Recommended replacement interval for the part category Headlight bulb : 12 month / 15000 km

Important!

This replacement procedure can be used for:
OPEL Movano Minibus (X70) 2.5 D (JD), OPEL Movano Minibus (X70) 2.8 DTI (JD), OPEL Movano Minibus (X70) 2.2 DTI (JD), OPEL Movano Minibus (X70) 1.9 DTI (JD), OPEL Movano Minibus (X70) 1.9 DTI (JD), OPEL Movano Minibus (X70) 2.5 DTI (JD), OPEL Movano Minibus (X70) 3.0 DTi (JD), OPEL Movano Minibus (X70) 2.5 CDTI (JD), OPEL Movano Minibus (X70) 2.5 CDTI (JD), OPEL Movano Minibus (X70) 2.5 CDTI (JD) … View more

The steps may slightly vary depending on the car design.

This video shows the replacement procedure of a similar car part on another vehicle

Alternative products

Headlight bulb

Replacement: headlight bulb – OPEL MOVANO Combi (J9). Tools you need:

                      Electronic spray
                    
                      Drive socket # 7 
                    
                      Torx bit T30
                    
                      Ratchet wrench
                    
                      Flat screwdriver
                    
                      Microfibre towel
                    
                      Fender cover

Buy tools

Replacement: headlight bulb – OPEL MOVANO Combi (J9). Tip from AUTODOC experts:

The replacement procedure is identical for the left and right headlight bulbs.
Replace the bulbs in both headlights at a time.
All work should be done with the engine stopped.

Replacement: headlight bulb – OPEL MOVANO Combi (J9). Take the following steps:

Step 1

Switch off the ignition.

Step 2

Open the hood.

Step 3

Use a fender protection cover to prevent damaging paintwork and plastic parts of the car.

Step 4

Detach the air intake hose clamp. Use a drive socket #7. Use a ratchet wrench.
Step 5

Disconnect the air intake pipe from the air filter housing.
Step 6

Cover the air intake hose with a microfibre towel to prevent dust and dirt from getting into the system.
Step 7

Detach the fasteners connecting the air pipe and the wiring harness to the air filter housing.
Step 8

Take off the filter lid. Remove the filter element from the filter housing.
Step 9

Unscrew the filter housing fastening bolts. Use Torx T30. Use a ratchet wrench.
Step 10

Remove the air filter housing.
Step 11

Detach the bulb holder by turning it by ~30°. Remove the holder from the headlight mounting seat.
Step 12

Remove the old bulb. Use a flat screwdriver.
Step 13

Check the condition of the bulb holder terminals. Replace if necessary.

Step 14

Clean the bulb mounting seat on the holder. Use electronic spray.
Step 15

Install a new bulb into the holder.

Replacement: headlight bulb – OPEL MOVANO Combi (J9). AUTODOC recommends:
Avoid touching the bulb glass. The finger marks left on it may cause failure.
Step 16

Install the bulb holder into the headlight mounting seat. Secure the bulb holder by turning it by ~30°.
Step 17

Reinstall the air filter housing.
Step 18

Screw the filter housing fastening bolts. Use Torx T30. Use a ratchet wrench.
Step 19

Insert the filter cartridge into the filter housing. Make sure that the filter edge fits tight to the housing.

AUTODOC recommends:
Replacement: headlight bulb – OPEL MOVANO Combi (J9). Be sure to position the filtering element correctly. Avoid misalignment.During installation, make sure to prevent dust and dirt from getting into the air filter housing.
Step 20

Reinstall the air filter cover. Fasten it.
Step 21

Attach the fasteners connecting the air pipe and the wiring harness to the air filter housing.
Step 22

Remove the microfibre towel from the air intake hose.
Step 23

Connect the air intake pipe to the air filter housing.
Step 24

Fasten the clamp on the air intake hose. Use a drive socket #7. Use a ratchet wrench.

Step 25

Remove the fender protection cover.

Step 26

Close the hood.