How to carry out replacement: Brake Pads 1.6 16V Renault Megane 1 Grandtour
Disclaimer
Change Renault Megane 1 Grandtour 1.6 16V Brake Pads yourself – manuals and video tutorials

How to change rear brake pads on RENAULT MEGANE I Grandtour (KA0/1_) – replacement guide

downloads: 1
Views: 13
Download your free tutorial and fix RENAULT MEGANE I Grandtour (KA0/1_) 1.6 e problems yourself Download for free 1.31 MB Brake Pads for Renault Megane 1 Grandtour Shop now
Leave a comment Open in a new tab
When to replace the Brake Pads on your RENAULT MEGANE
Recommended replacement interval for the part category Brake pad set : 30000 km
Important!
This replacement procedure can be used for:
RENAULT MEGANE I Grandtour (KA0/1_) 1.4 16V (KA0D, KA1H, KA0W, KA10), RENAULT MEGANE I Grandtour (KA0/1_) 1.6 16V (KA0B, KA04, KA11), RENAULT MEGANE I Grandtour (KA0/1_) 1.9 dCi (KA05, KA1F), RENAULT MEGANE I Grandtour (KA0/1_) 1.9 dTi (KA1U), RENAULT MEGANE I Grandtour (KA0/1_) 1.8 16V (KA0S, KA12, KA1A, KA1M, KA1R), RENAULT MEGANE I Grandtour (KA0/1_) 1.9 dCi … View more

The steps may slightly vary depending on the car design.

This video shows the replacement procedure of a similar car part on another vehicle

All the parts you need to replace – Brake Pads for MEGANE I Grandtour (KA0/1_) and other RENAULT models
Alternative products
How to change Brake pad set on Renault Megane 1 Grandtour 1.6 16V – step-by-step instructions for straightforward car repair Brake pad set
Tools
Replacement: brake pads – RENAULT MEGANE I Grandtour (KA0/1_). List of the tools you'll need:
Wire brush
Nylon cleaning brush
WD-40 spray
Brake cleaner
Anti-squeal paste
Copper grease
Torque wrench
Combination spanner #13
Combination spanner #15
Drive socket # 13
Wheel impact socket #19
Ratchet wrench
Brake caliper wind back tool
Crow bar
Wheel chock
Buy tools
Replacement: brake pads – RENAULT MEGANE I Grandtour (KA0/1_). AUTODOC recommends:
  • Perform the replacement of brake pads in complete set for each axis. This provides effective braking.
  • The replacement procedure is identical for all brake pads on the same axle.
  • All work should be done with the engine stopped.
Carry out replacement in the following order:
  1. Step 1
    Open the bonnet. Unscrew the brake fluid reservoir cap.
    Step 2
    Secure the wheels with chocks.
    Step 3
    How to change Brake Pads on Renault Megane 1 Grandtour 1999 - free PDF and video manuals
    Loosen the wheel mounting bolts. Use wheel impact socket #19.
  2. Step 4
    Raise the car.
    AUTODOC recommends:
    If you are using a jack, make sure it rests on a flat surface without any unevenness.Be sure to additionally secure the car with jack stands.
    Step 5
    How to replace RENAULT MEGANE I Grandtour (KA0/1_) 1.6 16V 2000 Brake Pads - step-by-step manuals and video guides
    Unscrew the wheel bolts.
    AUTODOC recommends:
    Warning! To avoid injury, hold the wheel while unscrewing the fastening bolts. RENAULT MEGANE I Grandtour (KA0/1_)
  3. Step 6
    Renault Megane 1 Grandtour 1.4 16V 2001 Brake Pads replacement: free workshop manuals
    Remove the wheel.
  4. Step 7
    Changing Brake Pads on RENAULT MEGANE I Grandtour (KA0/1_) 1.9 dTi 2002 by yourself
    Clean the brake caliper fasteners. Use a wire brush. Use WD-40 spray.
  5. Step 8
    How to remove RENAULT MEGANE 1.8 16V 2003 Brake Pads - online easy-to-follow instructions
    Unscrew the brake caliper fastening. Use a combination spanner #15. Use a drive socket #13. Use a ratchet wrench.
  6. Step 9
    How to replace Brake Pads on RENAULT MEGANE I Grandtour (KA0/1_) 1999: download PDF manuals and video instructions
    Remove the brake caliper.
    Replacement: brake pads – RENAULT MEGANE I Grandtour (KA0/1_). AUTODOC experts recommend:
    Tie the caliper to the suspension or to the body with a wire without disconnecting from the brake hose to prevent depressurization of the brake system.Make sure that the brake caliper is not hanging on the brake hose.Don't press the brake pedal after the brake caliper has been removed. As a result, the piston can fall out from the brake cylinder, and brake fluid leakage and depressurization of the system may occur.
  7. Step 10
    How hard is it to do yourself: Brake Pads replacement on Renault Megane 1 Grandtour 1.4 e 2000 - download illustrated guide
    Remove the brake pads. Use a crowbar.
    Replacement: brake pads – RENAULT MEGANE I Grandtour (KA0/1_). AUTODOC recommends:
    Measure the brake disc thickness. Upon reaching the wear limit the part must be replaced.
  8. Step 11
    Need to know how to renew Brake Pads on RENAULT MEGANE 2001? This free workshop manual will help you to do it yourself
    Clean the brake caliper bracket from dirt and dust. Use a wire brush. Use a brake cleaner.
    AUTODOC recommends:
    Replacement: brake pads – RENAULT MEGANE I Grandtour (KA0/1_). After applying the spray, wait a few minutes.Check the brake caliper bracket, brake caliper guide pins and boots. Clean them. Replace, if necessary.
  9. Step 12
    Changing of Brake Pads on Renault Megane 1 Grandtour 2002 won't be an issue if you follow this illustrated step-by-step guide
    Treat the brake pads in the area where their surface comes into contact with the brake caliper bracket. Use anti-squeal paste.
    Replacement: brake pads – RENAULT MEGANE I Grandtour (KA0/1_). Tip from AUTODOC experts:
    Make sure the disc surface is clean before installing the pads.
  10. Step 13
    RENAULT MEGANE 1.6 16V Brake Pads replacement: online guides and video tutorials
    Install new brake pads.
  11. Step 14
    Replacing Brake Pads on Renault Megane 1 Grandtour 1999 1.6 16V by yourself
    Treat the brake caliper piston. Use a nylon cleaning brush. Use a brake cleaner.
    AUTODOC recommends:
    After applying the spray, wait a few minutes.
Was this manual helpful?
Please rate this manual on a scale from 1 to 5. If you have any questions, feel free to ask us.
Users voted – 0
Need New Tyres?

