Recommended replacement interval for the part category Brake pad set : 30000 km

Important!

This replacement procedure can be used for:
RENAULT Dokker Van 1.5 dCi … View more

The steps may slightly vary depending on the car design.

This video shows the replacement procedure of a similar car part on another vehicle

All the parts you need to replace – Brake Pads for Dokker Van and other RENAULT models

Brake pad set

Brake pad set for Dokker Van Diesel (90 hp)

Replacement: brake pads – RENAULT Dokker Kastenwagen. Tools you'll need:

                        Wire brush
                      
                        Nylon cleaning brush
                      
                        WD-40 spray
                      
                        Brake cleaner 
                      
                        Anti-squeal paste
                      
                        Copper grease 
                      
                        Torque wrench
                      
                        Combination spanner #13
                      
                        Combination spanner #19
                      
                        Drive socket # 13 
                      
                        Wheel impact socket #17
                      
                        Brake caliper wind back tool
                      
                        Crow bar
                      
                        Fender cover
                      
                        Wheel chock

Buy tools

Replacement: brake pads – RENAULT Dokker Kastenwagen. AUTODOC recommends:

Perform the replacement of brake pads in complete set for each axis. This provides effective braking.
The replacement procedure is identical for all brake pads on the same axle.
Please note: all work on the car – RENAULT Dokker Kastenwagen – should be done with the engine switched off.

Carry out replacement in the following order:

Step 1

Open the bonnet.

Step 2

Use a fender protection cover to prevent damaging paintwork and plastic parts of the car.

Step 3

Unscrew the brake fluid reservoir cap.
Step 4

Secure the wheels with chocks.
Step 5

Loosen the wheel mounting bolts. Use wheel impact socket #17.
Step 6

Raise the front of the car and secure on supports.

Step 7

Unscrew the wheel bolts.

Replacement: brake pads – RENAULT Dokker Kastenwagen. Tip:
To avoid injury, hold up the wheel when unscrewing the bolts.
Step 8

Remove the wheel.
Step 9

Clean the brake caliper fasteners. Use a wire brush. Use WD-40 spray.
Step 10

Unscrew the brake caliper fastening. Use a combination spanner #13. Use a combination spanner #19.
Step 11

Spread the brake pads. Use a crowbar.
Step 12

Remove the brake caliper.

Replacement: brake pads – RENAULT Dokker Kastenwagen. Tip from AUTODOC experts:
Tie the caliper to the suspension or to the body with a wire without disconnecting from the brake hose to prevent depressurization of the brake system.Make sure that the brake caliper is not hanging on the brake hose.Don't press the brake pedal after the brake caliper has been removed. As a result, the piston can fall out from the brake cylinder, and brake fluid leakage and depressurization of the system may occur. Check the brake caliper bracket, brake caliper guide pins and boots. Clean them. Replace, if necessary.
Step 13

Remove the brake pads.

Replacement: brake pads – RENAULT Dokker Kastenwagen. AUTODOC recommends:
Measure the brake disc thickness. Upon reaching the wear limit the part must be replaced.
Step 14

Clean the brake caliper bracket from dirt and dust. Use a wire brush. Use a brake cleaner.

AUTODOC recommends:
Replacement: brake pads – RENAULT Dokker Kastenwagen. After applying the spray, wait a few minutes.
Step 15

Treat the brake caliper piston. Use a nylon cleaning brush. Use a brake cleaner.

Replacement: brake pads – RENAULT Dokker Kastenwagen. Tip from AUTODOC experts:
After applying the spray, wait a few minutes.
Step 16

Press in the brake caliper piston. Use brake caliper wind back tool.
Step 17

Treat the brake pads in the area where their surface comes into contact with the brake caliper bracket. Use anti-squeal paste.

Replacement: brake pads – RENAULT Dokker Kastenwagen. Tip from AUTODOC:
Make sure the disc surface is clean before installing the pads.
Step 18

Install new brake pads.

