When to replace the Brake Pads on your BMW i3
Recommended replacement interval for the part category Brake pad set : 30000 km
Important!
This replacement procedure can be used for:
BMW i3 (I01) Range Extender, BMW i3 (I01) Electric, BMW i3 (I01) s Range Extender, BMW i3 (I01) s Electric, BMW i3 (I01) s Range Extender 0.65 View more

The steps may slightly vary depending on the car design.

This video shows the replacement procedure of a similar car part on another vehicle

Tools
Replacement: brake pads – BMW i3 (I01). Tools you might need:
Wire brush
Brake cleaner
Anti-squeal paste
Copper grease
HEX bit no.H7.
Wheel impact socket #17
Ratchet wrench
Torque wrench
Brake caliper wind back tool
Crow bar
Fender cover
Wheel chock
Replacement: brake pads – BMW i3 (I01). Tip from AUTODOC experts:
  • Perform the replacement of brake pads in complete set for each axis. This provides effective braking.
  • The replacement procedure is identical for all brake pads on the same axle.
  • All work should be done with the engine stopped.
Replacement: brake pads – BMW i3 (I01). Take the following steps:
  1. Step 1
    Open the bonnet.
    Step 2
    Use a fender protection cover to prevent damaging paintwork and plastic parts of the car.
    Step 3
    How to change Brake Pads on BMW I01 2013 - free PDF and video manuals
    Remove the wiper arm cover.
  2. Step 4
    How to replace BMW i3 (I01) Elektrik 2014 Brake Pads - step-by-step manuals and video guides
    Unscrew the brake fluid reservoir cap.
  3. Step 5
    BMW I01 Electric 2015 Brake Pads replacement: free workshop manuals
    Secure the wheels with chocks.
  4. Step 6
    Changing Brake Pads on BMW i3 (I01) s Elektrik 2016 by yourself
    Loosen the wheel mounting bolts. Use wheel impact socket #17.
  5. Step 7
    Raise the rear of the car and secure on supports.
    Step 8
    How to remove BMW i3 s Range Extender 0.65 2017 Brake Pads - online easy-to-follow instructions
    Unscrew the wheel bolts.
    AUTODOC recommends:
    Warning! To avoid injury, hold the wheel while unscrewing the fastening bolts. BMW i3 (I01)
  6. Step 9
    How to replace Brake Pads on BMW i3 (I01) 2018: download PDF manuals and video instructions
    Remove the wheel.
  7. Step 10
    How hard is it to do yourself: Brake Pads replacement on BMW I01 Electric 2019 - download illustrated guide
    Disconnect the brake pads wear sensor. Use a crowbar.
    Please note!
    Some cars are not equipped with the brake pad wear sensor.
  8. Step 11
    Need to know how to renew Brake Pads on BMW i3 2020? This free workshop manual will help you to do it yourself
    Remove the dust boot caps of the brake caliper guide pins. Use a crowbar.
  9. Step 12
    Changing of Brake Pads on BMW I01 2021 won't be an issue if you follow this illustrated step-by-step guide
    Unscrew the brake caliper fastening. Use HEX No.H7. Use a ratchet wrench.
  10. Step 13
    BMW i3 s Elektrik Brake Pads replacement: online guides and video tutorials
    Spread the brake pads. Use a crowbar.
  11. Step 14
    Replacing Brake Pads on BMW I01 2023 Elektrik by yourself
    Detach the brake caliper retaining spring. Use a crowbar.
  12. Step 15
    i3 (I01) s Range Extender 0.65 2024 Brake Pads DIY replacement workshop manual
    Remove the brake caliper.
    Replacement: brake pads – BMW i3 (I01). AUTODOC recommends:
    Tie the caliper to the suspension or to the body with a wire without disconnecting from the brake hose to prevent depressurization of the brake system.Make sure that the brake caliper is not hanging on the brake hose.Don't press the brake pedal after the brake caliper has been removed. As a result, the piston can fall out from the brake cylinder, and brake fluid leakage and depressurization of the system may occur. Check the brake caliper bracket, brake caliper guide pins and boots. Clean them. Replace, if necessary.
  13. Step 16
    How to change Brake Pads on BMW i3 (I01) 2013 - tips and tricks
    Remove the brake pads.
    Replacement: brake pads – BMW i3 (I01). Tip:
    Measure the brake disc thickness. Upon reaching the wear limit the part must be replaced.
  14. Step 17
    Step-by-step recommendations for DIY replacement BMW I01 2014 s Range Extender 0.65 Brake Pads
    Clean the brake caliper bracket from dirt and dust. Use a wire brush. Use a brake cleaner.
    Replacement: brake pads – BMW i3 (I01). Tip from AUTODOC:
    After applying the spray, wait a few minutes.
  15. Step 18
    DIY replacement of Brake Pads on BMW i3 (I01) Range Extender 2015 is not an issue anymore with our step-by-step tutorial
    Treat the brake caliper piston. Use a brake cleaner.
    AUTODOC recommends:
    Replacement: brake pads – BMW i3 (I01). After applying the spray, wait a few minutes.
  16. Step 19
    How to change Brake Pads on BMW I01 2013 - free PDF and video manuals
    Press in the brake caliper piston. Use brake caliper wind back tool.
  17. Step 20
    How to replace BMW i3 (I01) Elektrik 2014 Brake Pads - step-by-step manuals and video guides
    Treat the brake pads in the area where their surface comes into contact with the brake caliper bracket. Use anti-squeal paste.
    Replacement: brake pads – BMW i3 (I01). Professionals recommend:
    Make sure the disc surface is clean before installing the pads.
Was this manual helpful?
Please rate this manual on a scale from 1 to 5. If you have any questions, feel free to ask us.
Users voted – 0
Your profile is your personal assistant.

It can track car expenses, keep a car log and replacement schedule, and save favourite materials, notes and documents

Install the AUTODOC CLUB app!
Your personal car expenses manager, maintenance tips, reminders about upcoming appointments and service intervals, DIY repair instructions – all this on your phone.
BMW i3 (I01) Brake Pads replace by yourself - Scan QR-code and download AUTODOC CLUB app
Scan

To download the app:

  • - scan the QR code
  • - download from App Store
  • - download from Google Play
DIY BMW i3 (I01) Brake Pads replacement - online guide
Tips & tricks for your BMW i3 (I01)
View more
  • How to change Brake pad set on BMW i3 (I01) Range Extender - replacement tricks
    How to shine your tyres | AUTODOC tips
  • Changing Disc pads BMW I01 Elektrik - Replacement Tips
    How to remove scratches from car plastic | AUTODOC tips
  • Maintenance Hacks - BMW i3 (I01) Electric Brake pad kit replacement guide
    How to repair a bumper yourself | AUTODOC tips
  • Replace Disc brake pads on BMW I01 - free video tips
    How to fix your car with AUTODOC CLUB