Recommended replacement interval for the part category Brake pad set : 30000 km

Important!

This replacement procedure can be used for:
CITROËN C2 Hatchback (JM) 1.6 HDi, CITROËN C2 Hatchback (JM) 1.6 VTS, CITROËN C2 Hatchback (JM) 1.4 HDi, CITROËN C2 Hatchback (JM) 1.6 … View more

The steps may slightly vary depending on the car design.

This video shows the replacement procedure of a similar car part on another vehicle

Alternative products

Brake pad set

Replacement: brake pads – CITROËN C2 (JM_). List of the tools you'll need:

                      Wire brush
                    
                      WD-40 spray
                    
                      Brake cleaner 
                    
                      Anti-squeal paste
                    
                      Copper grease 
                    
                      Combination spanner #13
                    
                      Combination spanner #15
                    
                      Wheel impact socket #19
                    
                      Torque wrench
                    
                      Brake caliper wind back tool
                    
                      Crow bar
                    
                      Wheel chock

Buy tools

Replacement: brake pads – CITROËN C2 (JM_). Tip:

Perform the replacement of brake pads in complete set for each axis. This provides effective braking.
The replacement procedure is identical for all brake pads on the same axle.
All work should be done with the engine stopped.

Replacement: brake pads – CITROËN C2 (JM_). Use the following procedure:

Step 1

Open the bonnet. Unscrew the brake fluid reservoir cap.

Step 2

Secure the wheels with chocks.
Step 3

Loosen the wheel mounting bolts. Use wheel impact socket #19.
Step 4

Raise the front of the car and secure on supports.

Step 5

Unscrew the wheel bolts.

AUTODOC recommends:
Important! Hold the wheel while unscrewing the fastening bolts. CITROËN C2 (JM_)
Step 6

Remove the wheel.
Step 7

Clean the brake caliper fasteners. Use a wire brush. Use WD-40 spray.
Step 8

Unscrew the brake caliper fastening. Use a combination spanner #13. Use a combination spanner #15.
Step 9

Spread the brake pads. Use a crowbar.
Step 10

Remove the brake caliper.

Replacement: brake pads – CITROËN C2 (JM_). AUTODOC recommends:
Tie the caliper to the suspension or to the body with a wire without disconnecting from the brake hose to prevent depressurization of the brake system.Make sure that the brake caliper is not hanging on the brake hose.Don't press the brake pedal after the brake caliper has been removed. As a result, the piston can fall out from the brake cylinder, and brake fluid leakage and depressurization of the system may occur. Check the brake caliper bracket, brake caliper guide pins and boots. Clean them. Replace, if necessary.
Step 11

Remove the brake pads.

Replacement: brake pads – CITROËN C2 (JM_). AUTODOC experts recommend:
Measure the brake disc thickness. Upon reaching the wear limit the part must be replaced.
Step 12

Treat the brake caliper piston. Use a brake cleaner.

AUTODOC recommends:
Replacement: brake pads – CITROËN C2 (JM_). After applying the spray, wait a few minutes.
Step 13

Press in the brake caliper piston. Use brake caliper wind back tool.
Step 14

Clean the brake caliper bracket from dirt and dust. Use a wire brush. Use a brake cleaner.

Replacement: brake pads – CITROËN C2 (JM_). Professionals recommend:
After applying the spray, wait a few minutes.
Step 15

Treat the brake pads in the area where their surface comes into contact with the brake caliper bracket. Use anti-squeal paste.

AUTODOC recommends:
Make sure the disc surface is clean before installing the pads.
Step 16

Install new brake pads.

Replacement: brake pads – CITROËN C2 (JM_). Tip from AUTODOC experts:
Make sure the pads are installed with linings facing the disc.
Step 17

Install the brake caliper and fix it. Use a combination spanner #13. Use a combination spanner #15. Use a torque wrench. Tighten it to 27 Nm torque.
Step 18

Treat the surface where the brake disc contacts the wheel rim. Use copper grease.
Step 19

Clean the brake disk surface. Use a brake cleaner.

AUTODOC recommends:
Replacement: brake pads – CITROËN C2 (JM_). After applying the spray, wait a few minutes.
Step 20

Install the wheel.

Replacement: brake pads – CITROËN C2 (JM_). AUTODOC recommends:
To avoid injury, hold up the wheel when screwing in the fastening bolts.
Step 21

Screw in the wheel bolts. Use wheel impact socket #19.
Step 22

Lower the car and working in a cross order, tighten the wheel bolts. Use a torque wrench. Tighten it to 100 Nm torque.

AUTODOC recommends:
Important! Replacement: brake pads – CITROËN C2 (JM_). Check the brake fluid level in the reservoir and top up if necessary.
Step 23

Tighten the brake fluid reservoir cap. Close the hood.

Replacement: brake pads – CITROËN C2 (JM_). Professionals recommend:
Without starting the engine, press the brake pedal several times until you feel significant resistance.
Step 24

Remove the jacks and chocks.

AUTODOC recommends:
Slow down smoothly for first 150-200 km after the brake pads replacement. Avoid unneccessary and sharp braking to a stop.

Was this manual helpful?

Please rate this manual on a scale from 1 to 5. If you have any questions, feel free to ask us.

Need New Tyres?

Find out which tyre and wheel sizes are compatible with the CITROËN C2 Hatchback (JM) model

Citroen C2 Mk1 tyre size

How to change front brake caliper on CITROËN C2 Hatchback (JM) – replacement guide

Free download PDF
1.96 MB
How to change rear brake pads on CITROËN C2 Hatchback (JM) – replacement guide

Free download PDF
1.59 MB
How to change front brake discs on CITROËN C2 Hatchback (JM) – replacement guide

Free download PDF
2.04 MB
How to change rear wheel bearing on CITROËN C2 Hatchback (JM) – replacement guide

Free download PDF
2.22 MB
How to change serpentine belt on CITROËN C2 Hatchback (JM) – replacement guide

Free download PDF
1.17 MB
How to change spark plugs on CITROËN C2 Hatchback (JM) – replacement guide

Free download PDF
1.24 MB

How to change rear brake pads on CITROËN C2 Hatchback (JM) – replacement guide

Free download PDF
1.59 MB
How to change rear brake pads on CITROËN C2 Enterprise (JG_) – replacement guide

Free download PDF
1.58 MB
How to change front brake pads on CITROËN C2 Enterprise (JG_) – replacement guide

Free download PDF
1.46 MB
How to change brake pads on a car – replacement tutorial

Universal

Free download PDF
2.84 MB
How to change front brake pads on Citroen C3 1 – replacement guide

Free download PDF
1.42 MB
How to change front brake pads on Citroen Xsara Picasso – replacement guide

Free download PDF
1.42 MB

Unlock your car maintenance assistant!

Track expenses, manage logs, schedule replacements, and more.

How to Install a New Windscreen Yourself | AUTODOC Expert Tips

10K views

Published on: 06/06/2024
CHECK ENGINE light turned on – step-by-step guide on what to do

4K views

Published on: 10/07/2025
Stop Rust Before It Starts: Top 5 Tips for Car Body Protection | AUTODOC Insights

7K views

Published on: 27/07/2023
Drive with Care: 8 Common Bad Driving Habits Explained | AUTODOC

4K views

Published on: 01/04/2021