When to replace the Brake Discs on your VW TRANSPORTER
Recommended replacement interval for the part category Brake disc : 50000 km
Important!
This replacement procedure can be used for:
VW Transporter V Van (7HA, 7HH, 7EA, 7EH) 1.9 TDI, VW Transporter V Van (7HA, 7HH, 7EA, 7EH) 2.5 TDI, VW Transporter V Van (7HA, 7HH, 7EA, 7EH) 2.5 TDI, VW Transporter V Van (7HA, 7HH, 7EA, 7EH) 2.0, VW Transporter V Van (7HA, 7HH, 7EA, 7EH) VR6 3.2, VW Transporter V Van (7HA, 7HH, 7EA, 7EH) 2.5 TDI 4motion, VW Transporter V Van (7HA, 7HH, 7EA, 7EH) 2.5 TDI 4motion, VW Transporter V Van (7HA, 7HH, 7EA, 7EH) 1.9 TDI, VW Transporter V Van (7HA, 7HH, 7EA, 7EH) VR6 3.2 4motion, VW Transporter V Van (7HA, 7HH, 7EA, 7EH) 1.9 TDI, VW Transporter V Van (7HA, 7HH, 7EA, 7EH) 2.0 BiFuel, VW Transporter V Van (7HA, 7HH, 7EA, 7EH) 1.9 TDI View more

The steps may slightly vary depending on the car design.

How to change rear brake discs on VW T5 TRANSPORTER Van [TUTORIAL AUTODOC]

