Recommended replacement interval for the part category Brake pad set : 30000 km

Important!

This replacement procedure can be used for:
SKODA Octavia II Combi (1Z5) 1.6 TDI 4x4, SKODA Octavia II Combi (1Z5) 1.6 LPG, SKODA Octavia II Combi (1Z5) 2.0 TDI 16V 4x4, SKODA Octavia II Combi (1Z5) 1.8 TSI, SKODA Octavia II Combi (1Z5) 2.0 TDI, SKODA Octavia II Combi (1Z5) 1.6, SKODA Octavia II Combi (1Z5) 1.6 FSI, SKODA Octavia II Combi (1Z5) 1.9 TDI, SKODA Octavia II Combi (1Z5) 2.0 TDI 16V, SKODA Octavia II Combi (1Z5) 2.0 FSI, SKODA Octavia II Combi (1Z5) 2.0 FSI 4x4, SKODA Octavia II Combi (1Z5) 2.0 TDI 4x4, SKODA Octavia II Combi (1Z5) 2.0 TDI, SKODA Octavia II Combi (1Z5) 1.4, SKODA Octavia II Combi (1Z5) 2.0 TDI 16V, SKODA Octavia II Combi (1Z5) 1.6 MultiFuel, SKODA Octavia II Combi (1Z5) 1.6 TDI, SKODA Octavia II Combi (1Z5) 1.4 TSI, SKODA Octavia II Combi (1Z5) 1.2 TSI … View more

The steps may slightly vary depending on the car design.

How to change rear brake pads on OCTAVIA 1Z5 [TUTORIAL AUTODOC]

All the parts you need to replace – Brake Pads for Octavia II Combi (1Z5) and other SKODA models

Alternative products

Brake pad set

Replacement: brake pads – Skoda Octavia 1Z5. List of the tools you'll need:

                      Wire brush
                    
                      Nylon cleaning brush
                    
                      WD-40 spray
                    
                      Brake cleaner
                    
                      Anti-squeal paste
                    
                      Copper grease
                    
                      Combination spanner #13
                    
                      Combination spanner #15
                    
                      Drive socket # 13
                    
                      Wheel impact socket #17
                    
                      Torque wrench
                    
                      Brake caliper wind back tool
                    
                      Crow bar
                    
                      Wheel chock

Buy tools

Replacement: brake pads – Skoda Octavia 1Z5. Professionals recommend:

Perform the replacement of brake pads in complete set for each axis. This provides effective braking.
The replacement procedure is identical for all brake pads on the same axle.
Please note: all work on the car – Skoda Octavia 1Z5 – should be done with the engine switched off.

Carry out replacement in the following order:

Step 1

Open the bonnet. Unscrew the brake fluid reservoir cap.
Step 2

Secure the wheels with chocks.
Step 3

Loosen the wheel mounting bolts. Use wheel impact socket #17.
Step 4

Raise the rear of the car and secure on supports.
Step 5

Unscrew the wheel bolts.

Replacement: brake pads – Skoda Octavia 1Z5. AUTODOC recommends:
To avoid injury, hold up the wheel when unscrewing the bolts.
Step 6

Remove the wheel.
Step 7

Clean the brake caliper fasteners. Use a wire brush. Use WD-40 spray.
Step 8

Unscrew the brake caliper fastening. Use a combination spanner #13. Use a combination spanner #15.
Step 9

Spread the brake pads. Use a crowbar.
Step 10

Remove the brake caliper. Use a crowbar.

Replacement: brake pads – Skoda Octavia 1Z5. AUTODOC experts recommend:
Tie the caliper to the suspension or to the body with a wire without disconnecting from the brake hose to prevent depressurization of the brake system.Make sure that the brake caliper is not hanging on the brake hose.Don't press the brake pedal after the brake caliper has been removed. As a result, the piston can fall out from the brake cylinder, and brake fluid leakage and depressurization of the system may occur. Check the brake caliper bracket, brake caliper guide pins and boots. Clean them. Replace, if necessary.
Step 11

Remove the brake pads. Use a crowbar.

Replacement: brake pads – Skoda Octavia 1Z5. Tip:
Measure the brake disc thickness. Upon reaching the wear limit the part must be replaced.
Step 12

Clean the brake caliper bracket from dirt and dust. Use a wire brush. Use a brake cleaner.

Replacement: brake pads – Skoda Octavia 1Z5. Tip from AUTODOC:
After applying the spray, wait a few minutes.
Step 13

Treat the brake caliper piston. Use a nylon cleaning brush. Use a brake cleaner.

