Recommended replacement interval for the part category Brake pad set : 30000 km

Important!

This replacement procedure can be used for:
CITROËN C4 Saloon N 1.6, CITROËN C4 Saloon N 1.6 THP, CITROËN C4 Saloon N 1.6, CITROËN C4 Saloon N 2.0 16V, CITROËN C4 Saloon N 1.6 HDi, CITROËN C4 Saloon N 1.6 Flex, CITROËN C4 Saloon N 2.0 Flex, CITROËN C4 Saloon N 1.6 THP 165 … View more

The steps may slightly vary depending on the car design.

This video shows the replacement procedure of a similar car part on another vehicle

All the parts you need to replace – Brake Pads for C4 Saloon N and other CITROËN models

Brake pad set

        Brake pad set for C4 II Saloon Petrol (165 hp)
      
        Brake pad set for C4 II Saloon Petrol/Ethanol (151 hp)
      
        Brake pad set for C4 II Saloon Petrol/Ethanol (173 hp)
      
        Brake pad set for C4 II Saloon Diesel (115 hp)
      
        Brake pad set for C4 II Saloon Petrol (143 hp)
      
        Brake pad set for C4 II Saloon Petrol (116 hp)
      
        Brake pad set for C4 II Saloon Petrol (150 hp)
      
        Brake pad set for C4 II Saloon Petrol (120 hp)

Replacement: brake pads – CITROËN C4 Saloon N. Tools you need:

                        Wire brush
                      
                        Nylon cleaning brush
                      
                        WD-40 spray
                      
                        All-purpose cleaning spray
                      
                        Brake cleaner 
                      
                        Anti-squeal paste
                      
                        Copper grease 
                      
                        Torque wrench
                      
                        Combination spanner #19
                      
                        Drive socket # 13
                      
                        Wheel impact socket #17
                      
                        Ratchet wrench
                      
                        Brake caliper wind back tool
                      
                        Pliers 
                      
                        Water pump pliers
                      
                        Crow bar
                      
                        Wheel chock

Buy tools

Replacement: brake pads – CITROËN C4 Saloon N. AUTODOC recommends:

Perform the replacement of brake pads in complete set for each axis. This provides effective braking.
The replacement procedure is identical for all brake pads on the same axle.
Warning! Shut down the engine before starting any work – CITROËN C4 Saloon N.

Carry out replacement in the following order:

Step 1

Open the bonnet. Unscrew the brake fluid reservoir cap.

Step 2

Secure the wheels with chocks.

Step 3

Loosen the wheel mounting bolts. Use wheel impact socket #17.
Step 4

Raise the rear of the car and secure on supports.

Step 5

Unscrew the wheel bolts.

Replacement: brake pads – CITROËN C4 Saloon N. Tip:
To avoid injury, hold up the wheel when unscrewing the bolts.
Step 6

Remove the wheel.
Step 7

Clean the fastener of the parking brake cable. Use a wire brush. Use WD-40 spray.
Step 8

Release the parking brake cable. Use water pump pliers. Use pliers. Use a crowbar.
Step 9

Clean the brake caliper fasteners. Use a wire brush. Use all-purpose cleaning spray.
Step 10

Unscrew the brake caliper fastening. Use a combination spanner #19. Use a drive socket #13. Use a ratchet wrench.
Step 11

Spread the brake pads. Use a crowbar.
Step 12

Remove the brake caliper.

Replacement: brake pads – CITROËN C4 Saloon N. Professionals recommend:
Tie the caliper to the suspension or to the body with a wire without disconnecting from the brake hose to prevent depressurization of the brake system.Make sure that the brake caliper is not hanging on the brake hose.Don't press the brake pedal after the brake caliper has been removed. As a result, the piston can fall out from the brake cylinder, and brake fluid leakage and depressurization of the system may occur. Check the brake caliper bracket, brake caliper guide pins and boots. Clean them. Replace, if necessary.
Step 13

Remove the brake pads. Use a crowbar.

AUTODOC recommends:
Measure the brake disc thickness. Upon reaching the wear limit the part must be replaced.
Step 14

Clean the brake caliper bracket from dirt and dust. Use a wire brush. Use a brake cleaner.

AUTODOC recommends:
After applying the spray, wait a few minutes.
Step 15

Treat the brake caliper piston. Use a nylon cleaning brush. Use a brake cleaner.

