How to carry out replacement: Brake Pads 4.5 Porsche 928 Coupe
Disclaimer
Change Porsche 928 Coupe 4.5 Brake Pads yourself – manuals and video tutorials

How to change rear brake pads on PORSCHE 928 Coupe – replacement guide

downloads: 3
Views: 51
Download your free tutorial and fix PORSCHE 928 Coupe 5.0 S problems yourself Download for free 1.43 MB Brake Pads for Porsche 928 Coupe Shop now
Leave a comment Open in a new tab
When to replace the Brake Pads on your PORSCHE 928
Recommended replacement interval for the part category Brake pad set : 30000 km
Important!
This replacement procedure can be used for:
PORSCHE 928 Coupe 5.0 S4 Cat, PORSCHE 928 Coupe 5.0 GT … View more

The steps may slightly vary depending on the car design.

This video shows the replacement procedure of a similar car part on another vehicle

All the parts you need to replace – Brake Pads for 928 Coupe and other PORSCHE models
How to change Brake pad set on Porsche 928 Coupe 4.5 – step-by-step instructions for straightforward car repair Brake pad set
How to change Brake pad set on 928 Coupe – tips for proper car maintenance
Brake pad set for 928 Coupe Petrol (320 hp)
Simple DIY car repair steps – Replacing Brake pad set on 928 Coupe
Brake pad set for 928 Coupe Petrol (330 hp)
Tools
Replacement: brake pads – PORSCHE 928. List of the tools you'll need:
Wire brush
Nylon cleaning brush
WD-40 spray
Brake cleaner
Anti-squeal paste
Copper grease
Torque wrench
Combination spanner #13
Combination spanner #15
Drive socket # 13
Wheel impact socket #17
Ratchet wrench
Water pump pliers
Brake caliper wind back tool
Crow bar
Wheel chock
Buy tools
Replacement: brake pads – PORSCHE 928. Tip from AUTODOC experts:
  • Perform the replacement of brake pads in complete set for each axis. This provides effective braking.
  • The replacement procedure is identical for all brake pads on the same axle.
  • Please note: all work on the car – PORSCHE 928 – should be done with the engine switched off.
Carry out replacement in the following order:
  1. Step 1
    Open the hood. Unscrew the brake fluid reservoir cap.
    Step 2
    Secure the wheels with chocks.
    Step 3
    How to change Brake Pads on Porsche 928 Coupe 1977 - free PDF and video manuals
    Loosen the wheel mounting bolts. Use wheel impact socket #17.
  2. Step 4
    Raise the rear of the car and secure on supports.
    Step 5
    Unscrew the wheel bolts.
    AUTODOC recommends:
    Warning! To avoid injury, hold the wheel while unscrewing the fastening bolts. PORSCHE 928
    Step 6
    How to replace PORSCHE 928 Coupe 4.5 1978 Brake Pads - step-by-step manuals and video guides
    Remove the wheel.
  3. Step 7
    Porsche 928 Coupe 4.7 S 1979 Brake Pads replacement: free workshop manuals
    Clean the fastener of the parking brake cable. Use a wire brush. Use WD-40 spray.
  4. Step 8
    Changing Brake Pads on PORSCHE 928 Coupe 5.0 S, S4 1980 by yourself
    Release the parking brake cable. Use water pump pliers. Use a crowbar.
  5. Step 9
    How to remove PORSCHE 928 5.0 GT 1981 Brake Pads - online easy-to-follow instructions
    Clean the brake caliper fasteners. Use a wire brush. Use WD-40 spray.
  6. Step 10
    How to replace Brake Pads on PORSCHE 928 Coupe 1982: download PDF manuals and video instructions
    Unscrew the brake caliper fastening. Use a combination spanner #13. Use a combination spanner #15. Use a ratchet wrench.
  7. Step 11
    How hard is it to do yourself: Brake Pads replacement on Porsche 928 Coupe 5.0 S (M 28.45, M 28.46) 1983 - download illustrated guide
    Remove the brake caliper. Use a crowbar.
    Replacement: brake pads – PORSCHE 928. Tip from AUTODOC experts:
    Tie the caliper to the suspension or to the body with a wire without disconnecting from the brake hose to prevent depressurization of the brake system.Make sure that the brake caliper is not hanging on the brake hose.Don't press the brake pedal after the brake caliper has been removed. As a result, the piston can fall out from the brake cylinder, and brake fluid leakage and depressurization of the system may occur.Check the brake caliper bracket, brake caliper guide pins and boots. Clean them. Replace, if necessary.
  8. Step 12
    Need to know how to renew Brake Pads on PORSCHE 928 1984? This free workshop manual will help you to do it yourself
    Remove the brake pads.
    Replacement: brake pads – PORSCHE 928. AUTODOC experts recommend:
    Measure the brake disc thickness. Upon reaching the wear limit the part must be replaced.
  9. Step 13
    Changing of Brake Pads on Porsche 928 Coupe 1985 won't be an issue if you follow this illustrated step-by-step guide
    Clean the brake caliper bracket from dirt and dust. Use a wire brush. Use a brake cleaner.
    AUTODOC recommends:
    Replacement: brake pads – PORSCHE 928. After applying the spray, wait a few minutes.
  10. Step 14
    PORSCHE 928 4.5 Brake Pads replacement: online guides and video tutorials
    Treat the brake pads in the area where their surface comes into contact with the brake caliper bracket. Use anti-squeal paste.
    Replacement: brake pads – PORSCHE 928. Tip:
    Make sure the disc surface is clean before installing the pads.
  11. Step 15
    Replacing Brake Pads on Porsche 928 Coupe 1987 4.5 by yourself
    Install new brake pads.
    Replacement: brake pads – PORSCHE 928. Tip from AUTODOC experts:
    Make sure the pads are installed with linings facing the disc.
  12. Step 16
    928 Coupe 5.0 GT 1988 Brake Pads DIY replacement workshop manual
    Treat the brake caliper piston. Use a nylon cleaning brush. Use a brake cleaner.
    AUTODOC recommends:
    Replacement: brake pads – PORSCHE 928. After applying the spray, wait a few minutes.
Was this manual helpful?
Please rate this manual on a scale from 1 to 5. If you have any questions, feel free to ask us.
Users voted – 0
Searching for the right tyres?

