Disclaimer
How to change manual gearbox oil on AUDI 80 B3 (89, 89Q, 8A) – replacement guide
downloads:
16
Views:
178
Recommended replacement interval for the part category Automatic transmission fluid : 60000 km
Important!
This replacement procedure can be used for:
AUDI 80 (89, 89Q, 8A, B3) 1.6, AUDI 80 (89, 89Q, 8A, B3) 1.8, AUDI 80 (89, 89Q, 8A, B3) 1.8 S, AUDI 80 (89, 89Q, 8A, B3) 1.8 S, AUDI 80 (89, 89Q, 8A, B3) 1.8 E, AUDI 80 (89, 89Q, 8A, B3) 1.8, AUDI 80 (89, 89Q, 8A, B3) 2.0 E, AUDI 80 (89, 89Q, 8A, B3) 1.6 D, AUDI 80 (89, 89Q, 8A, B3) 1.6 TD, AUDI 80 (89, 89Q, 8A, B3) 1.9 D, AUDI 80 (89, 89Q, 8A, B3) 1.6, AUDI 80 (89, 89Q, 8A, B3) 2.0 E 16V, AUDI 80 (89, 89Q, 8A, B3) 1.8 S quattro, AUDI 80 (89, 89Q, 8A, B3) 1.8 S quattro, AUDI 80 (89, 89Q, 8A, B3) 1.8 quattro, AUDI 80 (89, 89Q, 8A, B3) 2.0 E quattro, AUDI 80 (89, 89Q, 8A, B3) 2.0 quattro, AUDI 80 (89, 89Q, 8A, B3) 2.0 E 16V quattro, AUDI 80 (89, 89Q, 8A, B3) 2.0 E, AUDI 80 (89, 89Q, 8A, B3) 1.8 E quattro, AUDI 80 (89, 89Q, 8A, B3) 2.0 E quattro, AUDI 80 (89, 89Q, 8A, B3) 2.3 quattro … View more
The steps may slightly vary depending on the car design.
AUDI 80 (89, 89Q, 8A, B3) 1.6, AUDI 80 (89, 89Q, 8A, B3) 1.8, AUDI 80 (89, 89Q, 8A, B3) 1.8 S, AUDI 80 (89, 89Q, 8A, B3) 1.8 S, AUDI 80 (89, 89Q, 8A, B3) 1.8 E, AUDI 80 (89, 89Q, 8A, B3) 1.8, AUDI 80 (89, 89Q, 8A, B3) 2.0 E, AUDI 80 (89, 89Q, 8A, B3) 1.6 D, AUDI 80 (89, 89Q, 8A, B3) 1.6 TD, AUDI 80 (89, 89Q, 8A, B3) 1.9 D, AUDI 80 (89, 89Q, 8A, B3) 1.6, AUDI 80 (89, 89Q, 8A, B3) 2.0 E 16V, AUDI 80 (89, 89Q, 8A, B3) 1.8 S quattro, AUDI 80 (89, 89Q, 8A, B3) 1.8 S quattro, AUDI 80 (89, 89Q, 8A, B3) 1.8 quattro, AUDI 80 (89, 89Q, 8A, B3) 2.0 E quattro, AUDI 80 (89, 89Q, 8A, B3) 2.0 quattro, AUDI 80 (89, 89Q, 8A, B3) 2.0 E 16V quattro, AUDI 80 (89, 89Q, 8A, B3) 2.0 E, AUDI 80 (89, 89Q, 8A, B3) 1.8 E quattro, AUDI 80 (89, 89Q, 8A, B3) 2.0 E quattro, AUDI 80 (89, 89Q, 8A, B3) 2.3 quattro … View more
The steps may slightly vary depending on the car design.
