How to carry out replacement: Brake Discs 2.2 16V (F07) Opel Astra G Coupe
Disclaimer
Change Opel Astra G Coupe 2.2 DTI (F07) Brake Discs yourself – manuals and video tutorials

How to change rear brake discs on OPEL Astra G Coupe (T98) – replacement guide

downloads: 0
Views: 7
Download your free tutorial and fix OPEL Astra G Coupe (T98) 2.0 16V Turbo (F07) problems yourself Download for free 2.4 MB Brake Discs for Opel Astra G Coupe Shop now
Leave a comment Open in a new tab
When to replace the Brake Discs on your OPEL ASTRA
Recommended replacement interval for the part category Brake disc : 50000 km
Important!
This replacement procedure can be used for:
OPEL Astra G Coupe (T98) 1.6 16V (F07), OPEL Astra G Coupe (T98) 1.8 16V (F07), OPEL Astra G Coupe (T98) 2.0 16V Turbo (F07), OPEL Astra G Coupe (T98) 1.8 16V (F07), OPEL Astra G Coupe (T98) 2.2 16V (F07), OPEL Astra G Coupe (T98) 2.2 DTI (F07), OPEL Astra G Coupe (T98) 2.0 16V Turbo (F07), OPEL Astra G Coupe (T98) 2.0 16V Turbo (F07), OPEL Astra G Coupe (T98) 1.6 16V (F07) … View more

The steps may slightly vary depending on the car design.

This video shows the replacement procedure of a similar car part on another vehicle