AUTODOC recommends:
Replacement: brake pads – Skoda Octavia 1Z5. After applying the spray, wait a few minutes.
Step 14

Press in the brake caliper piston. Use brake caliper wind back tool.
Step 15

Treat the brake pads in the area where their surface comes into contact with the brake caliper bracket. Use anti-squeal paste.

Replacement: brake pads – Skoda Octavia 1Z5. Tip from AUTODOC experts:
Make sure the disc surface is clean before installing the pads.
Step 16

Install new brake pads.

Replacement: brake pads – Skoda Octavia 1Z5. AUTODOC recommends:
Make sure the pads are installed with linings facing the disc.
Step 17

Install the brake caliper and fix it. Use a combination spanner #15. Use a drive socket #13. Use a torque wrench. Tighten it to 35 Nm torque.
Step 18

Treat the surface where the brake disc contacts the wheel rim. Use copper grease.
Step 19

Clean the brake disk surface. Use a brake cleaner.

Replacement: brake pads – Skoda Octavia 1Z5. Professionals recommend:
After applying the spray, wait a few minutes.
Step 20

Install the wheel.

AUTODOC recommends:
Important! Hold the wheel while screwing in the fastening bolts. Skoda Octavia 1Z5
Step 21

Screw in the wheel bolts. Use wheel impact socket #17.
Step 22

Lower the car and working in a cross order, tighten the wheel bolts. Use wheel impact socket #17. Use a torque wrench. Tighten it to 120 Nm torque.
Step 23

Remove the jacks and chocks.

Replacement: brake pads – Skoda Octavia 1Z5. AUTODOC recommends:
Check the brake fluid level in the expansion tank and refill if necessary.
Step 24

Tighten the brake fluid reservoir cap.

AUTODOC recommends:
Skoda Octavia 1Z5 – Without starting the engine, press the brake pedal several times until it feels firm.
Step 25

Close the hood.

Replacement: brake pads – Skoda Octavia 1Z5. Tip:
Slow down smoothly for first 150-200 km after the brake pads replacement. Avoid unneccessary and sharp braking to a stop.

Was this manual helpful?

Please rate this manual on a scale from 1 to 5. If you have any questions, feel free to ask us.

Need New Tyres?

Find out which tyre and wheel sizes are compatible with the SKODA Octavia II Combi (1Z5) model

Skoda Octavia Mk2 Estate tyre size

How to change rear brake discs on Skoda Octavia 1Z5 – replacement guide

Free download PDF
2.1 MB
How to change front brake discs on Skoda Octavia 1Z5 – replacement guide

Free download PDF
2.26 MB
How to change front brake pads on Skoda Octavia 1Z5 – replacement guide

Free download PDF
1.79 MB
How to change front brake caliper on Skoda Octavia 1Z5 – replacement guide

Free download PDF
2.15 MB
How to change rear brake caliper on SKODA Octavia II Combi (1Z5) – replacement guide

Free download PDF
2.15 MB
How to change front ABS sensor on SKODA Octavia II Combi (1Z5) – replacement guide

Free download PDF
1.3 MB

How to change front brake pads on SKODA Octavia III Hatchback (5E3, NL3, NR3) – replacement guide

Free download PDF
1.58 MB
How to change rear brake pads on SKODA Octavia III Hatchback (5E3, NL3, NR3) – replacement guide

Free download PDF
1.37 MB
How to change front brake pads on SKODA Octavia III Combi (5E5) – replacement guide

Free download PDF
1.58 MB
How to change rear brake pads on SKODA Octavia III Combi (5E5) – replacement guide

Free download PDF
1.37 MB
How to change front brake pads on SKODA OCTAVIA (1Z3) – replacement guide

Free download PDF
1.57 MB
How to change rear brake pads on SKODA OCTAVIA (1Z3) – replacement guide

Free download PDF
1.37 MB

Unlock your car maintenance assistant!

Track expenses, manage logs, schedule replacements, and more.

Unveiling the secrets: Detecting vacuum leaks with a Smoke Machine | AUTODOC

19K views

Published on: 23/07/2020
Engine Overheating? Replace Your Cooling Fan to Fix It

6K views

Published on: 15/11/2020
How to get your motorcycle ready for spring

3K views

Published on: 22/05/2025
K2 ROTON wheel cleaner overview

3K views

Published on: 27/03/2025