Recommended replacement interval for the part category Brake pad set : 30000 km

Important!

This replacement procedure can be used for:
CITROËN DS3 1.6 Racing, CITROËN DS3 1.6 Racing, CITROËN DS3 1.6 THP 150, CITROËN DS3 1.4 HDi 70 (SA8HP4), CITROËN DS3 1.4 VTi 95, CITROËN DS3 1.6 VTi 120, CITROËN DS3 1.6 THP 155, CITROËN DS3 1.6 HDi 90, CITROËN DS3 1.6 HDi 110, CITROËN DS3 1.6 THP160, CITROËN DS3 1.4 VTi 98, CITROËN DS3 1.2 VTi 82, CITROËN DS3 1.4 VTi 95 LPG, CITROËN DS3 1.6 HDi 115, CITROËN DS3 1.6 HDi 115, CITROËN DS3 1.6 BlueHDi 120, CITROËN DS3 1.6 BlueHDi 100, CITROËN DS3 1.2 THP 110, CITROËN DS3 1.6 THP 165, CITROËN DS3 1.6 BlueHDi 75 … View more

The steps may slightly vary depending on the car design.

This video shows the replacement procedure of a similar car part on another vehicle

All the parts you need to replace – Brake Pads for DS3 and other CITROËN models

Alternative products

Brake pad set

402B0029 RIDEX Brake pad set

11,82 GBP

Shop

13.0460-2823.2 ATE Brake pad set

18,60 GBP

Shop

6010092 KRAFT Brake pad set

19,02 GBP

Shop

13.0460-2864.2 ATE Brake pad set

24,31 GBP

Shop

13.0460-2820.2 ATE Brake pad set

24,96 GBP

Shop

13.0460-2886.2 ATE Brake pad set

25,01 GBP

Shop

13.0460-2894.2 ATE Brake pad set

25,88 GBP

Shop

13.0460-2819.2 ATE Brake pad set

26,60 GBP

Shop

13.0460-2860.2 ATE Brake pad set

27,03 GBP

Shop

13.0460-2740.2 ATE Brake pad set

27,76 GBP

Shop

Replacement: brake pads – CITROËN DS3. Tools you need:

                      Wire brush
                    
                      Nylon cleaning brush
                    
                      WD-40 spray
                    
                      All-purpose cleaning spray
                    
                      Brake cleaner 
                    
                      Anti-squeal paste
                    
                      Copper grease 
                    
                      Torque wrench
                    
                      Combination spanner #19
                    
                      Drive socket # 13
                    
                      Wheel impact socket #17
                    
                      Ratchet wrench
                    
                      Brake caliper wind back tool
                    
                      Pliers 
                    
                      Water pump pliers
                    
                      Crow bar
                    
                      Wheel chock

Buy tools

Replacement: brake pads – CITROËN DS3. AUTODOC recommends:

Perform the replacement of brake pads in complete set for each axis. This provides effective braking.
The replacement procedure is identical for all brake pads on the same axle.
Warning! Shut down the engine before starting any work – CITROËN DS3.

Carry out replacement in the following order:

Step 1

Open the bonnet. Unscrew the brake fluid reservoir cap.

Step 2

Secure the wheels with chocks.

Step 3

Loosen the wheel mounting bolts. Use wheel impact socket #17.
Step 4

Raise the rear of the car and secure on supports.

Step 5

Unscrew the wheel bolts.

Replacement: brake pads – CITROËN DS3. Tip:
To avoid injury, hold up the wheel when unscrewing the bolts.
Step 6

Remove the wheel.
Step 7

Clean the fastener of the parking brake cable. Use a wire brush. Use WD-40 spray.
Step 8

Release the parking brake cable. Use water pump pliers. Use pliers. Use a crowbar.
Step 9

Clean the brake caliper fasteners. Use a wire brush. Use all-purpose cleaning spray.
Step 10

Unscrew the brake caliper fastening. Use a combination spanner #19. Use a drive socket #13. Use a ratchet wrench.
Step 11

Spread the brake pads. Use a crowbar.
Step 12

Remove the brake caliper.

Replacement: brake pads – CITROËN DS3. Professionals recommend:
Tie the caliper to the suspension or to the body with a wire without disconnecting from the brake hose to prevent depressurization of the brake system.Make sure that the brake caliper is not hanging on the brake hose.Don't press the brake pedal after the brake caliper has been removed. As a result, the piston can fall out from the brake cylinder, and brake fluid leakage and depressurization of the system may occur. Check the brake caliper bracket, brake caliper guide pins and boots. Clean them. Replace, if necessary.
Step 13

Remove the brake pads. Use a crowbar.

