Important!

This replacement procedure can be used for:
OPEL ZAFIRA B (A05) 1.8 (M75) … View more

The steps may slightly vary depending on the car design.

This video shows the replacement procedure of a similar car part on another vehicle

All the parts you need to replace – Springs for ZAFIRA B Van and other OPEL models

Alternative products

Coil spring

Replacement: coil springs – OPEL ZAFIRA B Van. List of the tools you'll need:

                      Wire brush
                    
                      WD-40 spray
                    
                      Brake cleaner 
                    
                      Copper grease 
                    
                      Combination spanner #18
                    
                      Combination spanner #19
                    
                      HEX bit no.H6.
                    
                      Drive socket # 18 
                    
                      Drive socket # 19 
                    
                      Drive socket # 22 
                    
                      Wheel impact socket #17
                    
                      Ratchet wrench
                    
                      Torque wrench
                    
                      Flat Screwdriver
                    
                      Tap wrench
                    
                      Clip removal tool
                    
                      Water pump pliers
                    
                      Crow bar
                    
                      Rubber mallet
                    
                      Hydraulic strut spring compressor
                    
                      Hydraulic transmission jack
                    
                      Fender cover
                    
                      Wheel chock

Buy tools

Replacement: coil springs – OPEL ZAFIRA B Van. AUTODOC experts recommend:

Both coil springs of the front suspension should be replaced simultaneously.
The replacement procedure is identical for the left and right coil springs of the front suspension.
Please note: all work on the car – OPEL ZAFIRA B Van – should be done with the engine switched off.

Carry out replacement in the following order:

Step 1

Open the hood.

Step 2

Use a fender protection cover to prevent damaging paintwork and plastic parts of the car.

Step 3

Remove the cowl grille seal.
Step 4

Raise up and remove the cowl grille.
Step 5

Remove the shock strut mount cap. Use a flat screwdriver.
Step 6

Clean the fasteners of the shock strut upper mount. Use a wire brush. Use WD-40 spray.
Step 7

Remove the retainer of the shock strut upper mount. Use a clip removal tool.
Step 8

Secure the wheels with chocks.
Step 9

Loosen the wheel mounting bolts. Use wheel impact socket #17.
Step 10

Raise the front of the car and secure on supports.

Step 11

Unscrew the wheel bolts.

AUTODOC recommends:
Warning! To avoid injury, hold the wheel while unscrewing the fastening bolts. OPEL ZAFIRA B Van
Step 12

Remove the wheel.
Step 13

Clean the stabiliser link fasteners. Use a wire brush. Use WD-40 spray.
Step 14

Unscrew the nut and remove the stabilizer rod from the shock strut. Use a combination spanner #19. Use a drive socket #19. Use a ratchet wrench.
Step 15

Remove the stabilizer rod.

Step 16

Clean the fasteners connecting the shock strut to the steering knuckle. Use a wire brush. Use WD-40 spray.
Step 17

Unscrew the lower fastener connecting the shock strut to the steering knuckle. Use a combination spanner #18. Use a drive socket #18. Use a tap wrench.
Step 18

Clean the fasteners of the ABS sensor and of the brake hose which connect them to the shock strut. Use a wire brush. Use WD-40 spray.
Step 19

Disconnect the fastener of the ABS sensor cable from the shock absorber strut. Use a flat screwdriver.
Step 20

Detach the brake hose from the shock strut. Use water pump pliers.
Step 21

Prop up the steering knuckle. Use a hydraulic transmission jack.

Step 22

Remove the fastening bolts.
Step 23

Disconnect the steering knuckle from the shock absorber strut. Use a crowbar.
Step 24

Remove the retainer of the shock strut upper mount.

Replacement: coil springs – OPEL ZAFIRA B Van. AUTODOC recommends:
To avoid injury, hold the shock strut firmly when dismantling it.
Step 25

Remove the suspension strut.
Step 26

Set the shock absorber strut on the spring compressor tool.

Replacement: coil springs – OPEL ZAFIRA B Van. Tip from AUTODOC experts:
Note that when using a spring compressor, spring coils need to be securely gripped, compressing the spring on the opposite sides.Ensure the correct position of the spring in the retainer.Make sure that the spring coils tightly entered the lock handles.
Step 27

Compress the spring.
Step 28

Remove the strut piston rod nut. Use HEX No.H6. Use a drive socket #22. Use a ratchet wrench.
Step 29

Remove the top strut mount.
Step 30

Release the coil spring.
Step 31

Remove the shock absorber dust cap and the bump stop.

AUTODOC recommends:
Replacement: coil springs – OPEL ZAFIRA B Van. Carefully inspect the mount, the boot, and the bump stop of the shock absorber. Replace if necessary.
Step 32

Remove the spring.
Step 33

Install the spring on the shock absorber.
Step 34

Compress the spring.
Step 35

Install the mount, the boot and the bump stop on the shock absorber.
Step 36

Tighten the shock strut piston rod nut. Use HEX No.H6. Use a drive socket #22. Use a torque wrench. Tighten it to 65 Nm torque.

