Recommended replacement interval for the part category Oil filter : 1 year / 30000 km

Important!

This replacement procedure can be used for:
OPEL INSIGNIA Estate 1.4 (35), OPEL INSIGNIA Estate 1.6 (35), OPEL INSIGNIA Estate 1.8 (35), OPEL INSIGNIA Estate 1.6 Turbo (35), OPEL INSIGNIA Estate 1.4 LPG (35) … View more

The steps may slightly vary depending on the car design.

This video shows the replacement procedure of a similar car part on another vehicle

All the parts you need to replace – Oil Filter for INSIGNIA Estate and other OPEL models

Oil filter

        Oil filter for Insignia A Sports Tourer (G09) Petrol (140 hp)
      
        Oil filter for Insignia A Sports Tourer (G09) Petrol (116 hp)
      
        Oil filter for Insignia A Sports Tourer (G09) Petrol (140 hp)
      
        Oil filter for Insignia A Sports Tourer (G09) Petrol (180 hp)
      
        Oil filter for Insignia A Sports Tourer (G09) Petrol/Petroleum Gas (LPG) (140 hp)

Replacement: engine oil and filter – OPEL INSIGNIA Estate. Tools you'll need:

                        Wire brush
                      
                        All-purpose cleaning spray
                      
                        Drive socket # 24 
                      
                        Torx bit T45
                      
                        Ratchet wrench
                      
                        Torque wrench
                      
                        Oil drain pan
                      
                        Funnel
                      
                        Flat Screwdriver
                      
                        Microfibre towel
                      
                        Fender cover

Buy tools

Replacement: engine oil and filter – OPEL INSIGNIA Estate. AUTODOC recommends:

Replace the oil filter every time when changing motor oil.
Wear gloves to prevent contact with hot liquid.
All work should be done with the engine stopped.

Replacement: engine oil and filter – OPEL INSIGNIA Estate. Recommended sequence of steps:

Step 1

Open the hood.

Step 2

Use a fender protection cover to prevent damaging paintwork and plastic parts of the car.

Step 3

Unscrew the oil filler plug.
Step 4

Lift the car using a jack or place it over an inspection pit.

Replacement: engine oil and filter – OPEL INSIGNIA Estate. Tip:
The vehicle must be on even keel, and if it is at an angle, the drain plug must be at the lowest point.All work should be done with the engine stopped.
Step 5

Put a waste oil container with at least 5 l capacity under the drainage hole.
Step 6

Clean the area of the oil pan drainage hole. Use a wire brush. Use all-purpose cleaning spray.
Step 7

Unscrew the drain plug. Use Torx T45. Use a ratchet wrench.
Step 8

Drain the used oil.

Replacement: engine oil and filter – OPEL INSIGNIA Estate. Tip from AUTODOC experts:
Caution! The oil may be hot.
Step 9

Clean the oil filter housing cap. Use all-purpose cleaning spray.
Step 10

Unscrew the filter housing cap together with the old filter element. Use a drive socket #24. Use a ratchet wrench.
Step 11

Prepare a container for the old oil filter.
Step 12

Put the old filter cartridge in the container.

Replacement: engine oil and filter – OPEL INSIGNIA Estate. AUTODOC experts recommend:
Move up the container. The oil starts to drain out of the drainage hole immediately after you have removed the oil filter.
Step 13

Cover the oil filter housing with a microfibre towel to prevent dirt and foreign objects from getting into the system.

Step 14

Detach the oil filter from the filter cover.
Step 15

Remove the oil filter cover O-ring. Use a flat screwdriver.
Step 16

Clean the oil filter housing cap. Use all-purpose cleaning spray.
Step 17

Install a new O-ring to its mounting seat on the filter cover.
Step 18

Install the new oil filter to the mounting seat on the filter cover.

Please note!
Make sure to install the filter correctly. Don't mix up the sides of the part.Wait until the oil has completely drained from the drainage hole.
Step 19

Clean the area of the oil pan drainage hole.
Step 20

Screw in the new drainage plug and tighten it. Use Torx T45. Use a torque wrench. Tighten it to 14 Nm torque.
Step 21

Clean the area of the oil pan drainage hole. Use all-purpose cleaning spray.
Step 22

Lower the car.