Find out which tyre and wheel sizes are compatible with the PORSCHE 928 Coupe model.

Porsche 928 Coupe tyre size

Popular maintenance tutorials for Porsche 928 Coupe

More manuals for Porsche 928 Coupe

Complete guides for changing the Brake pad set on different PORSCHE 928 models

Your profile is your personal assistant.

It can track car expenses, keep a car log and replacement schedule, and save favourite materials, notes and documents

Install the AUTODOC CLUB app!
Your personal car expenses manager, maintenance tips, reminders about upcoming appointments and service intervals, DIY repair instructions – all this on your phone.
PORSCHE 928 Coupe Brake Pads replace by yourself - Scan QR-code and download AUTODOC CLUB app
Scan

To download the app:

  • - scan the QR code
  • - download from App Store
  • - download from Google Play
DIY PORSCHE 928 Coupe Brake Pads replacement - online guide
Tips & tricks for your PORSCHE 928 Coupe
View more
  • How to change Brake pad set on PORSCHE 928 Coupe 5.0 S4 Cat - replacement tricks
    DIY jack restoration | AUTODOC tips
    12K views
    Published on: 22/09/2022
  • Changing Disc pads Porsche 928 Coupe 4.5 - Replacement Tips
    What to do if the belt squeals | AUTODOC tips
    4K views
    Published on: 04/03/2021
  • Maintenance Hacks - PORSCHE 928 Coupe 4.7 S Brake pad kit replacement guide
    DIY brake caliper restoration | AUTODOC tips
    562K views
    Published on: 02/06/2022
  • Replace Disc brake pads on Porsche 928 Coupe - free video tips
    4 reasons why your CHECK ENGINE light is on | AUTODOC tips
    6K views
    Published on: 30/03/2022

Most commonly replaced car parts on PORSCHE 928

Professional manuals for the most common PORSCHE models