Disclaimer
How to change rear brake pads on Volvo V70 SW – replacement guide
downloads:
7
Views:
135
Recommended replacement interval for the part category Brake pad set : 30000 km
Important!
This replacement procedure can be used for:
VOLVO V70 II (285) T5, VOLVO V70 II (285) 2.4 T, VOLVO V70 II (285) 2.5 TDI, VOLVO V70 II (285) 2.4, VOLVO V70 II (285) 2.4, VOLVO V70 II (285) D5, VOLVO V70 II (285) 2.4 Bifuel (CNG), VOLVO V70 II (285) 2.4 T AWD, VOLVO V70 II (285) 2.4 D, VOLVO V70 II (285) 2.5 T AWD, VOLVO V70 II (285) D5 AWD, VOLVO V70 II (285) 2.5 T, VOLVO V70 II (285) T5, VOLVO V70 II (285) D5, VOLVO V70 II (285) D5 AWD, VOLVO V70 II (285) 2.4 D, VOLVO V70 II (285) 2.3, VOLVO V70 II (285) 2.4 Bifuel (LPG), VOLVO V70 II (285) 2.4 D5, VOLVO V70 II (285) 2.4 CDI … View more
The steps may slightly vary depending on the car design.
VOLVO V70 II (285) T5, VOLVO V70 II (285) 2.4 T, VOLVO V70 II (285) 2.5 TDI, VOLVO V70 II (285) 2.4, VOLVO V70 II (285) 2.4, VOLVO V70 II (285) D5, VOLVO V70 II (285) 2.4 Bifuel (CNG), VOLVO V70 II (285) 2.4 T AWD, VOLVO V70 II (285) 2.4 D, VOLVO V70 II (285) 2.5 T AWD, VOLVO V70 II (285) D5 AWD, VOLVO V70 II (285) 2.5 T, VOLVO V70 II (285) T5, VOLVO V70 II (285) D5, VOLVO V70 II (285) D5 AWD, VOLVO V70 II (285) 2.4 D, VOLVO V70 II (285) 2.3, VOLVO V70 II (285) 2.4 Bifuel (LPG), VOLVO V70 II (285) 2.4 D5, VOLVO V70 II (285) 2.4 CDI … View more
The steps may slightly vary depending on the car design.
How to change rear brake pads / rear brake pad set on VOLVO V70 2 (SW) [TUTORIAL AUTODOC]
All the parts you need to replace – Brake Pads for V70 II (285) and other VOLVO models
Brake pad set
Brake pad set
Brake pad set for VOLVO V70 II (285) 2.4 Bifuel (CNG) Petrol/Natural Gas (CNG) (140 hp)
Brake pad set for VOLVO V70 II (285) 2.4 T AWD Petrol (200 hp)
Brake pad set for VOLVO V70 II (285) 2.4 D Diesel (131 hp)
Wire brush
Brake cleaner
Anti-squeal paste
Copper grease
HEX bit No.H7
Brake caliper wind back tool
Wheel impact socket #19
Ratchet wrench
Torque wrench
Rubber mallet
Crow bar
Wheel chock
Replacement: brake pads – Volvo V70 SW. AUTODOC experts recommend:
- Perform the replacement of brake pads in complete set for each axis. This provides effective braking.
- The replacement procedure is identical for all brake pads on the same axle.
- Please note: all work on the car – Volvo V70 SW – should be done with the engine switched off.
Carry out replacement in the following order:
- Step 1
Open the bonnet. Unscrew the brake fluid reservoir cap. - Step 2
Secure the wheels with chocks. - Step 3
Loosen the wheel mounting bolts. Use wheel impact socket #19. - Step 4
Raise the rear of the car and secure on supports. - Step 5
Unscrew the wheel bolts.AUTODOC recommends:Warning! To avoid injury, hold the wheel while unscrewing the fastening bolts. Volvo V70 SW - Step 6
Remove the wheel. - Step 7
Spread the brake pads. Use a crowbar. - Step 8
Remove the dust boot caps of the brake caliper guide pins. Use a crowbar. - Step 9
Unscrew the brake caliper fastening. Use HEX No.H7. Use a ratchet wrench. - Step 10
Detach the brake caliper retaining spring. Use a crowbar. - Step 11
Remove the brake caliper.Replacement: brake pads – Volvo V70 SW. AUTODOC experts recommend:Tie the caliper to the suspension or to the body with a wire without disconnecting from the brake hose to prevent depressurization of the brake system.Make sure that the brake caliper is not hanging on the brake hose.Don't press the brake pedal after the brake caliper has been removed. As a result, the piston can fall out from the brake cylinder, and brake fluid leakage and depressurization of the system may occur. Check the brake caliper bracket, brake caliper guide pins and boots. Clean them. Replace, if necessary. - Step 12
Remove the brake pads. Use a crowbar.Replacement: brake pads – Volvo V70 SW. AUTODOC recommends:Measure the brake disc thickness. Upon reaching the wear limit the part must be replaced. - Step 13
Clean the brake caliper bracket from dirt and dust. Use a wire brush. Use a brake cleaner.AUTODOC recommends:After applying the spray, wait a few minutes. - Step 14
Treat the brake caliper piston. Use a brake cleaner.AUTODOC recommends:Replacement: brake pads – Volvo V70 SW. After applying the spray, wait a few minutes. - Step 15
Press in the brake caliper piston. Use brake caliper wind back tool. - Step 16
Treat the brake pads in the area where their surface comes into contact with the brake caliper bracket. Use anti-squeal paste.Replacement: brake pads – Volvo V70 SW. Professionals recommend:Make sure the disc surface is clean before installing the pads.
Was this manual helpful?
Please rate this manual on a scale from 1 to 5. If you have any questions, feel free to ask us.
Users voted – 0
Popular maintenance tutorials for Volvo V70 Mk2
Free download PDF
2.16 MB
Free download PDF2.25 MB
Free download PDF1.77 MB
Free download PDF2.02 MB
Free download PDF593.92 KB
Free download PDF614.4 KB
Complete guides for changing the Brake pad set on different VOLVO V70 models
- Free download PDF1.77 MB
Free download PDF2.36 MB
Free download PDF1.72 MB
Free download PDF2.25 MB
Free download PDF1.6 MB
Free download PDF1.54 MB
Your profile is your personal assistant.
It can track car expenses, keep a car log and replacement schedule, and save favourite materials, notes and documents
Install the AUTODOC CLUB app!
Your personal car expenses manager, maintenance tips, reminders about upcoming appointments and service intervals, DIY repair instructions – all this on your phone.
Scan
To download the app:
- - scan the QR code
- - download from App Store
- - download from Google Play
Tips & tricks for your VOLVO V70 II (285)
View more
What to do if the ABS light comes on | AUTODOC tips
How to check your head gasket | AUTODOC
How to repair a chipped or cracked windscreen | AUTODOC tips
How do EGR valves work? | AUTODOC
