How to carry out replacement: Gearbox Oil and Transmission Oil 1.9 TDI Seat Cordoba 6K5
Disclaimer
Change Seat Cordoba 6K5 1.9 SDI Gearbox Oil and Transmission Oil yourself – manuals and video tutorials

How to change manual gearbox oil on SEAT Cordoba Vario (6K5) – replacement guide

downloads: 3
Views: 40
Download your free tutorial and fix SEAT Cordoba Vario (6K5) 1.6 i problems yourself Download for free 1.22 MB Gearbox Oil and Transmission Oil for Seat Cordoba 6K5 Shop now
Leave a comment Open in a new tab
When to replace the Gearbox Oil and Transmission Oil on your SEAT CORDOBA
Recommended replacement interval for the part category Automatic transmission fluid : 60000 km
Important!
This replacement procedure can be used for:
SEAT Cordoba Vario (6K5) 1.4 i, SEAT Cordoba Vario (6K5) 1.9 SDI, SEAT Cordoba Vario (6K5) 1.9 TDI, SEAT Cordoba Vario (6K5) 1.6 i, SEAT Cordoba Vario (6K5) 1.9 TDI, SEAT Cordoba Vario (6K5) 1.6 i … View more

The steps may slightly vary depending on the car design.

This video shows the replacement procedure of a similar car part on another vehicle

All the parts you need to replace – Gearbox Oil and Transmission Oil for Cordoba Vario (6K5) and other SEAT models
Alternative products
How to change Automatic transmission fluid on Seat Cordoba 6K5 1.9 TDI – step-by-step instructions for straightforward car repair Automatic transmission fluid
How to change Manual Transmission Oil on Seat Cordoba 6K5 1.9 TDI – step-by-step instructions for straightforward car repair Manual Transmission Oil
Tools
Replacement: manual gearbox oil – SEAT CORDOBA Vario (6K5). List of the tools you'll need:
Wire brush
All-purpose cleaning spray
HEX bit No.H17.
Drive socket # 12
Phillips screwdriver
Torque wrench
Funnel
Oil drain pan
Fender cover
Buy tools
Replacement: manual gearbox oil – SEAT CORDOBA Vario (6K5). AUTODOC recommends:
  • All work should be done with the engine stopped.
Replacement: manual gearbox oil – SEAT CORDOBA Vario (6K5). Recommended sequence of steps:
  1. Step 1
    Open the hood.
    Step 2
    Use a fender protection cover to prevent damaging paintwork and plastic parts of the car.
    Step 3
    Lift the car using a jack or place it over an inspection pit.
    Replacement: manual gearbox oil – SEAT CORDOBA Vario (6K5). Tip:
    The vehicle must be on even keel, and if it is at an angle, the drain plug must be at the lowest point.
    Step 4
    How to change Gearbox Oil and Transmission Oil on Seat Cordoba 6K5 1996 - free PDF and video manuals
    Unscrew the fasteners of the lower sound insulation. Use a drive socket #12. Use a Phillips screwdriver.
  2. Step 5
    How to replace SEAT Cordoba Vario (6K5) 1.9 TDI 1997 Gearbox Oil and Transmission Oil - step-by-step manuals and video guides
    Remove the lower sound insulation.
  3. Step 6
    Seat Cordoba 6K5 1.6 i 1998 Gearbox Oil and Transmission Oil replacement: free workshop manuals
    Clean the area of the oil pan drainage hole. Use a wire brush. Use all-purpose cleaning spray.
    AUTODOC recommends:
    Replacement: manual gearbox oil – SEAT CORDOBA Vario (6K5). After applying the spray, wait a few minutes.
  4. Step 7
    Changing Gearbox Oil and Transmission Oil on SEAT Cordoba Vario (6K5) 1.4 i 1999 by yourself
    Put a waste oil container with at least 2 l capacity under the drainage hole.
  5. Step 8
    How to remove SEAT CORDOBA 1.4 16V 2000 Gearbox Oil and Transmission Oil - online easy-to-follow instructions
    Unscrew the drain plug. Use HEX No.H17.
  6. Step 9
    How to replace Gearbox Oil and Transmission Oil on SEAT Cordoba Vario (6K5) 2001: download PDF manuals and video instructions
    Drain the used oil.
    Replacement: manual gearbox oil – SEAT CORDOBA Vario (6K5). AUTODOC experts recommend:
    Caution! The oil may be hot.
  7. Step 10
    How hard is it to do yourself: Gearbox Oil and Transmission Oil replacement on Seat Cordoba 6K5 1.9 TDI 2002 - download illustrated guide
    Clean the area around the gearbox housing filler hole. Use a wire brush. Use all-purpose cleaning spray.
    Replacement: manual gearbox oil – SEAT CORDOBA Vario (6K5). Tip from AUTODOC:
    After applying the spray, wait a few minutes.
  8. Step 11
    Need to know how to renew Gearbox Oil and Transmission Oil on SEAT CORDOBA 1996? This free workshop manual will help you to do it yourself
    Unscrew the filler plug of the gearbox housing. Use HEX No.H17.
Was this manual helpful?
Please rate this manual on a scale from 1 to 5. If you have any questions, feel free to ask us.
Users voted – 0
Need New Tyres?

Find out which tyre and wheel sizes are compatible with the SEAT Córdoba I Vario (6K5) model

Seat Cordoba 6K5 tyre size

Popular maintenance tutorials for Seat Cordoba 6K5

More manuals for Seat Cordoba 6K5

Complete guides for changing the Gearbox oil on different SEAT CORDOBA models

Unlock your car maintenance assistant!

Track expenses, manage logs, schedule replacements, and more.

DIY SEAT Cordoba Vario (6K5) Gearbox Oil and Transmission Oil replacement - online guide
Tips & tricks for your SEAT Cordoba Vario (6K5)
View more
  • How to change Gearbox oil on SEAT Cordoba Vario (6K5) 1.9 SDI - replacement tricks
    The most common problems when buying a used car | AUTODOC
    4K views
    Published on: 10/11/2022
  • Changing Gear oil Seat Cordoba 6K5 1.9 TDI - Replacement Tips
    How to Get the Best Deals on Car Parts | Save Money with AUTODOC
    2K views
    Published on: 03/02/2022
  • Maintenance Hacks - SEAT Cordoba Vario (6K5) 1.6 i Transmission oil replacement guide
    Drive with Care: 8 Common Bad Driving Habits Explained | AUTODOC
    4K views
    Published on: 01/04/2021
  • Replace Manual gearbox oil on Seat Cordoba 6K5 - free video tips
    DIY rear axle restoration | Drivetrain restoration – Part 2
    6K views
    Published on: 07/11/2024

Most commonly replaced car parts on SEAT CORDOBA

Professional manuals for the most common SEAT models

Autodoc CLUB App icon
Time to replace parts? Get even better deals in our Shop app.
SEAT Cordoba Vario (6K5) Gearbox Oil and Transmission Oil replace by yourself - Scan QR-code and download AUTODOC CLUB app
SCAN ME