Recommended replacement interval for the part category Brake pad set : 30000 km

Important!

This replacement procedure can be used for:
RENAULT MODUS / GRAND MODUS (F/JP0_) 1.5 dCi 75, RENAULT MODUS / GRAND MODUS (F/JP0_) 1.5 dCi 90, RENAULT MODUS / GRAND MODUS (F/JP0_) 1.2, RENAULT MODUS / GRAND MODUS (F/JP0_) 1.2 (JP0C, JP0K, FP0C, FP0K, FP0P, JP0P, JP0T), RENAULT MODUS / GRAND MODUS (F/JP0_) 1.6 (JP0L, JP0V), RENAULT MODUS / GRAND MODUS (F/JP0_) 1.6 (JP03, JP0B, JP0U, JP0Y, JP1G), RENAULT MODUS / GRAND MODUS (F/JP0_) 1.5 dCi (FP0G, JP0G), RENAULT MODUS / GRAND MODUS (F/JP0_) 1.5 dCi (FP0F, JP0F), RENAULT MODUS / GRAND MODUS (F/JP0_) 1.4 (JP01, JP0J), RENAULT MODUS / GRAND MODUS (F/JP0_) 1.5 dCi (JP0G, JP0H), RENAULT MODUS / GRAND MODUS (F/JP0_) 1.2 (FP0C, FP0K, FP0P), RENAULT MODUS / GRAND MODUS (F/JP0_) 1.2 16V (JP0W), RENAULT MODUS / GRAND MODUS (F/JP0_) 1.5 dCi (JP02), RENAULT MODUS / GRAND MODUS (F/JP0_) 1.2 (JP0S), RENAULT MODUS / GRAND MODUS (F/JP0_) 1.5 dCi (FP0E, JP0E), RENAULT MODUS / GRAND MODUS (F/JP0_) 1.2 16V Hi-Flex, RENAULT MODUS / GRAND MODUS (F/JP0_) 1.5 dCi (FP0D, JP0D), RENAULT MODUS / GRAND MODUS (F/JP0_) 1.2 GPL (JP0R) … View more

The steps may slightly vary depending on the car design.

This video shows the replacement procedure of a similar car part on another vehicle

All the parts you need to replace – Brake Pads for MODUS / GRAND MODUS (F/JP0_) and other RENAULT models

Brake pad set

        Brake pad set for Modus / Grand Modus (F, JP) Diesel (75 hp)
      
        Brake pad set for Modus / Grand Modus (F, JP) Diesel (88 hp)
      
        Brake pad set for Modus / Grand Modus (F, JP) Petrol (103 hp)
      
        Brake pad set for Modus / Grand Modus (F, JP) Petrol (75 hp)
      
        Brake pad set for Modus / Grand Modus (F, JP) Petrol (88 hp)
      
        Brake pad set for Modus / Grand Modus (F, JP) Petrol (112 hp)
      
        Brake pad set for Modus / Grand Modus (F, JP) Diesel (68 hp)
      
        Brake pad set for Modus / Grand Modus (F, JP) Diesel (86 hp)
      
        Brake pad set for Modus / Grand Modus (F, JP) Petrol (98 hp)

Replacement: brake pads – RENAULT MODUS / GRAND MODUS (F/JP0_). List of the tools you'll need:

                        Wire brush
                      
                        Nylon cleaning brush
                      
                        WD-40 spray
                      
                        Brake cleaner
                      
                        Anti-squeal paste
                      
                        Ceramic grease
                      
                        Torque wrench
                      
                        Combination spanner #13
                      
                        Combination spanner #15
                      
                        Drive socket # 13
                      
                        Drive socket # 17
                      
                        Torx bit T40
                      
                        Wheel impact socket #17
                      
                        Ratchet wrench
                      
                        Tap wrench
                      
                        Brake caliper wind back tool
                      
                        Phillips screwdriver
                      
                        Crow bar
                      
                        Impact screwdriver
                      
                        Hammer
                      
                        Wheel chock

Buy tools

Replacement: brake pads – RENAULT MODUS / GRAND MODUS (F/JP0_). Professionals recommend:

Perform the replacement of brake pads in complete set for each axis. This provides effective braking.
The replacement procedure is identical for all brake pads on the same axle.
All work should be done with the engine stopped.

Carry out replacement in the following order:

Step 1

Open the bonnet.

Step 2

Unscrew the brake fluid reservoir cap.
Step 3

Secure the wheels with chocks.

Step 4

Loosen the wheel bolts. Use wheel impact socket #17. Use a tap wrench.
Step 5

Raise the car.

AUTODOC recommends:
If you are using a jack, make sure it rests on a flat surface without any unevenness.Be sure to additionally secure the car with jack stands.
Step 6

Unscrew the wheel bolts.

AUTODOC recommends:
Warning! To avoid injury, hold the wheel while unscrewing the fastening bolts. RENAULT MODUS / GRAND MODUS (F/JP0_)
Step 7

Remove the wheel.
Step 8

Spread the brake pads. Use a crowbar.
Step 9

Clean the brake caliper fasteners. Use a wire brush. Use WD-40 spray.
Step 10

Unscrew the brake caliper fasteners. Use a combination spanner #13. Use a combination spanner #15.
Step 11

Remove the fastening bolts.

