Recommended replacement interval for the part category Fuel filter : 12 month / 15000 km

Important!

This replacement procedure can be used for:
VAUXHALL CORSAVAN Mk I (B) 1.4 i … View more

The steps may slightly vary depending on the car design.

This video shows the replacement procedure of a similar car part on another vehicle

All the parts you need to replace – Fuel Filter for CORSAVAN Mk I (B) and other VAUXHALL models

Alternative products

Fuel filter

J1330901 HERTH+BUSS JAKOPARTS Fuel filter

6,05 GBP

Shop

152071760676 MAGNETI MARELLI Fuel filter

6,88 GBP

Shop

WK 512 MANN-FILTER Fuel filter

8,52 GBP

Shop

WK 55/3 MANN-FILTER Fuel filter

8,82 GBP

Shop

H110WK HENGST FILTER Fuel filter

8,99 GBP

Shop

0 450 905 969 BOSCH Fuel filter

9,49 GBP

Shop

0 450 905 316 BOSCH Fuel filter

12,11 GBP

Shop

SKFF-0870002 STARK Fuel filter

13,57 GBP

Shop

0 450 905 273 BOSCH Fuel filter

15,38 GBP

Shop

EFP202 DELPHI Fuel filter

18,19 GBP

Shop

Replacement: fuel filter – VAUXHALL CORSAVAN Mk I (B). Tools you might need:

                      Torx bit T20
                    
                      Fuel line pliers
                    
                      Fluid container

Buy tools

Replacement: fuel filter – VAUXHALL CORSAVAN Mk I (B). Tip from AUTODOC:

Ensure adequate ventilation of the workplace. Fuel vapors are poisonous.
All work should be done with the engine stopped.

Replacement: fuel filter – VAUXHALL CORSAVAN Mk I (B). Take the following steps:

Step 1

Open the fuel door. Unscrew the fuel filler cap.

Step 2

Lift the car using a jack or place it over an inspection pit.

Step 3

Prepare a container for fluids.
Step 4

Squeeze the clips and detach the fuel supply lines from the fuel filter housing. Use fuel line pliers.

Replacement: fuel filter – VAUXHALL CORSAVAN Mk I (B). AUTODOC recommends:
Be careful! Fuel may leak from the filter housing and hoses.
Step 5

Loosen the fuel filter mounting. Use Torx T20.
Step 6

Remove the fuel filter. Put the old filter cartridge in the container.
Step 7

Remove the retainers of the fasteners of the fuel filter tubes.
Step 8

Install the retainers of the fasteners of the fuel filter tubes.
Step 9

Install a new fuel filter.
Step 10

Tighten the fuel filter fasteners. Use Torx T20.

Replacement: fuel filter – VAUXHALL CORSAVAN Mk I (B). Tip:
Remember, it is important not to mix up the input and output of the filter. Arrows on the filter indicate the direction of fuel flow.During installation, take care to prevent dust and dirt from getting into the fuel filter housing.Take care to only use quality filters.
Step 11

Connect the fuel lines to the fuel filter and lock the fastening clips.

Step 12

Lower the car.

Step 13

Tighten the fuel filler cap. Close the fuel door.

Replacement: fuel filter – VAUXHALL CORSAVAN Mk I (B). Professionals recommend:
Before starting off, switch the ignition on and off several times. This should be done to activate the fuel pump to make it pump fuel through the fuel system.
Step 14

Run the engine for a few minutes. This is necessary in order to make sure that the component operates properly.

Replacement: fuel filter – VAUXHALL CORSAVAN Mk I (B). Tip from AUTODOC:
To protect the environment from pollution, be sure to dispose of the used filters at special collection points.

Was this manual helpful?

Please rate this manual on a scale from 1 to 5. If you have any questions, feel free to ask us.

Searching for the right tyres?

Find out which tyre and wheel sizes are compatible with the VAUXHALL Corsavan Mk1 (B) model.

VAUXHALL CORSAVAN Mk I (B) tyre size

How to change air filter on VAUXHALL CORSAVAN Mk I (B) – replacement guide

Free download PDF
993.28 KB
How to change engine oil and filter on VAUXHALL CORSAVAN Mk I (B) – replacement guide

Free download PDF
1.65 MB
How to change front brake pads on VAUXHALL CORSAVAN Mk I (B) – replacement guide

Free download PDF
1.46 MB
How to change front brake discs on VAUXHALL CORSAVAN Mk I (B) – replacement guide

Free download PDF
1.92 MB
How to change front wheel bearing on VAUXHALL CORSAVAN Mk I (B) – replacement guide

Free download PDF
4.61 MB
How to change rear wheel bearing on VAUXHALL CORSAVAN Mk I (B) – replacement guide

Free download PDF
1.94 MB

How to change fuel filter on VAUXHALL Corsa Mk III (D) Hatchback (S07) – replacement guide

Free download PDF
1.03 MB
How to change fuel filter on VAUXHALL Corsa Mk IV (E) Hatchback (X15) – replacement guide

Free download PDF
1.02 MB
How to change fuel filter on VAUXHALL Corsa Mk II (C) Hatchback (X01) – replacement guide

Free download PDF
921.6 KB
How to change fuel filter on VAUXHALL Corsa Mk I (B) Hatchback (S93) – replacement guide

Free download PDF
778.24 KB
How to change fuel filter on VAUXHALL Corsavan Mk III (D) (S07) – replacement guide

Free download PDF
1.02 MB
How to change fuel filter on VAUXHALL Corsavan Mk IV (E) Van (X15) – replacement guide

Free download PDF
1.02 MB

Your profile is your personal assistant.

It can track car expenses, keep a car log and replacement schedule, and save favourite materials, notes and documents

Install the AUTODOC CLUB app!

Your personal car expenses manager, maintenance tips, reminders about upcoming appointments and service intervals, DIY repair instructions – all this on your phone.

Scan

To download the app:

- scan the QR code
- download from App Store
- download from Google Play

What to do if your car's air conditioning isn't working properly | AUTODOC tips

6K views

Published on: 05/08/2021
How to choose the right engine oil for your car | AUTODOC

8K views

Published on: 01/07/2020
What to do if the airbag light is on | AUTODOC tips

6K views

Published on: 10/04/2023
8 bad driving habits | AUTODOC tips

4K views

Published on: 01/04/2021