Recommended replacement interval for the part category Brake pad set : 30000 km

Important!

This replacement procedure can be used for:
VAUXHALL Corsa Mk I (B) Hatchback (S93) 1.0 i 12V, VAUXHALL Corsa Mk I (B) Hatchback (S93) 1.2 i, VAUXHALL Corsa Mk I (B) Hatchback (S93) 1.4 i, VAUXHALL Corsa Mk I (B) Hatchback (S93) 1.4 i S, VAUXHALL Corsa Mk I (B) Hatchback (S93) 1.4 i 16V, VAUXHALL Corsa Mk I (B) Hatchback (S93) 1.6 i 16V, VAUXHALL Corsa Mk I (B) Hatchback (S93) 1.6 GSI 16V, VAUXHALL Corsa Mk I (B) Hatchback (S93) 1.5 D, VAUXHALL Corsa Mk I (B) Hatchback (S93) 1.5 TD, VAUXHALL Corsa Mk I (B) Hatchback (S93) 1.7 D, VAUXHALL Corsa Mk I (B) Hatchback (S93) 1.2 i 16V … View more

The steps may slightly vary depending on the car design.

This video shows the replacement procedure of a similar car part on another vehicle

All the parts you need to replace – Brake Pads for Corsa Mk I (B) Hatchback (S93) and other VAUXHALL models

Alternative products

Brake pad set

SKBP-0010046 STARK Brake pad set

13,10 GBP

Shop

402B0047 RIDEX Brake pad set

13,10 GBP

Shop

301356 VALEO Brake pad set

13,80 GBP

Shop

0 986 460 938 BOSCH Brake pad set

14,52 GBP

Shop

SKBP-0011176 STARK Brake pad set

14,86 GBP

Shop

P 59 011 BREMBO Brake pad set

17,03 GBP

Shop

2054701 TEXTAR Brake pad set

18,76 GBP

Shop

FDB732 FERODO Brake pad set

18,87 GBP

Shop

13.0460-7051.2 ATE Brake pad set

20,04 GBP

Shop

FSL732 FERODO Brake pad set

23,94 GBP

Shop

Replacement: brake pads – VAUXHALL CORSA Mk I (B). List of the tools you'll need:

                      Wire brush
                    
                      Nylon cleaning brush
                    
                      Brake cleaner 
                    
                      Anti-squeal paste
                    
                      High-temperature ceramic grease
                    
                      Torque wrench
                    
                      HEX bit No.H7
                    
                      Wheel impact socket #17
                    
                      Ratchet wrench
                    
                      Brake caliper wind back tool
                    
                      Crow bar
                    
                      Wheel chock

Buy tools

Replacement: brake pads – VAUXHALL CORSA Mk I (B). AUTODOC experts recommend:

Perform the replacement of brake pads in complete set for each axis. This provides effective braking.
The replacement procedure is identical for all brake pads on the same axle.
Please note: all work on the car – VAUXHALL CORSA Mk I (B) – should be done with the engine switched off.

Carry out replacement in the following order:

Step 1

Open the bonnet. Unscrew the brake fluid reservoir cap.

Step 2

Secure the wheels with chocks.

Step 3

Loosen the wheel mounting bolts. Use wheel impact socket #17.
Step 4

Raise the car.

AUTODOC recommends:
If you are using a jack, make sure it rests on a flat surface without any unevenness.Be sure to additionally secure the car with jack stands.
Step 5

Unscrew the wheel bolts.

AUTODOC recommends:
Warning! To avoid injury, hold the wheel while unscrewing the fastening bolts. VAUXHALL CORSA Mk I (B)
Step 6

Remove the wheel.
Step 7

Detach the brake caliper retaining spring. Use a crowbar.
Step 8

Spread the brake pads. Use a crowbar.
Step 9

Remove the dust boot caps of the brake caliper guide pins. Use a crowbar.
Step 10

Unscrew the brake caliper fastening. Use HEX No.H7. Use a ratchet wrench.
Step 11

Remove the brake caliper.

AUTODOC recommends:
Tie the caliper to the suspension or to the body with a wire without disconnecting from the brake hose to prevent depressurization of the brake system.Make sure that the brake caliper is not hanging on the brake hose.Don't press the brake pedal after the brake caliper has been removed. As a result, the piston can fall out from the brake cylinder, and brake fluid leakage and depressurization of the system may occur.
Step 12

Remove the brake pads.

AUTODOC recommends:
Measure the brake disc thickness. Upon reaching the wear limit the part must be replaced.
Step 13

Treat the brake caliper piston. Use a nylon cleaning brush. Use a brake cleaner.

AUTODOC recommends:
Replacement: brake pads – VAUXHALL CORSA Mk I (B). After applying the spray, wait a few minutes.
Step 14

Press in the brake caliper piston. Use brake caliper wind back tool.

