Important!

This replacement procedure can be used for:
VW Caddy II Estate (9K9B) 1.4, VW Caddy II Estate (9K9B) 1.4 16V, VW Caddy II Estate (9K9B) 1.6, VW Caddy II Estate (9K9B) 1.6, VW Caddy II Estate (9K9B) 1.7 SDI, VW Caddy II Estate (9K9B) 1.9 D, VW Caddy II Estate (9K9B) 1.9 SDI, VW Caddy II Estate (9K9B) 1.9 TDI … View more

The steps may slightly vary depending on the car design.

This video shows the replacement procedure of a similar car part on another vehicle

All the parts you need to replace – ABS Sensor for Caddy II Estate (9K9B) and other VW models

Alternative products

ABS sensor

Replacement: ABS sensor – VW CADDY II Estate (9K9B). Tools you might need:

                      Wire brush
                    
                      Nylon cleaning brush
                    
                      WD-40 spray
                    
                      Brake cleaner 
                    
                      Electronic spray
                    
                      Copper grease 
                    
                      Multipurpose grease
                    
                      Torque wrench
                    
                      Torx bit T30
                    
                      HEX bit No.H5
                    
                      HEX bit No.H7
                    
                      Wheel impact socket #17
                    
                      Ratchet wrench
                    
                      Flat screwdriver
                    
                      Pin punch
                    
                      Tap wrench
                    
                      Hammer
                    
                      Crow bar
                    
                      Wheel chock

Buy tools

Replacement: ABS sensor – VW CADDY II Estate (9K9B). Tip from AUTODOC:

All work should be done with the engine stopped.

Replacement: ABS sensor – VW CADDY II Estate (9K9B). Take the following steps:

Step 1

Secure the wheels with chocks.

Step 2

Loosen the wheel mounting bolts. Use wheel impact socket #17.
Step 3

Raise the front of the car and secure on supports.

Step 4

Unscrew the wheel bolts.

AUTODOC recommends:
Warning! To avoid injury, hold the wheel while unscrewing the fastening bolts. VW CADDY II Estate (9K9B)
Step 5

Remove the wheel.
Step 6

Clean the ABS sensor fastener. Use a nylon cleaning brush. Use WD-40 spray.
Step 7

Detach the ABS sensor connector. Use a flat screwdriver.
Step 8

Clean the ABS sensor fastener. Use a wire brush. Use WD-40 spray.
Step 9

Unscrew the ABS sensor fastener. Use HEX No.H5. Use a ratchet wrench.
Step 10

Remove the caps from the brake caliper guide pin boots. Use a crowbar.
Step 11

Unscrew the brake caliper fastening. Use HEX No.H7. Use a ratchet wrench. Use a tap wrench.
Step 12

Spread the brake pads. Use a crowbar.
Step 13

Remove the brake caliper.

Replacement: ABS sensor – VW CADDY II Estate (9K9B). Professionals recommend:
Tie the caliper to the suspension or to the body with a wire without disconnecting from the brake hose to prevent depressurization of the brake system.Make sure that the brake caliper is not hanging on the brake hose.Don't press the brake pedal after the brake caliper has been removed. As a result, the piston can fall out from the brake cylinder, and brake fluid leakage and depressurization of the system may occur. Check the brake caliper bracket, brake caliper guide pins and boots. Clean them. Replace, if necessary.
Step 14

Clean the brake disc fastener. Use a wire brush. Use WD-40 spray.
Step 15

Unscrew the brake disc fastening. Use Torx T30. Use a ratchet wrench.
Step 16

Remove the brake disc.
Step 17

Disconnect the ABS sensor. Use a pin punch. Use a hammer. Use a crowbar.
Step 18

Clean the ABS sensor mounting seat. Use a wire brush. Use WD-40 spray.
Step 19

Treat the ABS sensor fastener. Use a multipurpose grease.
Step 20

Connect the ABS sensor.
Step 21

Tighten the fastener that connects the ABS sensor to the steering knuckle. Use HEX No.H5. Use a torque wrench. Tighten it to 6 Nm torque.
Step 22