AUTODOC recommends:
Measure the brake disc thickness. Upon reaching the wear limit the part must be replaced.
Step 14

Clean the brake caliper bracket from dirt and dust. Use a wire brush. Use a brake cleaner.

AUTODOC recommends:
After applying the spray, wait a few minutes.
Step 15

Treat the brake caliper piston. Use a nylon cleaning brush. Use a brake cleaner.

Replacement: brake pads – CITROËN DS3. Tip from AUTODOC:
After applying the spray, wait a few minutes.
Step 16

Press in the brake caliper piston. Use brake caliper wind back tool.
Step 17

Treat the brake pads in the area where their surface comes into contact with the brake caliper bracket. Use anti-squeal paste.

AUTODOC recommends:
Make sure the disc surface is clean before installing the pads.
Step 18

Install new brake pads.

Replacement: brake pads – CITROËN DS3. AUTODOC experts recommend:
Make sure the pads are installed with linings facing the disc.
Step 19

Install the brake caliper and fix it. Use a combination spanner #19. Use a drive socket #13. Use a torque wrench. Tighten it to 30 Nm torque.
Step 20

Install the parking brake cable into the brake caliper bracket. Use water pump pliers. Use pliers.
Step 21

Treat the surface where the brake disc contacts the wheel rim. Use copper grease.
Step 22

Clean the brake disk surface. Use a brake cleaner.

AUTODOC recommends:
After applying the spray, wait a few minutes.
Step 23

Install the wheel.

AUTODOC recommends:
Warning! To avoid injury, hold the wheel while screwing in the fastening bolts on the car. CITROËN DS3
Step 24

Screw in the wheel bolts. Use wheel impact socket #17.
Step 25

Lower the car and working in a cross order, tighten the wheel bolts. Use wheel impact socket #17. Use a torque wrench. Tighten it to 100 Nm torque.
Step 26

Remove the jacks and chocks.

AUTODOC recommends:
Check the brake fluid level in the expansion tank and refill if necessary.
Step 27

Tighten the brake fluid reservoir cap.

Step 28

Close the hood.

Replacement: brake pads – CITROËN DS3. AUTODOC experts recommend:
Without starting the engine, press the brake pedal several times until you feel significant resistance.Slow down smoothly for first 150-200 km after the brake pads replacement. Avoid unneccessary and sharp braking to a stop.

Was this manual helpful?

Please rate this manual on a scale from 1 to 5. If you have any questions, feel free to ask us.

Need New Tyres?

Find out which tyre and wheel sizes are compatible with the CITROËN DS3 Hatchback model

Citroen DS3 Hatchback tyre size

How to change front brake discs on CITROËN DS3 – replacement guide

Free download PDF
1.73 MB
How to change front brake pads on CITROËN DS3 – replacement guide

Free download PDF
1.28 MB
How to change rear brake discs on CITROËN DS3 – replacement guide

Free download PDF
2.31 MB
How to change front wheel bearing on CITROËN DS3 – replacement guide

Free download PDF
5 MB
How to change rear wheel bearing on CITROËN DS3 – replacement guide

Free download PDF
2.15 MB
How to change serpentine belt on CITROËN DS3 – replacement guide

Free download PDF
634.88 KB

How to change front brake pads on CITROËN DS3 – replacement guide

Free download PDF
1.28 MB
How to change front brake pads on CITROËN DS3 Convertible – replacement guide

Free download PDF
1.28 MB
How to change rear brake pads on CITROËN DS3 Convertible – replacement guide

Free download PDF
1.59 MB
How to change brake pads on a car – replacement tutorial

Universal

Free download PDF
2.84 MB
How to change front brake pads on Citroen C3 1 – replacement guide

Free download PDF
1.42 MB
How to change front brake pads on Citroen Xsara Picasso – replacement guide

Free download PDF
1.42 MB

Unlock your car maintenance assistant!

Track expenses, manage logs, schedule replacements, and more.

DIY vehicle AC compressor restoration

554K views

Published on: 28/11/2024
Top 5 car noises you shouldn't ignore

6K views

Published on: 10/04/2025
Top 5 possible reasons your car is shaking or vibrating

5K views

Published on: 14/02/2025
How to tighten cylinder head bolts

7K views

Published on: 06/03/2025