Step 23

Lubricate the rubber seal of the new filter with a little amount of fresh oil.
Step 24

Remove the microfibre towel from the oil filter housing.

Step 25

Screw the new filter into its place.
Step 26

Screw the cap. Use a drive socket #24. Use a torque wrench. Tighten it to 25 Nm torque.
Step 27

Remove the oil filler cap. Insert the funnel.
Step 28

Pour new oil into the engine in the amount recommended by the car manufacturer.

Replacement: engine oil and filter – OPEL INSIGNIA Estate. AUTODOC recommends:
Use the oil recommended by the manufacturer.
Step 29

Check the oil level using the dipstick. Top up oil if necessary.

Please note!
The oil level should be between the Min and Max marks.
Step 30

Install the oil filler cap. Tighten the oil filler cap.
Step 31

Run the engine for a few minutes. After the oil pressure warning light goes out, stop the engine.

Step 32

Check the oil level 5 minutes after the stop of the engine operation using a dipstick and add oil if necessary.

Please note!
The oil level should be between the Min and Max marks.Make sure that the oil filler cap is properly tightened.Check the threaded plug of the drainage hole and the oil filter seal for tightness. If necessary, carefully tighten them up.
Step 33

Remove the fender protection cover.

Step 34

Close the hood.

Replacement: engine oil and filter – OPEL INSIGNIA Estate. Tip from AUTODOC experts:
Note that oil pressure warning light, which indicates insufficient pressure in the lubrication system, may be on for a longer time than usual. After a few seconds, the oil will fill all the channels, and the light will go out. To protect the environment from pollution, be sure to dispose of the used filters at special collection points.

Was this manual helpful?

Please rate this manual on a scale from 1 to 5. If you have any questions, feel free to ask us.

Searching for the right tyres?

Find out which tyre and wheel sizes are compatible with the OPEL Insignia A Sports Tourer (G09) model.

Browse tyres

How to change spark plugs on OPEL INSIGNIA Estate – replacement guide

Free download PDF
1.08 MB
How to change front windshield wipers on OPEL Insignia A Sports Tourer (G09) – replacement guide

Free download PDF
1.43 MB
How to change rear windshield wipers on OPEL INSIGNIA Estate – replacement guide

Free download PDF
655.36 KB
How to change front anti roll bar links on OPEL INSIGNIA Estate – replacement guide

Free download PDF
1.39 MB
How to change headlight bulb on OPEL Insignia A Sports Tourer (G09) – replacement guide

Free download PDF
2.21 MB
How to change ignition coil on OPEL INSIGNIA Estate – replacement guide

Free download PDF
890.88 KB

How to change engine oil and filter on OPEL Insignia A Hatchback (G09) – replacement guide

Free download PDF
1.7 MB
How to change engine oil and filter on OPEL Insignia A Saloon (G09) – replacement guide

Free download PDF
1.7 MB
How to change engine oil and filter on OPEL INSIGNIA A Country Tourer (G09) – replacement guide

Free download PDF
1.6 MB
How to change engine oil and filter on a car – replacement tutorial

Universal

Free download PDF
2.82 MB
How to change engine oil and filter on Opel Meriva X03 – replacement guide

Free download PDF
1.87 MB
How to change engine oil and filter on Opel Corsa D – replacement guide

Free download PDF
3.03 MB

Your profile is your personal assistant.

It can track car expenses, keep a car log and replacement schedule, and save favourite materials, notes and documents

Install the AUTODOC CLUB app!

Your personal car expenses manager, maintenance tips, reminders about upcoming appointments and service intervals, DIY repair instructions – all this on your phone.

Scan

To download the app:

- scan the QR code
- download from App Store
- download from Google Play

What causes engine misfire? | AUTODOC

5K views

Published on: 10/07/2020
Coolant comparison test | AUTODOC

4K views

Published on: 13/10/2022
TOP 8 mistakes car owners make | AUTODOC tips

14K views

Published on: 09/12/2021
How to repair a chipped or cracked windscreen | AUTODOC tips

7K views

Published on: 14/12/2023