How to carry out replacement: Brake Discs 3.0 si BMW E86
Disclaimer
Change BMW E86 3.0 si Brake Discs yourself – manuals and video tutorials

How to change front brake discs on BMW Z4 Coupe (E86) – replacement guide

downloads: 2
Views: 29
Download your free tutorial and fix BMW Z4 Coupe (E86) 2.5i problems yourself Download for free 1.92 MB Brake Discs for BMW E86 Shop now
Leave a comment Open in a new tab
When to replace the Brake Discs on your BMW Z4
Recommended replacement interval for the part category Brake disc : 50000 km
Important!
This replacement procedure can be used for:
BMW Z4 Coupe (E86) 3.0 si … View more

The steps may slightly vary depending on the car design.

This video shows the replacement procedure of a similar car part on another vehicle

All the parts you need to replace – Brake Discs for Z4 Coupe (E86) and other BMW models
Alternative products
How to change Brake disc on BMW E86 3.0 si – step-by-step instructions for straightforward car repair Brake disc
Tools
Replacement: brake discs – BMW Z4 Coupe (E86). Tools you need:
Wire brush
WD-40 spray
Brake cleaner
Copper grease
Drive socket # 16
HEX bit No.H7.
Torx bit T30
Wheel impact socket #17
Brake caliper wind back tool
Ratchet wrench
Torque wrench
Tap wrench
Crow bar
Impact screwdriver
Rubber mallet
Wheel chock
Buy tools
Replacement: brake discs – BMW Z4 Coupe (E86). AUTODOC recommends:
  • Replace the brake disks on the car BMW Z4 Coupe (E86) in complete set for each axis. Regardless of the state of components. This will ensure even braking.
  • The replacement procedure is identical for both brake disks on the same axle.
  • When changing the brake discs, always replace the brake pads.
  • Please note: all work on the car – BMW Z4 Coupe (E86) – should be done with the engine switched off.
Carry out replacement in the following order:
  1. Step 1
    Open the bonnet. Unscrew the brake fluid reservoir cap.
    Step 2
    How to change Brake Discs on BMW E86 2006 - free PDF and video manuals
    Secure the wheels with chocks.
  2. Step 3
    How to replace BMW Z4 Coupe (E86) 3.0 si 2007 Brake Discs - step-by-step manuals and video guides
    Loosen the wheel mounting bolts. Use wheel impact socket #17.
  3. Step 4
    Raise the front of the car and secure on supports.
    Step 5
    BMW E86 M 2008 Brake Discs replacement: free workshop manuals
    Unscrew the wheel bolts.
    Replacement: brake discs – BMW Z4 Coupe (E86). Tip from AUTODOC:
    To avoid injury, hold up the wheel when unscrewing the bolts.
  4. Step 6
    Changing Brake Discs on BMW Z4 Coupe (E86) 2.5i 2009 by yourself
    Remove the wheel.
  5. Step 7
    How to remove BMW Z4 3.0 si 2006 Brake Discs - online easy-to-follow instructions
    Spread the brake pads. Use a crowbar.
  6. Step 8
    How to replace Brake Discs on BMW Z4 Coupe (E86) 2007: download PDF manuals and video instructions
    Detach the brake caliper retaining spring. Use a crowbar.
  7. Step 9
    How hard is it to do yourself: Brake Discs replacement on BMW E86 M3.2 2008 - download illustrated guide
    Remove the dust boot caps of the brake caliper guide pins. Use a crowbar.
  8. Step 10
    Need to know how to renew Brake Discs on BMW Z4 2009? This free workshop manual will help you to do it yourself
    Unscrew the brake caliper fastening. Use HEX No.H7. Use a ratchet wrench.
  9. Step 11
    Changing of Brake Discs on BMW E86 2006 won't be an issue if you follow this illustrated step-by-step guide
    Remove the brake caliper.
    Replacement: brake discs – BMW Z4 Coupe (E86). Professionals recommend:
    Tie the caliper to the suspension or to the body with a wire without disconnecting from the brake hose to prevent depressurization of the brake system.Make sure that the brake caliper is not hanging on the brake hose.Don't press the brake pedal after the brake caliper has been removed. As a result, the piston can fall out from the brake cylinder, and brake fluid leakage and depressurization of the system may occur.
  10. Step 12
    BMW Z4 3.0 si Brake Discs replacement: online guides and video tutorials
    Remove the brake pads.
  11. Step 13
    Replacing Brake Discs on BMW E86 2008 3.0 si by yourself
    Clean the brake caliper bracket fasteners. Use a wire brush. Use WD-40 spray.
  12. Step 14
    Z4 Coupe (E86) 3.0 si 2009 Brake Discs DIY replacement workshop manual
    Unscrew the caliper bracket fastening. Use a drive socket #16. Use a tap wrench. Use a ratchet wrench.
  13. Step 15
    How to change Brake Discs on BMW Z4 Coupe (E86) 2006 - tips and tricks
    Remove the caliper bracket.
  14. Step 16
    Step-by-step recommendations for DIY replacement BMW E86 2007 3.0 si Brake Discs
    Clean the brake disk surface. Use a wire brush. Use WD-40 spray.
  15. Step 17
    DIY replacement of Brake Discs on BMW Z4 Coupe (E86) M3.2 2008 is not an issue anymore with our step-by-step tutorial
    Unscrew the brake disc fastening. Use Torx T30. Use an impact screwdriver.
    Replacement: brake discs – BMW Z4 Coupe (E86). AUTODOC experts recommend:
    If necessary, use a rubber mallet.
  16. Step 18
    How to change Brake Discs on BMW E86 2006 - free PDF and video manuals
    Remove the brake disc.
  17. Step 19
    How to replace BMW Z4 Coupe (E86) 3.0 si 2007 Brake Discs - step-by-step manuals and video guides
    Clean the hub. Use a wire brush. Treat the contacting surface. Use copper grease.
  18. Step 20
    BMW E86 M 2008 Brake Discs replacement: free workshop manuals
    Install the brake disc.
  19. Step 21
    Changing Brake Discs on BMW Z4 Coupe (E86) 2.5i 2009 by yourself
    Tighten the brake disc fastening. Use Torx T30. Use a torque wrench. Tighten it to 16 Nm torque.
  20. Step 22
    How to remove BMW Z4 3.0 si 2006 Brake Discs - online easy-to-follow instructions
    Clean the mounting seats of the caliper and its bracket. Use a wire brush. Use WD-40 spray.
Was this manual helpful?
Please rate this manual on a scale from 1 to 5. If you have any questions, feel free to ask us.
Users voted – 0
Need New Tyres?

