How to carry out replacement: Brake Pads 1.4 i 16V (F35) Opel Corsa B Caravan
Disclaimer
Change Opel Corsa B Caravan 1.4 i 16V (F35) Brake Pads yourself – manuals and video tutorials

How to change front brake pads on OPEL Corsa B Caravan (S93) – replacement guide

downloads: 0
Views: 67
Download your free tutorial and fix OPEL Corsa B Caravan (S93) 1.2 i 16V (F35) problems yourself Download for free 1.46 MB Brake Pads for Opel Corsa B Caravan Shop now
Leave a comment Open in a new tab
When to replace the Brake Pads on your OPEL CORSA
Recommended replacement interval for the part category Brake pad set : 30000 km
Important!
This replacement procedure can be used for:
OPEL Corsa B Caravan (S93) 1.7 D (F35), OPEL Corsa B Caravan (S93) 1.4 i 16V (F35) … View more

The steps may slightly vary depending on the car design.

This video shows the replacement procedure of a similar car part on another vehicle

All the parts you need to replace – Brake Pads for Corsa B Caravan (S93) and other OPEL models
Alternative products
How to change Brake pad set on Opel Corsa B Caravan 1.4 i 16V (F35) – step-by-step instructions for straightforward car repair Brake pad set
Tools
Replacement: brake pads – OPEL CORSA B Estate (F35). List of the tools you'll need:
Wire brush
Nylon cleaning brush
Brake cleaner
Anti-squeal paste
High-temperature ceramic grease
Torque wrench
HEX bit No.H7
Wheel impact socket #17
Ratchet wrench
Brake caliper wind back tool
Crow bar
Wheel chock
Buy tools
Replacement: brake pads – OPEL CORSA B Estate (F35). AUTODOC experts recommend:
  • Perform the replacement of brake pads in complete set for each axis. This provides effective braking.
  • The replacement procedure is identical for all brake pads on the same axle.
  • Please note: all work on the car – OPEL CORSA B Estate (F35) – should be done with the engine switched off.
Carry out replacement in the following order:
  1. Step 1
    Open the bonnet. Unscrew the brake fluid reservoir cap.
    Step 2
    Secure the wheels with chocks.
    Step 3
    How to change Brake Pads on Opel Corsa B Caravan 1999 - free PDF and video manuals
    Loosen the wheel mounting bolts. Use wheel impact socket #17.
  2. Step 4
    Raise the car.
    AUTODOC recommends:
    If you are using a jack, make sure it rests on a flat surface without any unevenness.Be sure to additionally secure the car with jack stands.
    Step 5
    How to replace OPEL Corsa B Caravan (S93) 1.4 i 16V (F35) 2000 Brake Pads - step-by-step manuals and video guides
    Unscrew the wheel bolts.
    AUTODOC recommends:
    Warning! To avoid injury, hold the wheel while unscrewing the fastening bolts. OPEL CORSA B Estate (F35)
  3. Step 6
    Opel Corsa B Caravan 1.7 D (F35) 2001 Brake Pads replacement: free workshop manuals
    Remove the wheel.
  4. Step 7
    Changing Brake Pads on OPEL Corsa B Caravan (S93) 1.2 i 16V (F35) 2002 by yourself
    Detach the brake caliper retaining spring. Use a crowbar.
  5. Step 8
    How to remove OPEL CORSA 1.4 i 16V (F35) 1999 Brake Pads - online easy-to-follow instructions
    Spread the brake pads. Use a crowbar.
  6. Step 9
    How to replace Brake Pads on OPEL Corsa B Caravan (S93) 2000: download PDF manuals and video instructions
    Remove the dust boot caps of the brake caliper guide pins. Use a crowbar.
  7. Step 10
    How hard is it to do yourself: Brake Pads replacement on Opel Corsa B Caravan 1.5 TD (F35) 2001 - download illustrated guide
    Unscrew the brake caliper fastening. Use HEX No.H7. Use a ratchet wrench.
  8. Step 11
    Need to know how to renew Brake Pads on OPEL CORSA 2002? This free workshop manual will help you to do it yourself
    Remove the brake caliper.
    AUTODOC recommends:
    Tie the caliper to the suspension or to the body with a wire without disconnecting from the brake hose to prevent depressurization of the brake system.Make sure that the brake caliper is not hanging on the brake hose.Don't press the brake pedal after the brake caliper has been removed. As a result, the piston can fall out from the brake cylinder, and brake fluid leakage and depressurization of the system may occur.
  9. Step 12
    Changing of Brake Pads on Opel Corsa B Caravan 1999 won't be an issue if you follow this illustrated step-by-step guide
    Remove the brake pads.
    AUTODOC recommends:
    Measure the brake disc thickness. Upon reaching the wear limit the part must be replaced.
  10. Step 13
    OPEL CORSA 1.4 i 16V (F35) Brake Pads replacement: online guides and video tutorials
    Treat the brake caliper piston. Use a nylon cleaning brush. Use a brake cleaner.
    AUTODOC recommends:
    Replacement: brake pads – OPEL CORSA B Estate (F35). After applying the spray, wait a few minutes.
  11. Step 14
    Replacing Brake Pads on Opel Corsa B Caravan 2001 1.4 i 16V (F35) by yourself
    Press in the brake caliper piston. Use brake caliper wind back tool.
    Replacement: brake pads – OPEL CORSA B Estate (F35). Tip from AUTODOC:
    Check the brake caliper bracket, brake caliper guide pins and boots. Clean them. Replace, if necessary.
  12. Step 15
    Corsa B Caravan (S93) 1.4 i 16V (F35) 2002 Brake Pads DIY replacement workshop manual
    Clean the brake caliper bracket from dirt and dust. Use a wire brush. Use a brake cleaner.
    AUTODOC recommends:
    After applying the spray, wait a few minutes.
  13. Step 16
    How to change Brake Pads on OPEL Corsa B Caravan (S93) 1999 - tips and tricks
    Treat the brake pads in the area where their surface comes into contact with the brake caliper bracket. Use anti-squeal paste.
    Replacement: brake pads – OPEL CORSA B Estate (F35). Tip:
    Make sure the disc surface is clean before installing the pads.
  14. Step 17
    Step-by-step recommendations for DIY replacement Opel Corsa B Caravan 2000 1.4 i 16V (F35) Brake Pads
    Install new brake pads.
    Replacement: brake pads – OPEL CORSA B Estate (F35). AUTODOC recommends:
    Make sure the pads are installed with linings facing the disc.
Was this manual helpful?
Please rate this manual on a scale from 1 to 5. If you have any questions, feel free to ask us.
Users voted – 0
Need New Tyres?