All the parts you need to replace – Brake Discs for Astra G Coupe (T98) and other OPEL models
Alternative products
How to change Brake disc on Opel Astra G Coupe 2.2 16V (F07) – step-by-step instructions for straightforward car repair Brake disc
Tools
Replacement: brake discs – OPEL ASTRA G Coupe (F07_). Tools you need:
Wire brush
WD-40 spray
Brake cleaner
Copper grease
Torx bit T30
Drive socket # 11
Drive socket # 13
Drive socket # E20
Combination spanner #11
Combination spanner #13
Combination spanner #17
Wheel impact socket #17
Brake caliper wind back tool
Ratchet wrench
Torque wrench
Brake bleeder kit
Brake hose clip
Tap wrench
Crow bar
Rubber mallet
Wheel chock
Buy tools
Replacement: brake discs – OPEL ASTRA G Coupe (F07_). AUTODOC recommends:
  • Replace the brake disks on the car OPEL ASTRA G Coupe (F07_) in complete set for each axis. Regardless of the state of components. This will ensure even braking.
  • The replacement procedure is identical for both brake disks on the same axle.
  • When changing the brake discs, always replace the brake pads.
  • Please note: all work on the car – OPEL ASTRA G Coupe (F07_) – should be done with the engine switched off.
Carry out replacement in the following order:
  1. Step 1
    Open the bonnet. Unscrew the brake fluid reservoir cap.
    Step 2
    How to change Brake Discs on Opel Astra G Coupe 2000 - free PDF and video manuals
    Secure the wheels with chocks.
  2. Step 3
    How to replace OPEL Astra G Coupe (T98) 2.2 16V (F07) 2001 Brake Discs - step-by-step manuals and video guides
    Loosen the wheel mounting bolts. Use wheel impact socket #17.
  3. Step 4
    Raise the rear of the car and secure on supports.
    Step 5
    Opel Astra G Coupe 1.8 16V (F07) 2002 Brake Discs replacement: free workshop manuals
    Unscrew the wheel bolts.
    Replacement: brake discs – OPEL ASTRA G Coupe (F07_). Tip from AUTODOC:
    To avoid injury, hold up the wheel when unscrewing the bolts.
  4. Step 6
    Changing Brake Discs on OPEL Astra G Coupe (T98) 2.2 DTI (F07) 2003 by yourself
    Remove the wheel.
  5. Step 7
    How to remove OPEL ASTRA 1.6 16V (F07) 2004 Brake Discs - online easy-to-follow instructions
    Clean the brake caliper fasteners. Use a wire brush. Use WD-40 spray.
  6. Step 8
    How to replace Brake Discs on OPEL Astra G Coupe (T98) 2005: download PDF manuals and video instructions
    Clean the area where the brake hose is connected to the caliper, and the guide pins area. Use a wire brush. Use a brake cleaner.
    AUTODOC recommends:
    Replacement: brake discs – OPEL ASTRA G Coupe (F07_). After applying the spray, wait a few minutes.
  7. Step 9
    How hard is it to do yourself: Brake Discs replacement on Opel Astra G Coupe 1.8 16V (F07) 2000 - download illustrated guide
    Clamp the brake hose off using a brake hose clamp.
  8. Step 10
    Need to know how to renew Brake Discs on OPEL ASTRA 2001? This free workshop manual will help you to do it yourself
    Unscrew the brake hose from the brake caliper. Use a combination spanner #11.
  9. Step 11
    Changing of Brake Discs on Opel Astra G Coupe 2002 won't be an issue if you follow this illustrated step-by-step guide
    Disconnect the brake hose.
  10. Step 12
    OPEL ASTRA 2.2 DTI (F07) Brake Discs replacement: online guides and video tutorials
    Unscrew the brake caliper fastening. Use a combination spanner #13.
  11. Step 13
    Replacing Brake Discs on Opel Astra G Coupe 2004 2.2 16V (F07) by yourself
    Spread the brake pads. Use a crowbar.
  12. Step 14
    Astra G Coupe (T98) 1.6 16V (F07) 2005 Brake Discs DIY replacement workshop manual
    Remove the brake caliper. Use a crowbar.
    Replacement: brake discs – OPEL ASTRA G Coupe (F07_). Professionals recommend:
    Tie the caliper to the suspension or to the body with a wire without disconnecting from the brake hose to prevent depressurization of the brake system.Make sure that the brake caliper is not hanging on the brake hose.Don't press the brake pedal after the brake caliper has been removed. As a result, the piston can fall out from the brake cylinder, and brake fluid leakage and depressurization of the system may occur. Check the brake caliper bracket, brake caliper guide pins and boots. Clean them. Replace, if necessary.
  13. Step 15
    How to change Brake Discs on OPEL Astra G Coupe (T98) 2000 - tips and tricks
    Remove the brake pads. Use a crowbar.
  14. Step 16
    Step-by-step recommendations for DIY replacement Opel Astra G Coupe 2001 1.6 16V (F07) Brake Discs
    Clean the brake caliper bracket fasteners. Use a wire brush. Use a brake cleaner.
    Replacement: brake discs – OPEL ASTRA G Coupe (F07_). Tip from AUTODOC:
    After applying the spray, wait a few minutes.
  15. Step 17
    DIY replacement of Brake Discs on OPEL Astra G Coupe (T98) 2.0 16V Turbo (F07) 2002 is not an issue anymore with our step-by-step tutorial
    Unscrew the caliper bracket fastening. Use a drive socket #E20. Use a tap wrench.
  16. Step 18
    How to change Brake Discs on Opel Astra G Coupe 2000 - free PDF and video manuals
    Remove the caliper bracket.
  17. Step 19
    How to replace OPEL Astra G Coupe (T98) 2.2 16V (F07) 2001 Brake Discs - step-by-step manuals and video guides
    Clean the brake disc fasteners. Use a wire brush. Use WD-40 spray.
  18. Step 20
    Opel Astra G Coupe 1.8 16V (F07) 2002 Brake Discs replacement: free workshop manuals
    Unscrew the brake disc fastening. Use Torx T30. Use a ratchet wrench.
  19. Step 21
    Changing Brake Discs on OPEL Astra G Coupe (T98) 2.2 DTI (F07) 2003 by yourself
    Remove the brake disc.
    Replacement: brake discs – OPEL ASTRA G Coupe (F07_). Tip:
    If necessary, use a rubber mallet.
  20. Step 22
    How to remove OPEL ASTRA 1.6 16V (F07) 2004 Brake Discs - online easy-to-follow instructions
    Clean the hub. Use a wire brush. Treat the contacting surface. Use copper grease.
  21. Step 23
    How to replace Brake Discs on OPEL Astra G Coupe (T98) 2005: download PDF manuals and video instructions
    Install the brake disc.
  22. Step 24
    How hard is it to do yourself: Brake Discs replacement on Opel Astra G Coupe 1.8 16V (F07) 2000 - download illustrated guide
    Tighten the brake disc fastening. Use Torx T30. Use a torque wrench. Tighten it to 4 Nm torque.
  23. Step 25
    Need to know how to renew Brake Discs on OPEL ASTRA 2001? This free workshop manual will help you to do it yourself
    Clean the brake caliper bracket from dirt and dust. Use a wire brush. Use a brake cleaner.
    AUTODOC recommends:
    Replacement: brake discs – OPEL ASTRA G Coupe (F07_). After applying the spray, wait a few minutes.
  24. Step 26
    Changing of Brake Discs on Opel Astra G Coupe 2002 won't be an issue if you follow this illustrated step-by-step guide
    Install the brake caliper bracket.
  25. Step 27
    OPEL ASTRA 2.2 DTI (F07) Brake Discs replacement: online guides and video tutorials
    Tighten the brake caliper bracket. Use a drive socket #E20. Use a torque wrench. Tighten it to 100 Nm torque.
  26. Step 28
    Replacing Brake Discs on Opel Astra G Coupe 2004 2.2 16V (F07) by yourself
    Install the brake pads.
  27. Step 29
    Treat the brake caliper piston. Use a brake cleaner.
    Replacement: brake discs – OPEL ASTRA G Coupe (F07_). Tip from AUTODOC experts:
    After applying the spray, wait a few minutes.
    Step 30
    Astra G Coupe (T98) 1.6 16V (F07) 2005 Brake Discs DIY replacement workshop manual
    Press in the brake caliper piston. Use brake caliper wind back tool.
Was this manual helpful?
Please rate this manual on a scale from 1 to 5. If you have any questions, feel free to ask us.
Users voted – 0
Need New Tyres?