This video shows the replacement procedure of a similar car part on another vehicle
All the parts you need to replace – Gearbox Oil and Transmission Oil for 80 (89, 89Q, 8A, B3) and other AUDI models
Automatic transmission fluid
Manual Transmission Oil
Axle Gear Oil
Transfer Case Oil
Automatic transmission fluid
Manual Transmission Oil
Axle Gear Oil
Transfer Case Oil
Automatic transmission fluid for 80 B3 (89, 89Q, 8A) Petrol (113 hp)
Automatic transmission fluid for 80 B3 (89, 89Q, 8A) Diesel (54 hp)
Automatic transmission fluid for 80 B3 (89, 89Q, 8A) Diesel (80 hp)
Wire brush
All-purpose cleaning spray
HEX bit No.H17.
Drive socket # 12
Phillips screwdriver
Torque wrench
Funnel
Oil drain pan
Fender cover
Replacement: manual gearbox oil – AUDI 80 (89, 89Q, 8A, B3). AUTODOC recommends:
- All work should be done with the engine stopped.
Replacement: manual gearbox oil – AUDI 80 (89, 89Q, 8A, B3). Recommended sequence of steps:
- Step 1Open the hood.Step 2Use a fender protection cover to prevent damaging paintwork and plastic parts of the car.Step 3Lift the car using a jack or place it over an inspection pit.Replacement: manual gearbox oil – AUDI 80 (89, 89Q, 8A, B3). Tip:The vehicle must be on even keel, and if it is at an angle, the drain plug must be at the lowest point.Step 4
Unscrew the fasteners of the lower sound insulation. Use a drive socket #12. Use a Phillips screwdriver. - Step 5
Remove the lower sound insulation. - Step 6
Clean the area of the oil pan drainage hole. Use a wire brush. Use all-purpose cleaning spray.AUTODOC recommends:Replacement: manual gearbox oil – AUDI 80 (89, 89Q, 8A, B3). After applying the spray, wait a few minutes. - Step 7
Put a waste oil container with at least 2 l capacity under the drainage hole. - Step 8
Unscrew the drain plug. Use HEX No.H17. - Step 9
Drain the used oil.Replacement: manual gearbox oil – AUDI 80 (89, 89Q, 8A, B3). AUTODOC experts recommend:Caution! The oil may be hot. - Step 10
Clean the area around the gearbox housing filler hole. Use a wire brush. Use all-purpose cleaning spray.Replacement: manual gearbox oil – AUDI 80 (89, 89Q, 8A, B3). Tip from AUTODOC:After applying the spray, wait a few minutes. - Step 11
Unscrew the filler plug of the gearbox housing. Use HEX No.H17.
Was this manual helpful?
Please rate this manual on a scale from 1 to 5. If you have any questions, feel free to ask us.
Users voted – 0
Searching for the right tyres?
Find out which tyre and wheel sizes are compatible with the AUDI 80 B3 (89, 89Q, 8A) model.
Popular maintenance tutorials for Audi 80 B3
Free download PDF
2.32 MB
Free download PDF2.74 MB
Free download PDF3.49 MB
Free download PDF2.25 MB
Free download PDF839.68 KB
Free download PDF1.39 MB
Complete guides for changing the Gear oil on different AUDI 80 models
Free download PDF1.23 MB
Free download PDF1.23 MB
Free download PDF1.22 MB
Free download PDF1.22 MB
Free download PDF1.22 MB
Free download PDF1.22 MB
Your profile is your personal assistant.
It can track car expenses, keep a car log and replacement schedule, and save favourite materials, notes and documents
Install the AUTODOC CLUB app!
Your personal car expenses manager, maintenance tips, reminders about upcoming appointments and service intervals, DIY repair instructions – all this on your phone.
Scan
To download the app:
- - scan the QR code
- - download from App Store
- - download from Google Play
Tips & tricks for your AUDI 80 (89, 89Q, 8A, B3)
View more
How to easily repair a punctured tyre | AUTODOC tips
What to do if the ABS light comes on | AUTODOC tips
Top 5 reasons why the suspension knocks | AUTODOC tips
How to repair a bumper yourself | AUTODOC tips
