When to replace the Oil Filter on your VW PASSAT
Recommended replacement interval for the part category Oil filter : 12 month / 15000 km
Important!
This replacement procedure can be used for:
VW PASSAT (3B2) 1.8, VW PASSAT (3B2) 2.0 4motion, VW PASSAT (3B2) 2.0, VW PASSAT (3B2) 2.3 VR5 Syncro/4motion, VW PASSAT (3B2) 1.8 Syncro/4motion, VW PASSAT (3B2) 2.8 V6 Syncro/4motion, VW PASSAT (3B2) 1.8 T, VW PASSAT (3B2) 1.8, VW PASSAT (3B2) 1.6 View more

The steps may slightly vary depending on the car design.

This video shows the replacement procedure of a similar car part on another vehicle

All the parts you need to replace – Oil Filter for PASSAT (3B2) and other VW models
Tools
Replacement: engine oil and filter – VW PASSAT (3B2). Tools you'll need:
Wire brush
All-purpose cleaning spray
Oil filter cup socket 76-14F
Drive socket # 19
Torx bit T20
Combination spanner #19
Ratchet wrench
Torque wrench
Oil drain pan
Funnel
Fender cover
Replacement: engine oil and filter – VW PASSAT (3B2). Tip from AUTODOC experts:
  • Replace the oil filter every time when changing motor oil.
  • Use only new O-rings during installation.
  • Wear gloves to prevent contact with hot liquid.
  • All work should be done with the engine stopped.
Replacement: engine oil and filter – VW PASSAT (3B2). Take the following steps:
  1. Step 1
    Open the hood.
    Step 2
    Use a fender protection cover to prevent damaging paintwork and plastic parts of the car.
    Step 3
    How to change Oil Filter on Passat 3b2 1996 - free PDF and video manuals
    Unscrew the oil filler plug.
  2. Step 4
    Lift the car using a jack or place it over an inspection pit.
    Replacement: engine oil and filter – VW PASSAT (3B2). AUTODOC recommends:
    The vehicle must be on even keel, and if it is at an angle, the drain plug must be at the lowest point.
    Step 5
    How to replace VW PASSAT (3B2) 1.9 TDI 1997 Oil Filter - step-by-step manuals and video guides
    Undo the fasteners of the oil pan lower cover. Use Torx T20. Use a ratchet wrench.
  3. Step 6
    Passat 3b2 1.8 T 1998 Oil Filter replacement: free workshop manuals
    Remove the oil pan cover.
  4. Step 7
    Changing Oil Filter on VW PASSAT (3B2) 1.8 1999 by yourself
    Put a waste oil container with at least 5 l capacity under the drainage hole.
  5. Step 8
    How to remove VW PASSAT 2.8 V6 Syncro/4motion 2000 Oil Filter - online easy-to-follow instructions
    Clean the area of the oil pan drainage hole. Use a wire brush. Use all-purpose cleaning spray.
  6. Step 9
    How to replace Oil Filter on VW PASSAT (3B2) 2001: download PDF manuals and video instructions
    Unscrew the drain plug. Use a combination spanner #19.
  7. Step 10
    How hard is it to do yourself: Oil Filter replacement on Passat 3b2 2.3 VR5 1996 - download illustrated guide
    Drain the used oil.
    Replacement: engine oil and filter – VW PASSAT (3B2). Tip from AUTODOC:
    Caution! The oil may be hot.
  8. Step 11
    Need to know how to renew Oil Filter on VW PASSAT 1997? This free workshop manual will help you to do it yourself
    Clean the oil filter seat. Use all-purpose cleaning spray.
  9. Step 12
    Prepare a container for the old oil filter.
    Step 13
    Changing of Oil Filter on Passat 3b2 1998 won't be an issue if you follow this illustrated step-by-step guide
    Unscrew the oil filter. Use the 76-14F socket. Use a ratchet wrench.
  10. Step 14
    VW PASSAT 1.9 TDI Oil Filter replacement: online guides and video tutorials
    Put the old oil filter in the container.
    Replacement: engine oil and filter – VW PASSAT (3B2). Tip from AUTODOC experts:
    Move up the container. The oil starts to drain out of the drainage hole immediately after you have removed the oil filter.
  11. Step 15
    Replacing Oil Filter on Passat 3b2 2000 1.9 TDI by yourself
    Clean the oil filter seat.
  12. Step 16
    PASSAT (3B2) 2.8 V6 Syncro/4motion 2001 Oil Filter DIY replacement workshop manual
    Lubricate the rubber seal of the new filter with a little amount of fresh oil.
  13. Step 17
    How to change Oil Filter on VW PASSAT (3B2) 1996 - tips and tricks
    Screw the new filter into its place. Use the 76-14F socket. Use a torque wrench. Tighten it to 18 Nm torque.
    Replacement: engine oil and filter – VW PASSAT (3B2). Professionals recommend:
    Wait until the oil has completely drained from the drainage hole.
  14. Step 18
    Step-by-step recommendations for DIY replacement Passat 3b2 1997 2.8 V6 Syncro/4motion Oil Filter
    Clean the area of the oil pan drainage hole.
Was this manual helpful?
Please rate this manual on a scale from 1 to 5. If you have any questions, feel free to ask us.
Users voted – 0
Your profile is your personal assistant.

It can track car expenses, keep a car log and replacement schedule, and save favourite materials, notes and documents

Install the AUTODOC CLUB app!
Your personal car expenses manager, maintenance tips, reminders about upcoming appointments and service intervals, DIY repair instructions – all this on your phone.
VW PASSAT (3B2) Oil Filter replace by yourself - Scan QR-code and download AUTODOC CLUB app
Scan

To download the app:

  • - scan the QR code
  • - download from App Store
  • - download from Google Play
DIY VW PASSAT (3B2) Oil Filter replacement - online guide
Tips & tricks for your VW PASSAT (3B2)
View more
  • How to change Oil filters on VW PASSAT (3B2) 1.6 - replacement tricks
    How to reduce fuel consumption | AUTODOC
  • Changing Engine oil filter Passat 3b2 1.9 TDI - Replacement Tips
    How to easily repair a punctured tyre | AUTODOC tips
  • Maintenance Hacks - VW PASSAT (3B2) 1.8 T Oil filters replacement guide
    How to start a car after a long idle period | AUTODOC tips
  • Replace Engine oil filter on Passat 3b2 - free video tips
    5 car tips for a winter's day | AUTODOC tips