Recommended replacement interval for the part category Oil filter : 12 month / 15000 km

Important!

This replacement procedure can be used for:
RENAULT EXPRESS Box Body / Estate 1.9 D … View more

The steps may slightly vary depending on the car design.

This video shows the replacement procedure of a similar car part on another vehicle

All the parts you need to replace – Oil Filter for EXPRESS Box Body / Estate and other RENAULT models

Oil filter

Oil filter for Express Box Body / Estate Diesel (64 hp)

Replacement: engine oil and filter – RENAULT EXPRESS Box Body / Estate. Tools you'll need:

                        Oil filter cup socket 76/14-F
                      
                        Impact socket №12
                      
                        Square oil drain plug socket No.8
                      
                        Ratchet wrench
                      
                        Torque wrench
                      
                        Oil drain pan
                      
                        Funnel
                      
                        Fender cover

Buy tools

Replacement: engine oil and filter – RENAULT EXPRESS Box Body / Estate. AUTODOC experts recommend:

Replace the oil filter every time when changing motor oil.
Wear gloves to prevent contact with hot liquid.
All work should be done with the engine stopped.

Replacement: engine oil and filter – RENAULT EXPRESS Box Body / Estate. Recommended sequence of steps:

Step 1

Open the hood.

Step 2

Use a fender protection cover to prevent damaging paintwork and plastic parts of the car.

Step 3

Unscrew the oil filler plug.
Step 4

Lift the car using a jack or place it over an inspection pit.

Replacement: engine oil and filter – RENAULT EXPRESS Box Body / Estate. Professionals recommend:
The vehicle must be on even keel, and if it is at an angle, the drain plug must be at the lowest point.All work should be done with the engine stopped.
Step 5

Remove the lower sound insulation. Use a drive socket #12. Use a ratchet wrench.
Step 6

Put a waste oil container with at least 5 l capacity under the drainage hole.
Step 7

Unscrew the drain plug. Use square oil drain plug socket No.8 Use a ratchet wrench.
Step 8

Drain the used oil.

Replacement: engine oil and filter – RENAULT EXPRESS Box Body / Estate. AUTODOC experts recommend:
Caution! The oil may be hot.Wait until the oil has completely drained from the drainage hole.
Step 9

Move the container under the oil filter.
Step 10

Unscrew the oil filter. Use the 76/14-F socket.
Step 11

Prepare a container for the old oil filter. Put the old oil filter in the container.

Replacement: engine oil and filter – RENAULT EXPRESS Box Body / Estate. Tip from AUTODOC:
Move up the container. The oil starts to drain out of the drainage hole immediately after you have removed the oil filter.
Step 12

Clean the oil filter seat.
Step 13

Lubricate the rubber seal of the new filter with a little amount of fresh oil.
Step 14

Screw the new filter into its place. Use the 76/14-F socket. Use a torque wrench. Tighten it to 21 nm torque.
Step 15

Clean the area of the oil pan drainage hole.
Step 16

Screw in the new drainage plug and tighten it. Use square oil drain plug socket No.8 Use a torque wrench. Tighten it to 20 nm torque.
Step 17

Install the lower sound insulation. Screw in the fasteners of the lower sound insulation. Use a drive socket #12. Use a ratchet wrench.
Step 18

Lower the car.

Step 19

Remove the oil filler cap. Insert the funnel.
Step 20

Pour new oil into the engine in the amount recommended by the car manufacturer.

Replacement: engine oil and filter – RENAULT EXPRESS Box Body / Estate. Tip:
Use the oil recommended by the manufacturer.
Step 21

Check the oil level using the dipstick. Top up oil if necessary.

Please note!
The oil level should be between the Min and Max marks.
Step 22

Tighten the oil filler cap.
Step 23

Run the engine for a few minutes. After the oil pressure warning light goes out, stop the engine.

Step 24

Check the oil level 5 minutes after the stop of the engine operation using a dipstick and add oil if necessary.

Please note!
The oil level should be between the Min and Max marks.Make sure that the oil filler cap is properly tightened.Check the threaded plug of the drainage hole and the oil filter seal for tightness. If necessary, carefully tighten them up.
Step 25

Remove the fender protection cover.

Step 26

Close the hood.

Replacement: engine oil and filter – RENAULT EXPRESS Box Body / Estate. Tip from AUTODOC experts:
Note that oil pressure warning light, which indicates insufficient pressure in the lubrication system, may be on for a longer time than usual. After a few seconds, the oil will fill all the channels, and the light will go out. To protect the environment from pollution, be sure to dispose of the used filters at special collection points.

Was this manual helpful?

Please rate this manual on a scale from 1 to 5. If you have any questions, feel free to ask us.

Searching for the right tyres?

Find out which tyre and wheel sizes are compatible with the RENAULT Express Box Body / Estate model.

Express tyre size

How to change front wheel bearing on RENAULT Express Box Body / Estate – replacement guide

Free download PDF
4.31 MB
How to change water pump & timing belt kit on Renault Clio 3 – replacement guide

Free download PDF
5.68 MB
How to change fuel filter on Renault Megane Scenic – replacement guide

Free download PDF
1.66 MB
How to change serpentine belt on Renault Clio 3 – replacement guide

Free download PDF
1.84 MB
How to change fuel filter on Renault Clio 3 – replacement guide

Free download PDF
1.84 MB
How to change rear brake pads on Renault Megane 2 – replacement guide

Free download PDF
2.49 MB

How to change engine oil and filter on RENAULT Express Pickup – replacement guide

Free download PDF
1.99 MB
How to change engine oil and filter on a car – replacement tutorial

Universal

Free download PDF
2.82 MB
How to change engine oil and filter on Renault Scenic 2 – replacement guide

Free download PDF
1.94 MB
How to change engine oil and filter on Renault Megane 2 – replacement guide

Free download PDF
2.51 MB
How to change engine oil and filter on Renault Clio 2 – replacement guide

Free download PDF
1.95 MB
How to change engine oil and filter on Renault Clio 3 – replacement guide

Free download PDF
1.95 MB

Your profile is your personal assistant.

It can track car expenses, keep a car log and replacement schedule, and save favourite materials, notes and documents

Install the AUTODOC CLUB app!

Your personal car expenses manager, maintenance tips, reminders about upcoming appointments and service intervals, DIY repair instructions – all this on your phone.

Scan

To download the app:

- scan the QR code
- download from App Store
- download from Google Play

How to prevent car windows from fogging up | AUTODOC tips

12K views

Published on: 04/02/2021
DIY jack restoration | AUTODOC tips

12K views

Published on: 22/09/2022
Important differences between car tools | AUTODOC tips

7K views

Published on: 16/12/2021
TOP 6 WD-40 lifehacks | AUTODOC tips

12K views

Published on: 15/07/2021