Recommended replacement interval for the part category Brake pad set : 30000 km

Important!

This replacement procedure can be used for:
VOLVO V70 I (875, 876) 2.4, VOLVO V70 I (875, 876) 2.4 Turbo AWD, VOLVO V70 I (875, 876) 2.5 TDI, VOLVO V70 I (875, 876) 2.3 Turbo, VOLVO V70 I (875, 876) 2.4 Bifuel, VOLVO V70 I (875, 876) 2.4, VOLVO V70 I (875, 876) 2.4 Turbo AWD, VOLVO V70 I (875, 876) 2.3 AWD, VOLVO V70 I (875, 876) 2.5 TDi AWD … View more

The steps may slightly vary depending on the car design.

This video shows the replacement procedure of a similar car part on another vehicle

Alternative products

Brake pad set

Replacement: brake pads – VOLVO V70 I (LV). Tools you might need:

                      Wire brush
                    
                      Brake cleaner 
                    
                      Anti-squeal paste
                    
                      Copper grease 
                    
                      HEX bit No.H7
                    
                      Brake caliper wind back tool
                    
                      Wheel impact socket #19
                    
                      Ratchet wrench
                    
                      Torque wrench
                    
                      Rubber mallet
                    
                      Crow bar
                    
                      Wheel chock

Buy tools

Replacement: brake pads – VOLVO V70 I (LV). AUTODOC experts recommend:

Perform the replacement of brake pads in complete set for each axis. This provides effective braking.
The replacement procedure is identical for all brake pads on the same axle.
Please note: all work on the car – VOLVO V70 I (LV) – should be done with the engine switched off.

Carry out replacement in the following order:

Step 1

Open the bonnet. Unscrew the brake fluid reservoir cap.

Step 2

Secure the wheels with chocks.
Step 3

Loosen the wheel mounting bolts. Use wheel impact socket #19.
Step 4

Raise the rear of the car and secure on supports.

Step 5

Unscrew the wheel bolts.

AUTODOC recommends:
Warning! To avoid injury, hold the wheel while unscrewing the fastening bolts. VOLVO V70 I (LV)
Step 6

Remove the wheel.
Step 7

Spread the brake pads. Use a crowbar.
Step 8

Remove the dust boot caps of the brake caliper guide pins. Use a crowbar.
Step 9

Unscrew the brake caliper fastening. Use HEX No.H7. Use a ratchet wrench.
Step 10

Detach the brake caliper retaining spring. Use a crowbar.
Step 11

Remove the brake caliper.

Replacement: brake pads – VOLVO V70 I (LV). AUTODOC experts recommend:
Tie the caliper to the suspension or to the body with a wire without disconnecting from the brake hose to prevent depressurization of the brake system.Make sure that the brake caliper is not hanging on the brake hose.Don't press the brake pedal after the brake caliper has been removed. As a result, the piston can fall out from the brake cylinder, and brake fluid leakage and depressurization of the system may occur. Check the brake caliper bracket, brake caliper guide pins and boots. Clean them. Replace, if necessary.
Step 12

Remove the brake pads. Use a crowbar.

Replacement: brake pads – VOLVO V70 I (LV). AUTODOC recommends:
Measure the brake disc thickness. Upon reaching the wear limit the part must be replaced.
Step 13

Clean the brake caliper bracket from dirt and dust. Use a wire brush. Use a brake cleaner.

AUTODOC recommends:
After applying the spray, wait a few minutes.
Step 14

Treat the brake caliper piston. Use a brake cleaner.

AUTODOC recommends:
Replacement: brake pads – VOLVO V70 I (LV). After applying the spray, wait a few minutes.
Step 15

Press in the brake caliper piston. Use brake caliper wind back tool.
Step 16

Treat the brake pads in the area where their surface comes into contact with the brake caliper bracket. Use anti-squeal paste.