Find out which tyre and wheel sizes are compatible with the OPEL Astra G Coupe (T98) model

Opel Astra G Coupe tyre size

Popular maintenance tutorials for Opel Astra G Coupe

More manuals for Opel Astra G Coupe

Complete guides for changing the Brake rotors on different OPEL ASTRA models

Unlock your car maintenance assistant!

Track expenses, manage logs, schedule replacements, and more.

DIY OPEL Astra G Coupe (T98) Brake Discs replacement - online guide
Tips & tricks for your OPEL Astra G Coupe (T98)
View more
  • How to change Brake rotors on OPEL Astra G Coupe (T98) 2.0 16V Turbo (F07) - replacement tricks
    How to Safely Wash Your Car in Winter Without Damage | AUTODOC tips
    3K views
    Published on: 31/01/2024
  • Changing Brake disc Opel Astra G Coupe 2.2 16V (F07) - Replacement Tips
    How do EGR valves work? | AUTODOC
    22K views
    Published on: 18/07/2020
  • Maintenance Hacks - OPEL Astra G Coupe (T98) 1.8 16V (F07) Rotors replacement guide
    How to Fix a Squealing Belt: Causes & Solutions | AUTODOC Expert Tips
    5K views
    Published on: 04/03/2021
  • Replace Disc brakes on Opel Astra G Coupe - free video tips
    Understanding Airbag Light Warnings | Essential Tips for Car Safety
    6K views
    Published on: 10/04/2023

Most commonly replaced car parts on OPEL ASTRA

Professional manuals for the most common OPEL models

Autodoc CLUB App icon
Time to replace parts? Get even better deals in our Shop app.
OPEL Astra G Coupe (T98) Brake Discs replace by yourself - Scan QR-code and download AUTODOC CLUB app
SCAN ME