Replacement: brake pads – VAUXHALL CORSA Mk I (B). Tip from AUTODOC:
Check the brake caliper bracket, brake caliper guide pins and boots. Clean them. Replace, if necessary.
Step 15

Clean the brake caliper bracket from dirt and dust. Use a wire brush. Use a brake cleaner.

AUTODOC recommends:
After applying the spray, wait a few minutes.
Step 16

Treat the brake pads in the area where their surface comes into contact with the brake caliper bracket. Use anti-squeal paste.

Replacement: brake pads – VAUXHALL CORSA Mk I (B). Tip:
Make sure the disc surface is clean before installing the pads.
Step 17

Install new brake pads.

Replacement: brake pads – VAUXHALL CORSA Mk I (B). AUTODOC recommends:
Make sure the pads are installed with linings facing the disc.
Step 18

Install the brake caliper and fix it. Use HEX No.H7. Use a torque wrench. Tighten it to 30 Nm torque.
Step 19

Install the dust boot caps of the brake caliper guide pins.
Step 20

Install the brake caliper retaining spring. Use a crowbar.
Step 21

Clean the wheel rim mounting seat. Use a wire brush.
Step 22

Treat the surface where the brake disc contacts the wheel rim. Use high-temperature ceramic grease.
Step 23

Clean the brake disk surface. Use a brake cleaner.

AUTODOC recommends:
After applying the spray, wait a few minutes.
Step 24

Install the wheel.

AUTODOC recommends:
Warning! To avoid injury, hold the wheel while screwing in the fastening bolts on the car. VAUXHALL CORSA Mk I (B)
Step 25

Screw in the wheel bolts. Use wheel impact socket #17.
Step 26

Lower the car and working in a cross order, tighten the wheel bolts. Use wheel impact socket #17. Use a torque wrench. Tighten it to 110 Nm torque.
Step 27

Remove the jacks and chocks.

AUTODOC recommends:
Check the brake fluid level in the expansion tank and refill if necessary.Without starting the engine, press the brake pedal several times until you feel significant resistance.
Step 28

Tighten the brake fluid reservoir cap.

Step 29

Close the hood.

Replacement: brake pads – VAUXHALL CORSA Mk I (B). AUTODOC experts recommend:
Slow down smoothly for first 150-200 km after the brake pads replacement. Avoid unneccessary and sharp braking to a stop.

Was this manual helpful?

Please rate this manual on a scale from 1 to 5. If you have any questions, feel free to ask us.

Need New Tyres?

Find out which tyre and wheel sizes are compatible with the VAUXHALL Corsa Mk1 (B) Hatchback (S93) model

VAUXHALL CORSA Mk I (B) tyre size

How to change wheel cylinder on VAUXHALL Corsa Mk I (B) Hatchback (S93) – replacement guide

Free download PDF
2.08 MB
How to change rear brake shoes on VAUXHALL Corsa Mk I (B) Hatchback (S93) – replacement guide

Free download PDF
1.58 MB
How to change front brake discs on VAUXHALL Corsa Mk I (B) Hatchback (S93) – replacement guide

Free download PDF
1.92 MB
How to change front wheel bearing on VAUXHALL Corsa Mk I (B) Hatchback (S93) – replacement guide

Free download PDF
4.62 MB
How to change rear wheel bearing on VAUXHALL Corsa Mk I (B) Hatchback (S93) – replacement guide

Free download PDF
2.07 MB
How to change spark plugs on VAUXHALL Corsa Mk I (B) Hatchback (S93) – replacement guide

Free download PDF
1.86 MB

How to change front brake pads on VAUXHALL Corsa Mk III (D) Hatchback (S07) – replacement guide

Free download PDF
1.49 MB
How to change front brake pads on VAUXHALL Corsa Mk IV (E) Hatchback (X15) – replacement guide

Free download PDF
1.5 MB
How to change front brake pads on VAUXHALL Corsa Mk II (C) Hatchback (X01) – replacement guide

Free download PDF
1.49 MB
How to change rear brake pads on VAUXHALL Corsa Mk II (C) Hatchback (X01) – replacement guide

Free download PDF
1.48 MB
How to change front brake pads on VAUXHALL Corsavan Mk III (D) (S07) – replacement guide

Free download PDF
1.47 MB
How to change front brake pads on VAUXHALL Corsavan Mk IV (E) Van (X15) – replacement guide

Free download PDF
1.49 MB

Unlock your car maintenance assistant!

Track expenses, manage logs, schedule replacements, and more.

How to Use Sandblasting Equipment: Step-by-Step Guide | AUTODOC Tips

4K views

Published on: 16/05/2024
Easy Steps to Paint Brake Calipers Without Special Skills or High Costs

10K views

Published on: 08/04/2021
#DIY guide: Changing your car's color with a spray can | AUTODOC tips

5K views

Published on: 25/03/2021
5 causes of turbocharger failure and how to avoid them

12K views

Published on: 04/04/2024