Replacement: coil springs – OPEL ZAFIRA B Van. Tip:
Check to make sure the spring is positioned correctly. Avoid its misalignment.
Step 37

Decompress the spring.
Step 38

Remove the assembled shock strut.
Step 39

Treat the shock strut rod. Use copper grease.

Step 40

Install the shock strut into the wheel arch.

AUTODOC recommends:
To avoid injury, hold the shock strut firmly when mounting it.
Step 41

Treat the shock strut mounting seat on the steering knuckle. Use a wire brush. Use WD-40 spray.
Step 42

Fix the shock absorber strut on the steering knuckle.
Step 43

Install the fastening bolts.
Step 44

Raise the hydraulic transmission jack by 10-15 cm.
Step 45

Install the retainer of the shock strut upper mount. Use water pump pliers.
Step 46

Connect the fastener of the ABS sensor cable to the shock absorber strut.
Step 47

Fasten the brake hose on the strut. Use a rubber mallet.
Step 48

Tighten the lower fasteners connecting the shock strut to the steering knuckle. Use a combination spanner #18. Use a drive socket #18. Use a torque wrench. Tighten it to 105 Nm torque.
Step 49

Ιnstall the transverse stabilizer link.
Step 50

Tighten the fastener connecting the stabilizer link to the shock strut. Use a drive socket #19. Use a combination spanner #19. Use a torque wrench. Tighten it to 55 Nm torque.
Step 51

Remove the support from under the steering knuckle.

AUTODOC recommends:
Replacement: coil springs – OPEL ZAFIRA B Van. Lower the transmission jack smoothly, without jerks, to avoid damaging components and mechanisms.
Step 52

Treat the shock strut fasteners. Treat all joints of the arm. Use copper grease.
Step 53

Treat the surface where the brake disc contacts the wheel rim. Use copper grease.
Step 54

Clean the brake disk surface. Use a brake cleaner.

AUTODOC recommends:
Replacement: coil springs – OPEL ZAFIRA B Van. After applying the spray, wait a few minutes.
Step 55

Install the wheel.

AUTODOC recommends:
Warning! To avoid injury, hold the wheel while screwing in the fastening bolts on the car. OPEL ZAFIRA B Van
Step 56

Screw in the wheel bolts. Use wheel impact socket #17.
Step 57

Lower the car and working in a cross order, tighten the wheel bolts. Use a torque wrench. Tighten it to 110 Nm torque.
Step 58

Install and secure the cowl grille.
Step 59

Install the shock strut mount cap.

Step 60

Install the cowl grille seal.
Step 61

Remove the jacks and chocks.

Step 62

Remove the fender protection cover.

Step 63

Close the hood.

Was this manual helpful?

Please rate this manual on a scale from 1 to 5. If you have any questions, feel free to ask us.

Need New Tyres?

Find out which tyre and wheel sizes are compatible with the OPEL Zafira B Van (A05) model

OPEL ZAFIRA B Van tyre size

How to change rear brake pads on OPEL Zafira B Van (A05) – replacement guide

Free download PDF
2.32 MB
How to change front windshield wipers on OPEL Zafira B Van (A05) – replacement guide

Free download PDF
1.33 MB
How to change rear windshield wipers on OPEL Zafira B Van (A05) – replacement guide

Free download PDF
1.33 MB
How to change front anti roll bar links on OPEL Zafira B Van (A05) – replacement guide

Free download PDF
2.07 MB
How to change engine oil and filter on OPEL ZAFIRA B Van – replacement guide

Free download PDF
1.62 MB
How to change headlight bulb on OPEL Zafira B Van (A05) – replacement guide

Free download PDF
2.2 MB

How to change rear coil springs on Opel Zafira B A05 – replacement guide

Free download PDF
1.49 MB
How to change front coil springs on Opel Zafira B A05 – replacement guide

Free download PDF
3.02 MB
How to change front coil springs on Opel Zafira F75 – replacement guide

Free download PDF
3.76 MB
How to change rear coil springs on Opel Zafira F75 – replacement guide

Free download PDF
1.71 MB
How to change coil springs on a car – replacement tutorial

Universal

Free download PDF
1.91 MB
How to change front coil springs on Opel Corsa D – replacement guide

Free download PDF
3.86 MB

Unlock your car maintenance assistant!

Track expenses, manage logs, schedule replacements, and more.

How to replace a timing chain yourself

19K views

Published on: 12/12/2024
#DIY Wheel Rim Restoration: Revive Scratches and Chips Easily!

7K views

Published on: 18/07/2024
TOP 8 mistakes car owners make | AUTODOC tips

14K views

Published on: 09/12/2021
Checking the starter without removing it | AUTODOC tips

27K views

Published on: 01/12/2020