Recommended replacement interval for the part category Fuel filter : 240000 km

Important!

This replacement procedure can be used for:
NISSAN Kubistar Van (X76) 1.2, NISSAN Kubistar Van (X76) 1.2 16V, NISSAN Kubistar Van (X76) 1.6 16V, NISSAN Kubistar Van (X76) 1.4 … View more

The steps may slightly vary depending on the car design.

This video shows the replacement procedure of a similar car part on another vehicle

All the parts you need to replace – Fuel Filter for Kubistar Van (X76) and other NISSAN models

Fuel filter

        Fuel filter for Kubistar Van (X76) Petrol (60 hp)
      
        Fuel filter for Kubistar Van (X76) Petrol (75 hp)
      
        Fuel filter for Kubistar Van (X76) Petrol (95 hp)
      
        Fuel filter for Kubistar Van (X76) Petrol (75 hp)

Replacement: fuel filter – NISSAN KUBISTAR Box (X80). Tools you might need:

                        Nylon cleaning brush
                      
                        All-purpose cleaning spray
                      
                        Fuel line pliers
                      
                        Fluid container

Buy tools

Replacement: fuel filter – NISSAN KUBISTAR Box (X80). AUTODOC experts recommend:

Ensure adequate ventilation of the workplace. Fuel vapors are poisonous.
Please note: all work on the car – NISSAN KUBISTAR Box (X80) – should be done with the engine switched off.

Carry out replacement in the following order:

Step 1

Open the fuel door.
Step 2

Unscrew the fuel filler cap.
Step 3

Raise the car.

Replacement: fuel filter – NISSAN KUBISTAR Box (X80). Tip:
If you are using a jack, make sure it rests on a flat surface without any unevenness.Be sure to additionally secure the car with jack stands.
Step 4

Prepare a container for fluids.
Step 5

Clean the fasteners of the fuel supply lines. Use a nylon cleaning brush. Use all-purpose cleaning spray.
Step 6

Squeeze the clips and detach the fuel supply lines from the fuel filter housing. Use fuel line pliers.

AUTODOC recommends:
Be careful! Fuel may leak from the filter housing and hoses.
Step 7

Remove the fuel filter.
Step 8

Put the old filter cartridge in the container.

Step 9

Clean the fuel filter bracket. Clean the fasteners of the fuel supply lines. Use all-purpose cleaning spray.
Step 10

Install a new fuel filter.

Replacement: fuel filter – NISSAN KUBISTAR Box (X80). Tip from AUTODOC:
Remember, it is important not to mix up the input and output of the filter. Arrows on the filter indicate the direction of fuel flow.During installation, take care to prevent dust and dirt from getting into the fuel filter housing.NISSAN KUBISTAR Box (X80) – It's important to only use high-quality filters.
Step 11

Connect the fuel supply lines to the fuel filter.
Step 12

Clean the fuel lines. Use all-purpose cleaning spray.
Step 13

Lower the car.

Step 14

Tighten the fuel filler cap.
Step 15

Close the fuel door.

AUTODOC recommends:
Before starting off, switch the ignition on and off several times. This should be done to activate the fuel pump to make it pump fuel through the fuel system.
Step 16

Run the engine for a few minutes. This is necessary in order to make sure that the component operates properly.

Step 17

Shut off the engine.

Replacement: fuel filter – NISSAN KUBISTAR Box (X80). AUTODOC experts recommend:
To protect the environment from pollution, be sure to dispose of the used filters at special collection points.

Was this manual helpful?

Please rate this manual on a scale from 1 to 5. If you have any questions, feel free to ask us.

Searching for the right tyres?

Find out which tyre and wheel sizes are compatible with the NISSAN Kubistar Van (X76) model.

Browse tyres

How to change pollen filter on NISSAN Kubistar Van (X76) – replacement guide

Free download PDF
1.01 MB
How to change air filter on NISSAN Kubistar Van (X76) – replacement guide

Free download PDF
1.08 MB
How to change engine oil and filter on NISSAN Kubistar Van (X76) – replacement guide

Free download PDF
1.17 MB
How to change front brake pads on NISSAN Kubistar Van (X76) – replacement guide

Free download PDF
1.45 MB
How to change front brake discs on NISSAN Kubistar Van (X76) – replacement guide

Free download PDF
1.48 MB
How to change front wheel bearing on NISSAN Kubistar Van (X76) – replacement guide

Free download PDF
3.4 MB

How to change fuel filter on a car – replacement tutorial

Universal

Free download PDF
2 MB
How to change fuel filter on Nissan X Trail T30 – replacement guide

Free download PDF
1.86 MB
How to change fuel filter on Nissan Micra K12 – replacement guide

Free download PDF
2.46 MB
How to change fuel filter on NISSAN ALMERA II Hatchback (N16) – replacement guide

Free download PDF
1.75 MB
How to change fuel filter on NISSAN ALMERA I Hatchback (N15) – replacement guide

Free download PDF
1.75 MB
How to change fuel filter on NISSAN Elgrand (E50) – replacement guide

Free download PDF
1.75 MB

Your profile is your personal assistant.

It can track car expenses, keep a car log and replacement schedule, and save favourite materials, notes and documents

Install the AUTODOC CLUB app!

Your personal car expenses manager, maintenance tips, reminders about upcoming appointments and service intervals, DIY repair instructions – all this on your phone.

Scan

To download the app:

- scan the QR code
- download from App Store
- download from Google Play

How to save when buying car parts

2K views

Published on: 03/02/2022
3 things that cause engine damage | AUTODOC tips

9K views

Published on: 07/10/2021
How to Make a DIY Foam Sprayer | AUTODOC tips

208K views

Published on: 23/06/2022
What to do if your car's air conditioning isn't working properly | AUTODOC tips

6K views

Published on: 05/08/2021