Replacement: brake pads – CITROËN C4 Saloon N. Tip from AUTODOC:
After applying the spray, wait a few minutes.
Step 16

Press in the brake caliper piston. Use brake caliper wind back tool.
Step 17

Treat the brake pads in the area where their surface comes into contact with the brake caliper bracket. Use anti-squeal paste.

AUTODOC recommends:
Make sure the disc surface is clean before installing the pads.
Step 18

Install new brake pads.

Replacement: brake pads – CITROËN C4 Saloon N. AUTODOC experts recommend:
Make sure the pads are installed with linings facing the disc.
Step 19

Install the brake caliper and fix it. Use a combination spanner #19. Use a drive socket #13. Use a torque wrench. Tighten it to 30 Nm torque.
Step 20

Install the parking brake cable into the brake caliper bracket. Use water pump pliers. Use pliers.
Step 21

Treat the surface where the brake disc contacts the wheel rim. Use copper grease.
Step 22

Clean the brake disk surface. Use a brake cleaner.

AUTODOC recommends:
After applying the spray, wait a few minutes.
Step 23

Install the wheel.

AUTODOC recommends:
Warning! To avoid injury, hold the wheel while screwing in the fastening bolts on the car. CITROËN C4 Saloon N
Step 24

Screw in the wheel bolts. Use wheel impact socket #17.
Step 25

Lower the car and working in a cross order, tighten the wheel bolts. Use wheel impact socket #17. Use a torque wrench. Tighten it to 100 Nm torque.
Step 26

Remove the jacks and chocks.

AUTODOC recommends:
Check the brake fluid level in the expansion tank and refill if necessary.
Step 27

Tighten the brake fluid reservoir cap.

Step 28

Close the hood.

Replacement: brake pads – CITROËN C4 Saloon N. AUTODOC experts recommend:
Without starting the engine, press the brake pedal several times until you feel significant resistance.Slow down smoothly for first 150-200 km after the brake pads replacement. Avoid unneccessary and sharp braking to a stop.

Was this manual helpful?

Please rate this manual on a scale from 1 to 5. If you have any questions, feel free to ask us.

Searching for the right tyres?

Find out which tyre and wheel sizes are compatible with the CITROËN C4 II Saloon model.

Browse tyres

How to change front brake discs on CITROËN C4 Saloon N – replacement guide

Free download PDF
1.99 MB
How to change front wheel bearing on CITROËN C4 Saloon N – replacement guide

Free download PDF
5 MB
How to change spark plugs on CITROËN C4 Saloon N – replacement guide

Free download PDF
1003.52 KB
How to change front windshield wipers on CITROËN C4 Saloon N – replacement guide

Free download PDF
696.32 KB
How to change front anti roll bar links on CITROËN C4 Saloon N – replacement guide

Free download PDF
1.34 MB
How to change engine oil and filter on CITROËN C4 Saloon N – replacement guide

Free download PDF
1.52 MB

How to change rear brake pads on CITROËN C4 II (B7) – replacement guide

Free download PDF
1.67 MB
How to change front brake pads on CITROËN C4 CACTUS – replacement guide

Free download PDF
1.28 MB
How to change rear brake pads on CITROËN C4 CACTUS – replacement guide

Free download PDF
1.58 MB
How to change front brake pads on CITROËN C4 I (LC_) – replacement guide

Free download PDF
1.28 MB
How to change rear brake pads on CITROËN C4 I (LC_) – replacement guide

Free download PDF
1.59 MB
How to change rear brake pads on CITROËN C4 Picasso I (UD_) – replacement guide

Free download PDF
1.64 MB

Your profile is your personal assistant.

It can track car expenses, keep a car log and replacement schedule, and save favourite materials, notes and documents

Install the AUTODOC CLUB app!

Your personal car expenses manager, maintenance tips, reminders about upcoming appointments and service intervals, DIY repair instructions – all this on your phone.

Scan

To download the app:

- scan the QR code
- download from App Store
- download from Google Play

Things you should never do with an automatic transmission | AUTODOC tips

6K views

Published on: 26/01/2021
How to choose the right engine oil for your car | AUTODOC

8K views

Published on: 01/07/2020
How to find and change a fuse | AUTODOC

2K views

Published on: 15/08/2020
TOP 5 mistakes when replacing shock absorbers | AUTODOC tips

8K views

Published on: 15/06/2023