Step 12

Remove the brake caliper.

AUTODOC recommends:
Tie the caliper to the suspension or to the body with a wire without disconnecting from the brake hose to prevent depressurization of the brake system.Make sure that the brake caliper is not hanging on the brake hose.Don't press the brake pedal after the brake caliper has been removed. As a result, the piston can fall out from the brake cylinder, and brake fluid leakage and depressurization of the system may occur.
Step 13

Remove the brake pads.

AUTODOC recommends:
Measure the brake disc thickness. Upon reaching the wear limit the part must be replaced.
Step 14

Treat the brake caliper piston. Use a nylon cleaning brush. Use a brake cleaner.
Step 15

Press in the brake caliper piston. Use brake caliper wind back tool.
Step 16

Clean the brake caliper bracket of dirt and dust. Use a wire brush. Use a brake cleaner.

Replacement: brake pads – RENAULT MODUS / GRAND MODUS (F/JP0_). Tip:
Check the brake caliper bracket, brake caliper guide pins and boots. Clean them. Replace, if necessary.
Step 17

Treat the brake pads in the area where their surface comes into contact with the brake caliper bracket. Use anti-squeal paste.

Replacement: brake pads – RENAULT MODUS / GRAND MODUS (F/JP0_). Tip from AUTODOC experts:
Make sure the disc surface is clean before installing the pads.
Step 18

Install new brake pads.
Step 19

Install the brake caliper and fasten it.
Step 20

Install the fastening bolts.
Step 21

Tighten the brake caliper fasteners. Use a combination spanner #15. Use a drive socket #13. Use a torque wrench. Tighten it to 35 Nm torque.
Step 22

Treat the surface where the brake disc contacts the wheel rim. Use ceramic grease.
Step 23

Clean the brake disk surface. Use a brake cleaner.

Step 24

Install the wheel.

AUTODOC recommends:
Important! Hold the wheel while screwing in the fastening bolts. RENAULT MODUS / GRAND MODUS (F/JP0_)
Step 25

Screw in the wheel bolts. Use wheel impact socket #17. Use a ratchet wrench.
Step 26

Lower the car and working in a cross order, tighten the wheel bolts. Use wheel impact socket #17. Use a torque wrench. Tighten it to 110 Nm torque.
Step 27

Remove the jacks and chocks.

Replacement: brake pads – RENAULT MODUS / GRAND MODUS (F/JP0_). AUTODOC experts recommend:
Without starting the engine, press the brake pedal several times until you feel significant resistance.Check the brake fluid level in the expansion tank and top up if necessary.
Step 28

Tighten the brake fluid reservoir cap.

Step 29

Close the bonnet.

AUTODOC recommends:
Slow down smoothly for first 150-200 km after the brake pads replacement. Avoid unneccessary and sharp braking to a stop.

Was this manual helpful?

Please rate this manual on a scale from 1 to 5. If you have any questions, feel free to ask us.

Searching for the right tyres?

Find out which tyre and wheel sizes are compatible with the RENAULT Modus / Grand Modus (F, JP) model.

Browse tyres

How to change rear brake pads on RENAULT MODUS / GRAND MODUS (F/JP0_) – replacement guide

Free download PDF
1.37 MB
How to change front brake discs on RENAULT MODUS / GRAND MODUS (F/JP0_) – replacement guide

Free download PDF
1.96 MB
How to change rear wheel bearing on RENAULT MODUS / GRAND MODUS (F/JP0_) – replacement guide

Free download PDF
2.11 MB
How to change front wheel bearing on RENAULT MODUS / GRAND MODUS (F/JP0_) – replacement guide

Free download PDF
4.01 MB
How to change serpentine belt on RENAULT Modus / Grand Modus (F, JP) – replacement guide

Free download PDF
1.63 MB
How to change spark plugs on RENAULT MODUS / GRAND MODUS (F/JP0_) – replacement guide

Free download PDF
1.1 MB

How to change rear brake pads on RENAULT MODUS / GRAND MODUS (F/JP0_) – replacement guide

Free download PDF
1.37 MB
How to change brake pads on a car – replacement tutorial

Universal

Free download PDF
2.84 MB
How to change rear brake pads on Renault Megane 2 – replacement guide

Free download PDF
2.49 MB
How to change front brake pads on Renault Clio 3 – replacement guide

Free download PDF
1.64 MB
How to change front brake pads on Renault Clio 2 – replacement guide

Free download PDF
1.46 MB
How to change rear brake pads on Renault Scenic 2 – replacement guide

Free download PDF
1.61 MB

Your profile is your personal assistant.

It can track car expenses, keep a car log and replacement schedule, and save favourite materials, notes and documents

Install the AUTODOC CLUB app!

Your personal car expenses manager, maintenance tips, reminders about upcoming appointments and service intervals, DIY repair instructions – all this on your phone.

Scan

To download the app:

- scan the QR code
- download from App Store
- download from Google Play

3 things that cause engine damage | AUTODOC tips

9K views

Published on: 07/10/2021
4 reasons why your CHECK ENGINE light is on | AUTODOC tips

6K views

Published on: 30/03/2022
TOP 6 WD-40 lifehacks | AUTODOC tips

12K views

Published on: 15/07/2021
Important differences between car tools | AUTODOC tips

7K views

Published on: 16/12/2021