Recommended replacement interval for the part category Brake hose : 50000 km

Important!

This replacement procedure can be used for:
SKODA ROOMSTER (5J) 1.2 TDI, SKODA ROOMSTER (5J) 1.2, SKODA ROOMSTER (5J) 1.4, SKODA ROOMSTER (5J) 1.6, SKODA ROOMSTER (5J) 1.4 TDI, SKODA ROOMSTER (5J) 1.4 TDI, SKODA ROOMSTER (5J) 1.9 TDI, SKODA ROOMSTER (5J) 1.2, SKODA ROOMSTER (5J) 1.2 TSI, SKODA ROOMSTER (5J) 1.2 TSI, SKODA ROOMSTER (5J) 1.6 TDI, SKODA ROOMSTER (5J) 1.6 TDI … View more

The steps may slightly vary depending on the car design.

This video shows the replacement procedure of a similar car part on another vehicle

All the parts you need to replace – Brake Hose for ROOMSTER (5J) and other SKODA models

Brake hose

        Brake hose for Roomster (5J) Diesel (75 hp)
      
        Brake hose for Roomster (5J) Petrol (64 hp)
      
        Brake hose for Roomster (5J) Petrol (86 hp)
      
        Brake hose for Roomster (5J) Petrol (105 hp)
      
        Brake hose for Roomster (5J) Diesel (70 hp)
      
        Brake hose for Roomster (5J) Diesel (80 hp)
      
        Brake hose for Roomster (5J) Diesel (105 hp)
      
        Brake hose for Roomster (5J) Petrol (70 hp)
      
        Brake hose for Roomster (5J) Petrol (105 hp)

Replacement: brake hose – SKODA ROOMSTER (5J). List of the tools you'll need:

                        Wire brush
                      
                        Brake cleaner 
                      
                        Copper grease 
                      
                        Combination spanner #11
                      
                        Drive socket # 11 
                      
                        Wheel impact socket #17
                      
                        Ratchet wrench
                      
                        Torque wrench
                      
                        Brake bleeder kit
                      
                        Rubber mallet
                      
                        Fluid container
                      
                        Crow bar
                      
                        Wheel chock

Buy tools

Replacement: brake hose – SKODA ROOMSTER (5J). Professionals recommend:

The replacement procedure is identical for the right and left brake hoses on the same axle.
All work should be done with the engine stopped.

Replacement: brake hose – SKODA ROOMSTER (5J). Use the following procedure:

Step 1

Open the bonnet. Unscrew the brake fluid reservoir cap.

Step 2

Secure the wheels with chocks.
Step 3

Loosen the wheel mounting bolts. Use wheel impact socket #17.
Step 4

Raise the front of the car and secure on supports.

Step 5

Unscrew the wheel bolts.

AUTODOC recommends:
Important! Hold the wheel while unscrewing the fastening bolts. SKODA ROOMSTER (5J)
Step 6

Remove the wheel.
Step 7

Put a container for gathering brake fluid beneath.
Step 8

Clean the area where the brake hose is connected to the brake caliper and to the brake circuit pipe. Use a wire brush. Use a brake cleaner.

Replacement: brake hose – SKODA ROOMSTER (5J). Tip from AUTODOC:
After applying the spray, wait a few minutes.
Step 9

Remove the fastener attaching the brake hose to the shock strut. Use a crowbar.
Step 10

Detach the brake hose from the shock strut.

Step 11

Unscrew the brake hose from the brake caliper. Use a drive socket #11. Use a ratchet wrench.
Step 12

Unscrew the fastener connecting the brake hose to the brake circuit pipe. Use a combination spanner #11.
Step 13

Remove the brake hose.
Step 14

Screw the brake hose onto the brake circuit pipe. Use a combination spanner #11. Use a torque wrench. Tighten it to 15 Nm torque.
Step 15

Tighten the fastener connecting the brake pipe to the brake caliper. Use a drive socket #11. Use a torque wrench. Tighten it to 30 Nm torque.
Step 16

Clean the brake hose mounting seat on the brake circuit pipe. Clean the mounting seat of the brake hose on the brake caliper. Use a brake cleaner.