Treat the ABS sensor connector. Use dielectric grease.
Step 23

Attach the ABS sensor connector.
Step 24

Clean the hub. Use a wire brush. Treat the contacting surface. Use copper grease.
Step 25

Install the brake disc.
Step 26

Tighten the brake disc fastening. Use Torx T30. Use a torque wrench. Tighten it to 6 Nm torque.
Step 27

Install the brake caliper and fix it. Use HEX No.H7. Use a torque wrench. Tighten it to 30 Nm torque.
Step 28

Install the caps on the brake caliper guide pin boots.
Step 29

Clean the wheel rim mounting seat. Use a wire brush.
Step 30

Treat the surface where the brake disc contacts the wheel rim. Use copper grease.
Step 31

Clean the brake disk surface. Use a brake cleaner.

AUTODOC recommends:
Replacement: ABS sensor – VW CADDY II Estate (9K9B). After applying the spray, wait a few minutes.
Step 32

Install the wheel.

AUTODOC recommends:
Warning! To avoid injury, hold the wheel while screwing in the fastening bolts on the car. VW CADDY II Estate (9K9B)
Step 33

Screw in the wheel bolts. Use wheel impact socket #17.
Step 34

Lower the car and working in a cross order, tighten the wheel bolts. Use wheel impact socket #17. Use a torque wrench. Tighten it to 120 nm torque.
Step 35

Remove the jacks and chocks.

Was this manual helpful?

Please rate this manual on a scale from 1 to 5. If you have any questions, feel free to ask us.

Need New Tyres?

Find out which tyre and wheel sizes are compatible with the VW Caddy II Estate (9K9B) model

VW Caddy II Estate tyre size

How to change rear brake shoes on VW Caddy II Estate (9K9B) – replacement guide

Free download PDF
1.65 MB
How to change rear wheel bearing on VW Caddy II Estate (9K9B) – replacement guide

Free download PDF
1.98 MB
How to change front wheel bearing on VW Caddy II Estate (9K9B) – replacement guide

Free download PDF
4.06 MB
How to change serpentine belt on VW Caddy II Estate (9K9B) – replacement guide

Free download PDF
1.36 MB
How to change spark plugs on VW Caddy II Estate (9K9B) – replacement guide

Free download PDF
1003.52 KB
How to change front windshield wipers on VW Caddy II Estate (9K9B) – replacement guide

Free download PDF
1.56 MB

How to change front ABS sensor on VW Caddy III Van (2KA, 2KH, 2CA, 2CH) – replacement guide

Free download PDF
1.29 MB
How to change front ABS sensor on VW Caddy IV Van (SAA, SAH) – replacement guide

Free download PDF
1.28 MB
How to change front ABS sensor on VW Caddy III Estate (2KB, 2KJ, 2CB, 2CJ) – replacement guide

Free download PDF
1.3 MB
How to change front ABS sensor on VW Caddy IV Kombi (SAB, SAJ) – replacement guide

Free download PDF
1.28 MB
How to change front ABS sensor on VW Caddy II Van (9K9A) – replacement guide

Free download PDF
1.94 MB
How to change rear ABS sensor on VW Caddy II Pickup (9U7) – replacement guide

Free download PDF
1.94 MB

Unlock your car maintenance assistant!

Track expenses, manage logs, schedule replacements, and more.

Checking the starter without removing it | AUTODOC tips

27K views

Published on: 01/12/2020
Easy Steps to Fix Minor Scratches on Your Vehicle | AUTODOC tips

8K views

Published on: 12/05/2022
How to unlock your car without a key | AUTODOC tips

1M views

Published on: 15/09/2022
Coolant comparison test | AUTODOC

14K views

Published on: 18/02/2021