Find out which tyre and wheel sizes are compatible with the RENAULT Megane I Grandtour (KA) model

Renault Megane 1 Grandtour tyre size

Popular maintenance tutorials for Renault Megane 1 Grandtour

More manuals for Renault Megane 1 Grandtour

Complete guides for changing the Brake pad set on different RENAULT MEGANE models

Unlock your car maintenance assistant!

Track expenses, manage logs, schedule replacements, and more.

DIY RENAULT MEGANE I Grandtour (KA0/1_) Brake Pads replacement - online guide
Tips & tricks for your RENAULT MEGANE I Grandtour (KA0/1_)
View more
  • How to change Brake pad set on RENAULT MEGANE I Grandtour (KA0/1_) 1.9 dCi - replacement tricks
    Prevent Engine Damage: How to Identify Rocker Cover Gasket Issues and Proper Replacement | AUTODOC
    5K views
    Published on: 03/12/2020
  • Changing Disc pads Renault Megane 1 Grandtour 1.6 16V - Replacement Tips
    Transform Your Car's Look: 6 Simple Accessories You Need to Try!
    3K views
    Published on: 18/11/2021
  • Maintenance Hacks - RENAULT MEGANE I Grandtour (KA0/1_) 1.4 16V Brake pad kit replacement guide
    Engine Overheating? Replace Your Cooling Fan to Fix It
    6K views
    Published on: 15/11/2020
  • Replace Disc brake pads on Renault Megane 1 Grandtour - free video tips
    How to easily repair a punctured tyre | AUTODOC tips
    3K views
    Published on: 25/02/2021

Most commonly replaced car parts on RENAULT MEGANE

Professional manuals for the most common RENAULT models

Autodoc CLUB App icon
Time to replace parts? Get even better deals in our Shop app.
RENAULT MEGANE I Grandtour (KA0/1_) Brake Pads replace by yourself - Scan QR-code and download AUTODOC CLUB app
SCAN ME