Find out which tyre and wheel sizes are compatible with the OPEL Corsa B Caravan (S93) model

Opel Corsa B Caravan tyre size

Popular maintenance tutorials for Opel Corsa B Caravan

More manuals for Opel Corsa B Caravan

Complete guides for changing the Brake pad set on different OPEL CORSA models

Unlock your car maintenance assistant!

Track expenses, manage logs, schedule replacements, and more.

DIY OPEL Corsa B Caravan (S93) Brake Pads replacement - online guide
Tips & tricks for your OPEL Corsa B Caravan (S93)
View more
  • How to change Brake pad set on OPEL Corsa B Caravan (S93) 1.5 TD (F35) - replacement tricks
    Deep interior cleaning | Car transformation by detailing
    7K views
    Published on: 05/09/2024
  • Changing Disc pads Opel Corsa B Caravan 1.4 i 16V (F35) - Replacement Tips
    Transform Your Old Engine Valve Cover: Quick Polishing Tips for a Shiny Finish | AUTODOC Tips
    11K views
    Published on: 30/11/2023
  • Maintenance Hacks - OPEL Corsa B Caravan (S93) 1.7 D (F35) Brake pad kit replacement guide
    Understanding Car Tools: The Key Differences You Need to Know | AUTODOC tips
    8K views
    Published on: 16/12/2021
  • Replace Disc brake pads on Opel Corsa B Caravan - free video tips
    How to remove scratches from car plastic | AUTODOC tips
    187K views
    Published on: 15/12/2022

Most commonly replaced car parts on OPEL CORSA

Professional manuals for the most common OPEL models

ОЕ number
Autodoc CLUB App icon
Time to replace parts? Get even better deals in our Shop app.
OPEL Corsa B Caravan (S93) Brake Pads replace by yourself - Scan QR-code and download AUTODOC CLUB app
SCAN ME