Recommended replacement interval for the part category Spark plug : 2 year / 30000 km

Important!

This replacement procedure can be used for:
OPEL Corsa E Hatchback (X15) 1.4 LPG (08, 68), OPEL Corsa E Hatchback (X15) 1.4 LPG (08, 68), OPEL Corsa E Hatchback (X15) 1.4 (08, 68), OPEL Corsa E Hatchback (X15) 1.4 (08, 68), OPEL Corsa E Hatchback (X15) 1.2 (08, 68) … View more

The steps may slightly vary depending on the car design.

This video shows the replacement procedure of a similar car part on another vehicle

Alternative products

Spark plug

Replacement: spark plugs – OPEL CORSA E. Tools you might need:

                      High-temperature anti-seize lubricant
                    
                      Electronic spray
                    
                      Torx bit T30
                    
                      Spark plug socket # 16
                    
                      Ratchet wrench
                    
                      Torque wrench
                    
                      Flat screwdriver
                    
                      Crow bar
                    
                      Fender cover

Buy tools

Replacement: spark plugs – OPEL CORSA E. Professionals recommend:

The replacement procedure is the same for all spark plugs.
Warning! Shut down the engine before starting any work – OPEL CORSA E.

Carry out replacement in the following order:

Step 1

Open the hood. Use a fender protection cover to prevent damaging paintwork and plastic parts of the car.

Step 2

Remove the engine cover.
Step 3

Detach the connector from the ignition coil. Use a flat screwdriver.
Step 4

Unscrew the ignition coil bracket. Use Torx T30. Use a ratchet wrench.
Step 5

Pry up the ignition coil. Use a crowbar.
Step 6

Take out the ignition coil from the spark plug well.
Step 7

Clean dirt, dust and debris from inside the spark plug wells.
Step 8

Unscrew the spark plugs. Use the spark plug socket #16. Use a ratchet wrench.
Step 9

Take out the spark plugs.
Step 10

Apply a thin layer of a special high temperature anti-seize lubricant to the threads of the new spark plugs.
Step 11

Install the new spark plugs into their mounting seats.
Step 12

Screw new spark plugs and tighten them. Use the spark plug socket #16. Use a torque wrench. Tighten it to 24 nm torque.

Replacement: spark plugs – OPEL CORSA E. AUTODOC recommends:
Don't tighten the plugs with excessive force. Exceeding tightening torque can damage the thread connection. Be careful when working with a spark plug wrench. Its skewing can cause damage to the threaded connection.
Step 13

Install the ignition coil to the spark plug well. Make sure you hear a click indicating that it is locked in place.
Step 14

Tighten the ignition coil fastening. Use Torx T30. Use a torque wrench. Tighten it to 15 nm torque.
Step 15

Treat the ignition coil connector with electronic spray. The spray will protect the electrical contacts from corrosion, oxidation, and will reduce the contact resistance.

Replacement: spark plugs – OPEL CORSA E. Tip:
After applying the spray, wait a few minutes.
Step 16

Plug in the ignition coil connector.
Step 17

Install the engine cover and secure it. Make sure you hear a click indicating that it is locked in place.

Step 18

Run the engine for a few minutes. This is necessary in order to make sure that the component operates properly. Shut off the engine.

Step 19

Remove the fender protection cover.

Step 20

Close the hood.

Was this manual helpful?

Please rate this manual on a scale from 1 to 5. If you have any questions, feel free to ask us.

Need New Tyres?

Find out which tyre and wheel sizes are compatible with the OPEL Corsa E Hatchback (X15) model

Opel Corsa E x15 tyre size

How to change lambda sensor on OPEL Corsa E Hatchback (X15) – replacement guide

Free download PDF
819.2 KB
How to change front brake pads on OPEL Corsa E Hatchback (X15) – replacement guide

Free download PDF
1.55 MB
How to change front brake discs on OPEL Corsa E Hatchback (X15) – replacement guide

Free download PDF
2.06 MB
How to change front wheel bearing on OPEL Corsa E Hatchback (X15) – replacement guide

Free download PDF
4.28 MB
How to change front windshield wipers on OPEL Corsa E Hatchback (X15) – replacement guide

Free download PDF
706.56 KB
How to change engine oil and filter on OPEL Corsa E Hatchback (X15) – replacement guide

Free download PDF
2.72 MB

How to change spark plugs on OPEL Corsa D Hatchback (S07) – replacement guide

Free download PDF
1.25 MB
How to change spark plugs on Opel Corsa C petrol – replacement guide

Free download PDF
1.25 MB
How to change spark plugs on Opel Corsa S93 – replacement guide

Free download PDF
1.25 MB
How to change spark plugs on OPEL Corsa A CC (S83) – replacement guide

Free download PDF
1.25 MB
How to change spark plugs on OPEL Corsa C Van (X01) – replacement guide

Free download PDF
1.25 MB
How to change spark plugs on OPEL Corsa A TR (S83) – replacement guide

Free download PDF
1.25 MB

Unlock your car maintenance assistant!

Track expenses, manage logs, schedule replacements, and more.

TOP 8 mistakes car owners make | AUTODOC tips

14K views

Published on: 09/12/2021
DIY starter repair | AUTODOC tips

157K views

Published on: 31/08/2023
DIY engine block coffee table

5K views

Published on: 25/09/2025
Prevent Engine Damage: How to Identify Rocker Cover Gasket Issues and Proper Replacement | AUTODOC

6K views

Published on: 03/12/2020