AUTODOC recommends:
Make sure the pads are installed with linings facing the disc.
Step 19

Install the brake caliper and fix it. Use a combination spanner #13. Use a combination spanner #19. Use a drive socket #13. Use a torque wrench. Tighten it to 32 Nm torque.
Step 20

Treat the surface where the brake disc contacts the wheel rim. Use copper grease.
Step 21

Clean the brake disk surface. Use a brake cleaner.

Replacement: brake pads – RENAULT Dokker Kastenwagen. AUTODOC recommends:
After applying the spray, wait a few minutes.
Step 22

Install the wheel.

AUTODOC recommends:
Warning! To avoid injury, hold the wheel while screwing in the fastening bolts on the car. RENAULT Dokker Kastenwagen
Step 23

Screw in the wheel bolts. Use wheel impact socket #17.
Step 24

Lower the car and working in a cross order, tighten the wheel bolts. Use wheel impact socket #17. Use a torque wrench. Tighten it to 105 Nm torque.

Step 25

Remove the jacks and chocks.

Replacement: brake pads – RENAULT Dokker Kastenwagen. Tip from AUTODOC experts:
Check the brake fluid level in the expansion tank and refill if necessary.
Step 26

Tighten the brake fluid reservoir cap.

AUTODOC recommends:
RENAULT Dokker Kastenwagen – Without starting the engine, press the brake pedal several times until it feels firm.
Step 27

Remove the fender protection cover.

Step 28

Close the hood.

Replacement: brake pads – RENAULT Dokker Kastenwagen. Professionals recommend:
Slow down smoothly for first 150-200 km after the brake pads replacement. Avoid unneccessary and sharp braking to a stop.

Was this manual helpful?

Please rate this manual on a scale from 1 to 5. If you have any questions, feel free to ask us.

Searching for the right tyres?

Find out which tyre and wheel sizes are compatible with the RENAULT Dokker Van model.

RENAULT Dokker Kastenwagen tyre size

How to change front brake discs on RENAULT Dokker Van – replacement guide

Free download PDF
1.76 MB
How to change spark plugs on RENAULT Dokker Van – replacement guide

Free download PDF
880.64 KB
How to change engine oil and filter on RENAULT Dokker Van – replacement guide

Free download PDF
1.17 MB
How to change water pump & timing belt kit on Renault Clio 3 – replacement guide

Free download PDF
5.68 MB
How to change fuel filter on Renault Megane Scenic – replacement guide

Free download PDF
1.66 MB
How to change serpentine belt on Renault Clio 3 – replacement guide

Free download PDF
1.84 MB

How to change brake pads on a car – replacement tutorial

Universal

Free download PDF
2.84 MB
How to change rear brake pads on Renault Megane 2 – replacement guide

Free download PDF
2.49 MB
How to change front brake pads on Renault Clio 3 – replacement guide

Free download PDF
1.64 MB
How to change front brake pads on Renault Clio 2 – replacement guide

Free download PDF
1.46 MB
How to change rear brake pads on Renault Scenic 2 – replacement guide

Free download PDF
1.61 MB
How to change rear brake pads on Renault Megane Scenic – replacement guide

Free download PDF
2.19 MB

Your profile is your personal assistant.

It can track car expenses, keep a car log and replacement schedule, and save favourite materials, notes and documents

Install the AUTODOC CLUB app!

Your personal car expenses manager, maintenance tips, reminders about upcoming appointments and service intervals, DIY repair instructions – all this on your phone.

Scan

To download the app:

- scan the QR code
- download from App Store
- download from Google Play

What to do if the TPMS light is on | AUTODOC tips

6K views

Published on: 28/09/2023
How to remove scratches from car plastic | AUTODOC tips

102K views

Published on: 15/12/2022
How to detect vacuum leaks using a smoke machine | AUTODOC

19K views

Published on: 23/07/2020
The most common problems when buying a used car | AUTODOC

4K views

Published on: 10/11/2022