video
All the parts you need to replace – Brake Discs for Transporter V Van (7HA, 7HH, 7EA, 7EH) and other VW models
Tools
Replacement: brake discs – VW T5 Transporter. Tools you might need:
Wire brush
Nylon cleaning brush
WD-40 spray
Brake cleaner
Copper grease
Torque wrench
Drive socket # 21
Drive socket # 22
XZN bit #10
Wheel impact socket #19
Ratchet wrench
Impact screwdriver
Tap wrench
Brake caliper wind back tool
Crow bar
Wheel chock
Replacement: brake discs – VW T5 Transporter. AUTODOC experts recommend:
  • Replace the brake disks on the car VW T5 Transporter in complete set for each axis. Regardless of the state of components. This will ensure even braking.
  • The replacement procedure is identical for both brake disks on the same axle.
  • When changing the brake discs, always replace the brake pads.
  • Please note: all work on the car – VW T5 Transporter – should be done with the engine switched off.
Carry out replacement in the following order:
  1. Step 1
    How to change Brake Discs on VW T5 2003 - free PDF and video manuals
    Open the bonnet. Unscrew the brake fluid reservoir cap.
  2. Step 2
    Secure the wheels with chocks.
    Step 3
    How to replace VW Transporter V Van (7HA, 7HH, 7EA, 7EH) 2.5 TDI 2004 Brake Discs - step-by-step manuals and video guides
    Loosen the wheel mounting bolts. Use wheel impact socket #19.
  3. Step 4
    VW T5 2.5 TDI 4motion 2005 Brake Discs replacement: free workshop manuals
    Raise the rear of the car and secure on supports.
  4. Step 5
    Changing Brake Discs on VW Transporter V Van (7HA, 7HH, 7EA, 7EH) 2.0 TDI 2006 by yourself
    Unscrew the wheel bolts.
    AUTODOC recommends:
    Warning! To avoid injury, hold the wheel while unscrewing the fastening bolts. VW T5 Transporter
  5. Step 6
    How to remove VW TRANSPORTER 2.5 TDI 2007 Brake Discs - online easy-to-follow instructions
    Remove the wheel.
  6. Step 7
    How to replace Brake Discs on VW Transporter V Van (7HA, 7HH, 7EA, 7EH) 2008: download PDF manuals and video instructions
    Detach the ABS sensor connector.
  7. Step 8
    How hard is it to do yourself: Brake Discs replacement on VW T5 1.9 TDI 2009 - download illustrated guide
    Clean the brake caliper fasteners. Use a wire brush. Use WD-40 spray.
  8. Step 9
    Need to know how to renew Brake Discs on VW TRANSPORTER 2010? This free workshop manual will help you to do it yourself
    Unscrew the brake caliper fastening. Use a drive socket #22. Use a ratchet wrench.
  9. Step 10
    Changing of Brake Discs on VW T5 2011 won't be an issue if you follow this illustrated step-by-step guide
    Spread the brake pads. Use a crowbar.
  10. Step 11
    VW TRANSPORTER 2.5 TDI Brake Discs replacement: online guides and video tutorials
    Remove the brake caliper.
    Replacement: brake discs – VW T5 Transporter. Tip from AUTODOC experts:
    Tie the caliper to the suspension or to the body with a wire without disconnecting from the brake hose to prevent depressurization of the brake system.Make sure that the brake caliper is not hanging on the brake hose.Don't press the brake pedal after the brake caliper has been removed. As a result, the piston can fall out from the brake cylinder, and brake fluid leakage and depressurization of the system may occur. Check the brake caliper bracket, brake caliper guide pins and boots. Clean them. Replace, if necessary.
  11. Step 12
    Replacing Brake Discs on VW T5 2013 2.5 TDI by yourself
    Remove the brake pads.
  12. Step 13
    Transporter V Van (7HA, 7HH, 7EA, 7EH) 2.5 TDI 2014 Brake Discs DIY replacement workshop manual
    Clean the brake caliper bracket fasteners. Use a wire brush. Use WD-40 spray.
  13. Step 14
    How to change Brake Discs on VW Transporter V Van (7HA, 7HH, 7EA, 7EH) 2015 - tips and tricks
    Unscrew the caliper bracket fastening. Use a drive socket #21. Use a ratchet wrench. Use a tap wrench.
  14. Step 15
    Step-by-step recommendations for DIY replacement VW T5 2016 2.5 TDI Brake Discs
    Remove the caliper bracket.
  15. Step 16
    Clean the brake disc fastener. Use a wire brush. Use WD-40 spray.
    Step 17
    DIY replacement of Brake Discs on VW Transporter V Van (7HA, 7HH, 7EA, 7EH) 1.9 TDI 2017 is not an issue anymore with our step-by-step tutorial
    Unscrew the brake disc fastening. Use XZN #10. Use an impact screwdriver.
  16. Step 18
    How to change Brake Discs on VW T5 2003 - free PDF and video manuals
    Remove the brake disc.
  17. Step 19
    How to replace VW Transporter V Van (7HA, 7HH, 7EA, 7EH) 2.5 TDI 2004 Brake Discs - step-by-step manuals and video guides
    Clean the hub. Use a wire brush. Treat the contacting surface. Use copper grease.
  18. Step 20
    VW T5 2.5 TDI 4motion 2005 Brake Discs replacement: free workshop manuals
    Install the brake disc.
  19. Step 21
    Changing Brake Discs on VW Transporter V Van (7HA, 7HH, 7EA, 7EH) 2.0 TDI 2006 by yourself
    Screw in the brake disc fastener. Use XZN #10. Use a ratchet wrench.
  20. Step 22
    How to remove VW TRANSPORTER 2.5 TDI 2007 Brake Discs - online easy-to-follow instructions
    Clean the brake caliper bracket from dirt and dust. Use a wire brush. Use a brake cleaner.
    AUTODOC recommends:
    Replacement: brake discs – VW T5 Transporter. After applying the spray, wait a few minutes.
Was this manual helpful?
Please rate this manual on a scale from 1 to 5. If you have any questions, feel free to ask us.
Users voted – 1
Your profile is your personal assistant.

It can track car expenses, keep a car log and replacement schedule, and save favourite materials, notes and documents

Install the AUTODOC CLUB app!
Your personal car expenses manager, maintenance tips, reminders about upcoming appointments and service intervals, DIY repair instructions – all this on your phone.
VW Transporter V Van (7HA, 7HH, 7EA, 7EH) Brake Discs replace by yourself - Scan QR-code and download AUTODOC CLUB app
Scan

To download the app:

  • - scan the QR code
  • - download from App Store
  • - download from Google Play
DIY VW Transporter V Van (7HA, 7HH, 7EA, 7EH) Brake Discs replacement - online guide
Tips & tricks for your VW Transporter V Van (7HA, 7HH, 7EA, 7EH)
View more
  • How to change Brake rotors on VW Transporter V Van (7HA, 7HH, 7EA, 7EH) 1.9 TDI - replacement tricks
    How to check your head gasket | AUTODOC
  • Changing Brake disc VW T5 2.5 TDI - Replacement Tips
    TOP 4 car cleaning products | AUTODOC tips
  • Maintenance Hacks - VW Transporter V Van (7HA, 7HH, 7EA, 7EH) 2.5 TDI 4motion Brake disc kit replacement guide
    5 common car washing mistakes | AUTODOC tips
  • Replace Disc brake set on VW T5 - free video tips
    DIY brake caliper restoration | AUTODOC tips