How to carry out replacement: Gearbox Oil and Transmission Oil 1.0 Seat Arosa 6h
Disclaimer
Change Seat Arosa 6h 1.4 TDI Gearbox Oil and Transmission Oil yourself – manuals and video tutorials

How to change manual gearbox oil on SEAT AROSA (6H) – replacement guide

downloads: 22
Views: 301
Download your free tutorial and fix SEAT AROSA (6H) 1.7 SDI problems yourself Download for free 1.22 MB Gearbox Oil and Transmission Oil for Seat Arosa 6h Shop now
Leave a comment Open in a new tab
When to replace the Gearbox Oil and Transmission Oil on your SEAT AROSA
Recommended replacement interval for the part category Automatic transmission fluid : 50000 km
Important!
This replacement procedure can be used for:
SEAT AROSA (6H) 1.0, SEAT AROSA (6H) 1.4, SEAT AROSA (6H) 1.7 SDI, SEAT AROSA (6H) 1.4 16V, SEAT AROSA (6H) 1.4 TDI, SEAT AROSA (6H) 1.0 … View more

The steps may slightly vary depending on the car design.

This video shows the replacement procedure of a similar car part on another vehicle

All the parts you need to replace – Gearbox Oil and Transmission Oil for AROSA (6H) and other SEAT models
Alternative products
How to change Automatic transmission fluid on Seat Arosa 6h 1.0 – step-by-step instructions for straightforward car repair Automatic transmission fluid
How to change Manual Transmission Oil on Seat Arosa 6h 1.0 – step-by-step instructions for straightforward car repair Manual Transmission Oil
How to change Axle Gear Oil on Seat Arosa 6h 1.0 – step-by-step instructions for straightforward car repair Axle Gear Oil
Tools
Replacement: manual gearbox oil – SEAT AROSA (6H). List of the tools you'll need:
Wire brush
All-purpose cleaning spray
HEX bit No.H17.
Drive socket # 12
Phillips screwdriver
Torque wrench
Funnel
Oil drain pan
Fender cover
Buy tools
Replacement: manual gearbox oil – SEAT AROSA (6H). AUTODOC recommends:
  • All work should be done with the engine stopped.
Replacement: manual gearbox oil – SEAT AROSA (6H). Recommended sequence of steps:
  1. Step 1
    Open the hood.
    Step 2
    Use a fender protection cover to prevent damaging paintwork and plastic parts of the car.
    Step 3
    Lift the car using a jack or place it over an inspection pit.
    Replacement: manual gearbox oil – SEAT AROSA (6H). Tip:
    The vehicle must be on even keel, and if it is at an angle, the drain plug must be at the lowest point.
    Step 4
    How to change Gearbox Oil and Transmission Oil on Seat Arosa 6h 1997 - free PDF and video manuals
    Unscrew the fasteners of the lower sound insulation. Use a drive socket #12. Use a Phillips screwdriver.
  2. Step 5
    How to replace SEAT AROSA (6H) 1.0 1998 Gearbox Oil and Transmission Oil - step-by-step manuals and video guides
    Remove the lower sound insulation.
  3. Step 6
    Seat Arosa 6h 1.4 1999 Gearbox Oil and Transmission Oil replacement: free workshop manuals
    Clean the area of the oil pan drainage hole. Use a wire brush. Use all-purpose cleaning spray.
    AUTODOC recommends:
    Replacement: manual gearbox oil – SEAT AROSA (6H). After applying the spray, wait a few minutes.
  4. Step 7
    Changing Gearbox Oil and Transmission Oil on SEAT AROSA (6H) 1.4 TDI 2000 by yourself
    Put a waste oil container with at least 2 l capacity under the drainage hole.
  5. Step 8
    How to remove SEAT AROSA 1.4 16V 2001 Gearbox Oil and Transmission Oil - online easy-to-follow instructions
    Unscrew the drain plug. Use HEX No.H17.
  6. Step 9
    How to replace Gearbox Oil and Transmission Oil on SEAT AROSA (6H) 2002: download PDF manuals and video instructions
    Drain the used oil.
    Replacement: manual gearbox oil – SEAT AROSA (6H). AUTODOC experts recommend:
    Caution! The oil may be hot.
  7. Step 10
    How hard is it to do yourself: Gearbox Oil and Transmission Oil replacement on Seat Arosa 6h 1.4 2003 - download illustrated guide
    Clean the area around the gearbox housing filler hole. Use a wire brush. Use all-purpose cleaning spray.
    Replacement: manual gearbox oil – SEAT AROSA (6H). Tip from AUTODOC:
    After applying the spray, wait a few minutes.
  8. Step 11
    Need to know how to renew Gearbox Oil and Transmission Oil on SEAT AROSA 2004? This free workshop manual will help you to do it yourself
    Unscrew the filler plug of the gearbox housing. Use HEX No.H17.
Was this manual helpful?
Please rate this manual on a scale from 1 to 5. If you have any questions, feel free to ask us.
Users voted – 0
Need New Tyres?

Find out which tyre and wheel sizes are compatible with the SEAT Arosa (6H) model

Seat Arosa 6h tyre size

Popular maintenance tutorials for Seat Arosa 6h

More manuals for Seat Arosa 6h

Complete guides for changing the Gearbox oil on different SEAT AROSA models

Unlock your car maintenance assistant!

Track expenses, manage logs, schedule replacements, and more.

DIY SEAT AROSA (6H) Gearbox Oil and Transmission Oil replacement - online guide
Tips & tricks for your SEAT AROSA (6H)
View more
  • How to change Gearbox oil on SEAT AROSA (6H) 1.7 SDI - replacement tricks
    DIY brake caliper restoration | AUTODOC tips
    817K views
    Published on: 02/06/2022
  • Changing Gear oil Seat Arosa 6h 1.0 - Replacement Tips
    How to Safely Wash Your Car in Winter Without Damage | AUTODOC tips
    3K views
    Published on: 31/01/2024
  • Maintenance Hacks - SEAT AROSA (6H) 1.4 Transmission oil replacement guide
    5 Essential Tips for beginner drivers: Avoid Common Mistakes
    4K views
    Published on: 31/01/2023
  • Replace Manual gearbox oil on Seat Arosa 6h - free video tips
    DIY car soundproofing | AUTODOC tips
    107K views
    Published on: 15/04/2021

Most commonly replaced car parts on SEAT AROSA

Professional manuals for the most common SEAT models

ОЕ number
Autodoc CLUB App icon
Time to replace parts? Get even better deals in our Shop app.
SEAT AROSA (6H) Gearbox Oil and Transmission Oil replace by yourself - Scan QR-code and download AUTODOC CLUB app
SCAN ME