Find out which tyre and wheel sizes are compatible with the BMW Z4 Coupe (E86) model

BMW E86 tyre size

Popular maintenance tutorials for BMW E86

More manuals for BMW E86

Complete guides for changing the Brake rotors on different BMW Z4 models

Unlock your car maintenance assistant!

Track expenses, manage logs, schedule replacements, and more.

DIY BMW Z4 Coupe (E86) Brake Discs replacement - online guide
Tips & tricks for your BMW Z4 Coupe (E86)
View more
  • How to change Brake rotors on BMW Z4 Coupe (E86) M3.2 - replacement tricks
    #DIY Guide: How to Fix a Cracked Windscreen Without a Garage Visit
    8K views
    Published on: 14/12/2023
  • Changing Brake disc BMW E86 3.0 si - Replacement Tips
    Discover the 4 Key Reasons Your CHECK ENGINE Light Could Be On | AUTODOC Tips
    7K views
    Published on: 30/03/2022
  • Maintenance Hacks - BMW Z4 Coupe (E86) M Rotors replacement guide
    What causes engine misfire? | AUTODOC
    6K views
    Published on: 10/07/2020
  • Replace Disc brakes on BMW E86 - free video tips
    The Fast and Easy Way to Fix a Broken Wheel Stud | AUTODOC tips
    9K views
    Published on: 08/12/2020

Most commonly replaced car parts on BMW Z4

Professional manuals for the most common BMW models

Autodoc CLUB App icon
Time to replace parts? Get even better deals in our Shop app.
BMW Z4 Coupe (E86) Brake Discs replace by yourself - Scan QR-code and download AUTODOC CLUB app
SCAN ME