AUTODOC recommends:
Replacement: brake hose – SKODA ROOMSTER (5J). After applying the spray, wait a few minutes.
Step 17

Fasten the brake hose on the strut.
Step 18

Install the brake hose retaining clip. Use a rubber mallet.
Step 19

Undo the brake bleeder screw. Use a combination spanner #11.
Step 20

Connect the brake bleeder kit to the brake bleeder screw.
Step 21

Press the brake pedal several times to remove any air from the system.
Step 22

Tighten the brake bleeder screw. Use a combination spanner #11.
Step 23

Disconnect the brake bleeder kit.
Step 24

Clean dirt from the brake hose bolt. Use a brake cleaner.

Replacement: brake hose – SKODA ROOMSTER (5J). AUTODOC recommends:
After applying the spray, wait a few minutes.
Step 25

Tighten the brake caliper bleed screw. Use a drive socket #11. Use a torque wrench. Tighten it to 10 Nm torque.
Step 26

Clean the brake disk surface. Use a wire brush. Treat the surface where the brake disc contacts the wheel rim. Use copper grease.
Step 27

Install the wheel.

Replacement: brake hose – SKODA ROOMSTER (5J). Professionals recommend:
To avoid injury, hold up the wheel when screwing in the fastening bolts.
Step 28

Screw in the wheel bolts. Use wheel impact socket #17.
Step 29

Lower the car and working in a cross order, tighten the wheel bolts. Use a torque wrench. Tighten it to 120 Nm torque.
Step 30

Remove the jacks and chocks.
Step 31

Check the brake fluid level in the expansion tank and refill if necessary.

Step 32

Tighten the brake fluid reservoir cap. Close the hood.

Was this manual helpful?

Please rate this manual on a scale from 1 to 5. If you have any questions, feel free to ask us.

Searching for the right tyres?

Find out which tyre and wheel sizes are compatible with the SKODA Roomster (5J) model.

Browse tyres

How to change front brake discs on SKODA ROOMSTER (5J) – replacement guide

Free download PDF
1.54 MB
How to change front brake pads on SKODA ROOMSTER (5J) – replacement guide

Free download PDF
1.57 MB
How to change front brake caliper on SKODA ROOMSTER (5J) – replacement guide

Free download PDF
2.02 MB
How to change rear brake caliper on SKODA ROOMSTER (5J) – replacement guide

Free download PDF
2.01 MB
How to change brake drum on SKODA Roomster (5J) – replacement guide

Free download PDF
1.97 MB
How to change rear brake shoes on SKODA Roomster (5J) – replacement guide

Free download PDF
2.55 MB

How to change front brake hose on SKODA Roomster Praktik (5J) – replacement guide

Free download PDF
2.56 MB
How to change brake hose on a car – replacement tutorial

Universal

Free download PDF
2.39 MB
How to change front brake hose on Skoda Fabia 6Y5 – replacement guide

Free download PDF
2.57 MB
How to change front brake hose on SKODA Fabia II Hatchback (542) – replacement guide

Free download PDF
2.56 MB
How to change front brake hose on SKODA Fabia I Saloon (6Y3) – replacement guide

Free download PDF
2.56 MB
How to change front brake hose on SKODA Fabia I Hatchback (6Y2) – replacement guide

Free download PDF
2.56 MB

Your profile is your personal assistant.

It can track car expenses, keep a car log and replacement schedule, and save favourite materials, notes and documents

Install the AUTODOC CLUB app!

Your personal car expenses manager, maintenance tips, reminders about upcoming appointments and service intervals, DIY repair instructions – all this on your phone.

Scan

To download the app:

- scan the QR code
- download from App Store
- download from Google Play

How to detect vacuum leaks using a smoke machine | AUTODOC

19K views

Published on: 23/07/2020
5 car interior cleaning mistakes | AUTODOC tips

6K views

Published on: 26/05/2022
Top 6 products for enhancing your car | AUTODOC tips

3K views

Published on: 18/11/2021
Car checks you need to carry out on your car after the winter | AUTODOC tips

3K views

Published on: 23/03/2023