Replacement: brake pads – VOLVO V70 I (LV). Professionals recommend:
Make sure the disc surface is clean before installing the pads.
Step 17

Install new brake pads.

Replacement: brake pads – VOLVO V70 I (LV). AUTODOC recommends:
Make sure the pads are installed with linings facing the disc.
Step 18

Install the brake caliper and fix it. Use HEX No.H7. Use a torque wrench. Tighten it to 30 Nm torque.
Step 19

Install the dust boot caps of the brake caliper guide pins.
Step 20

Install the brake caliper retaining spring. Use a rubber mallet. Use a crowbar.
Step 21

Treat the surface where the brake disc contacts the wheel rim. Use copper grease.
Step 22

Clean the brake disk surface. Use a brake cleaner.

AUTODOC recommends:
Replacement: brake pads – VOLVO V70 I (LV). After applying the spray, wait a few minutes.
Step 23

Install the wheel.

AUTODOC recommends:
Warning! To avoid injury, hold the wheel while screwing in the fastening bolts on the car. VOLVO V70 I (LV)
Step 24

Screw in the wheel bolts. Use wheel impact socket #19.
Step 25

Lower the car and working in a cross order, tighten the wheel bolts. Use a torque wrench. Tighten it to 140 Nm torque.
Step 26

Remove the jacks and chocks.

Replacement: brake pads – VOLVO V70 I (LV). Tip from AUTODOC:
Check the brake fluid level in the expansion tank and refill if necessary.
Step 27

Tighten the brake fluid reservoir cap.

Replacement: brake pads – VOLVO V70 I (LV). Professionals recommend:
Without starting the engine, press the brake pedal several times until you feel significant resistance.
Step 28

Close the hood.

Replacement: brake pads – VOLVO V70 I (LV). Tip from AUTODOC:
Slow down smoothly for first 150-200 km after the brake pads replacement. Avoid unneccessary and sharp braking to a stop.

Was this manual helpful?

Please rate this manual on a scale from 1 to 5. If you have any questions, feel free to ask us.

Need New Tyres?

Find out which tyre and wheel sizes are compatible with the VOLVO V70 I (LV, 875, 876) model

Volvo v70 1 tyre size

How to change rear brake discs on VOLVO V70 I (875, 876) – replacement guide

Free download PDF
2.01 MB
How to change front brake discs on VOLVO V70 I (875, 876) – replacement guide

Free download PDF
2.13 MB
How to change front brake pads on VOLVO V70 I (875, 876) – replacement guide

Free download PDF
1.58 MB
How to change spark plugs on VOLVO V70 I (875, 876) – replacement guide

Free download PDF
1.72 MB
How to change front windshield wipers on VOLVO V70 I (875, 876) – replacement guide

Free download PDF
593.92 KB
How to change engine oil and filter on VOLVO V70 I (LV, 875, 876) – replacement guide

Free download PDF
1.61 MB

How to change front brake pads on Volvo V70 SW – replacement guide

Free download PDF
1.77 MB
How to change rear brake pads on Volvo V70 SW – replacement guide

Free download PDF
1.69 MB
How to change front brake discs on Volvo V70 BW – replacement guide

Free download PDF
2.36 MB
How to change front brake pads on Volvo V70 BW – replacement guide

Free download PDF
1.72 MB
How to change rear brake discs on Volvo V70 BW – replacement guide

Free download PDF
2.25 MB
How to change rear brake pads on Volvo V70 BW – replacement guide

Free download PDF
1.6 MB

Unlock your car maintenance assistant!

Track expenses, manage logs, schedule replacements, and more.

DIY engine block coffee table

5K views

Published on: 25/09/2025
DIY manual gearbox restoration | Drivetrain restoration – Part 3

18K views

Published on: 14/11/2024
What to do if your car’s bonnet won’t open | AUTODOC tips

18K views

Published on: 12/09/2024
#TPMS Explained: Why Your Light is On and How to Respond Safely

9K views

Published on: 28/09/2023