Recommended replacement interval for the part category Fuel filter : 60000 km

Important!

This replacement procedure can be used for:
CITROËN C4 Grand Picasso I (UA_) 2.0 HDi 138 … View more

The steps may slightly vary depending on the car design.

This video shows the replacement procedure of a similar car part on another vehicle

All the parts you need to replace – Fuel Filter for C4 Grand Picasso I (UA_) and other CITROËN models

Fuel filter

Fuel filter for C4 I Grand Picasso Diesel (136 hp)

Replacement: fuel filter – CITROËN C4 Grand Picasso I (UA_). Tools you might need:

                        All-purpose cleaning spray
                      
                        Drive socket # 27 
                      
                        Ratchet wrench
                      
                        Flat Screwdriver
                      
                        Clip removal tool
                      
                        Hand-operated fluid syringe

                        Fluid container
                      
                        Fender cover

Buy tools

Replacement: fuel filter – CITROËN C4 Grand Picasso I (UA_). AUTODOC experts recommend:

Ensure adequate ventilation of the workplace. Fuel vapors are poisonous.
All work should be done with the engine stopped.

Replacement: fuel filter – CITROËN C4 Grand Picasso I (UA_). Recommended sequence of steps:

Step 1

Open the hood.

Step 2

Use a fender protection cover to prevent damaging paintwork and plastic parts of the car.

Step 3

Remove the engine cover.

AUTODOC recommends:
Replacement: fuel filter – CITROËN C4 Grand Picasso I (UA_). To avoid damaging the part during installation, do not use excessive force.
Step 4

Clean the fasteners of the fuel supply lines. Use all-purpose cleaning spray.
Step 5

Detach the fuel pressure sensor connector. Use a flat screwdriver.
Step 6

Squeeze the clips and detach the fuel supply lines from the fuel filter housing. Use a flat screwdriver. Use a clip removal tool.

Replacement: fuel filter – CITROËN C4 Grand Picasso I (UA_). Tip:
Be careful! Fuel may leak from the filter housing and hoses.
Step 7

Close the fuel lines with caps.
Step 8

Unscrew the fasteners of the fuel filter housing cover. Use a drive socket #27. Use a ratchet wrench.
Step 9

Remove the fuel filter cover with the old filter cartridge attached.
Step 10

Prepare a container for fluids.

Step 11

Put the fuel filter cover with the old filter cartridge into a container.
Step 12

Pump the fuel out of the fuel filter housing. Use a hand-operated fluid syringe.
Step 13

Remove the old sealing ring. Use a flat screwdriver.
Step 14

Remove the fuel filter.
Step 15

Clean the fuel filter housing and the cover. Use all-purpose cleaning spray.
Step 16

Install the new sealing ring.
Step 17

Install a new fuel filter.

Replacement: fuel filter – CITROËN C4 Grand Picasso I (UA_). AUTODOC recommends:
Make sure that the fuel filter is positioned correctly. Consider the fuel flow direction mark.During installation, take care to prevent dust and dirt from getting into the fuel filter housing.Take care to only use quality filters.
Step 18

Install the fuel filter cover with the filter cartridge attached.
Step 19

Tighten the fasteners of the fuel filter cover. Use a drive socket #27. Use a ratchet wrench. Remove the caps from the fuel lines.
Step 20

Connect the fuel lines to the fuel filter and lock the fastening clips.
Step 21

Attach the fuel pressure sensor connector.
Step 22

Clean the fuel lines. Use all-purpose cleaning spray.
Step 23

Press the fuel primer pump several times until it gets hard.
Step 24

Install the engine cover and secure it.

Replacement: fuel filter – CITROËN C4 Grand Picasso I (UA_). Professionals recommend:
Make sure the engine cover is properly seated. It should not be displaced with respect to the guiding fasteners.Do not apply excessive force when installing the part. Otherwise you may damage the fasteners.
Step 25

Run the engine for a few minutes. This is necessary in order to make sure that the component operates properly.

Step 26

Shut off the engine.

Step 27

Remove the fender protection cover.

Step 28

Close the hood.

Replacement: fuel filter – CITROËN C4 Grand Picasso I (UA_). Tip from AUTODOC:
To protect the environment from pollution, be sure to dispose of the used filters at special collection points.

Was this manual helpful?

Please rate this manual on a scale from 1 to 5. If you have any questions, feel free to ask us.

Searching for the right tyres?

Find out which tyre and wheel sizes are compatible with the CITROËN C4 I Grand Picasso model.

Browse tyres

How to change engine oil and filter on CITROËN C4 Grand Picasso I (UA_) – replacement guide

Free download PDF
1.53 MB
How to change air filter on CITROËN C4 Grand Picasso I (UA_) – replacement guide

Free download PDF
1.16 MB
How to change front brake discs on CITROËN C4 Grand Picasso I (UA_) – replacement guide

Free download PDF
1.99 MB
How to change front wheel bearing on CITROËN C4 Grand Picasso I (UA_) – replacement guide

Free download PDF
5.01 MB
How to change serpentine belt on CITROËN C4 Grand Picasso I (UA_) – replacement guide

Free download PDF
716.8 KB
How to change spark plugs on CITROËN C4 Grand Picasso I (UA_) – replacement guide

Free download PDF
1.16 MB

How to change fuel filter on CITROËN C4 Grand Picasso II – replacement guide

Free download PDF
931.84 KB
How to change fuel filter on CITROËN C4 Picasso II – replacement guide

Free download PDF
931.84 KB
How to change fuel filter on CITROËN C4 II (B7) – replacement guide

Free download PDF
942.08 KB
How to change fuel filter on CITROËN C4 CACTUS – replacement guide

Free download PDF
931.84 KB
How to change fuel filter on CITROËN C4 I (LC_) – replacement guide

Free download PDF
1.41 MB
How to change fuel filter on CITROËN C4 Picasso I (UD_) – replacement guide

Free download PDF
1.42 MB

Your profile is your personal assistant.

It can track car expenses, keep a car log and replacement schedule, and save favourite materials, notes and documents

Install the AUTODOC CLUB app!

Your personal car expenses manager, maintenance tips, reminders about upcoming appointments and service intervals, DIY repair instructions – all this on your phone.

Scan

To download the app:

- scan the QR code
- download from App Store
- download from Google Play

How to replace the suspension on a BMW E30 Turbo | SUPERCAR AUTODOC

1K views

Published on: 04/03/2021
Causes of a worn car boot damper | AUTODOC

3K views

Published on: 04/07/2021
Top 5 mistakes when replacing spark plugs | AUTODOC tips

9K views

Published on: 13/07/2023
What to do if the airbag light is on | AUTODOC tips

5K views

Published on: 10/04/2023