Recommended replacement interval for the part category Brake pad set : 30000 km

Important!

This replacement procedure can be used for:
DACIA DOKKER Express 1.6, DACIA DOKKER Express 1.5 dCi 75 / Blue dCi 75 (FEJW, FEAH), DACIA DOKKER Express 1.5 dCi (FEAJ), DACIA DOKKER Express 1.5 dCi (FEMW), DACIA DOKKER Express 1.5 dCi … View more

The steps may slightly vary depending on the car design.

This video shows the replacement procedure of a similar car part on another vehicle

All the parts you need to replace – Brake Pads for DOKKER Express and other DACIA models

Brake pad set

        Brake pad set for Dokker Express Petrol (83 hp)
      
        Brake pad set for Dokker Express Diesel (75 hp)
      
        Brake pad set for Dokker Express Diesel (90 hp)
      
        Brake pad set for Dokker Express Diesel (85 hp)
      
        Brake pad set for Dokker Express Diesel (84 hp)

Replacement: brake pads – DACIA DOKKER Express. Tools you'll need:

                        Wire brush
                      
                        Nylon cleaning brush
                      
                        WD-40 spray
                      
                        Brake cleaner 
                      
                        Anti-squeal paste
                      
                        Copper grease 
                      
                        Torque wrench
                      
                        Combination spanner #13
                      
                        Combination spanner #19
                      
                        Drive socket # 13 
                      
                        Wheel impact socket #17
                      
                        Brake caliper wind back tool
                      
                        Crow bar
                      
                        Fender cover
                      
                        Wheel chock

Buy tools

Replacement: brake pads – DACIA DOKKER Express. AUTODOC recommends:

Perform the replacement of brake pads in complete set for each axis. This provides effective braking.
The replacement procedure is identical for all brake pads on the same axle.
Please note: all work on the car – DACIA DOKKER Express – should be done with the engine switched off.

Carry out replacement in the following order:

Step 1

Open the bonnet.

Step 2

Use a fender protection cover to prevent damaging paintwork and plastic parts of the car.

Step 3

Unscrew the brake fluid reservoir cap.
Step 4

Secure the wheels with chocks.
Step 5

Loosen the wheel mounting bolts. Use wheel impact socket #17.
Step 6

Raise the front of the car and secure on supports.

Step 7

Unscrew the wheel bolts.

Replacement: brake pads – DACIA DOKKER Express. Tip:
To avoid injury, hold up the wheel when unscrewing the bolts.
Step 8

Remove the wheel.
Step 9

Clean the brake caliper fasteners. Use a wire brush. Use WD-40 spray.
Step 10

Unscrew the brake caliper fastening. Use a combination spanner #13. Use a combination spanner #19.
Step 11

Spread the brake pads. Use a crowbar.
Step 12

Remove the brake caliper.

Replacement: brake pads – DACIA DOKKER Express. Tip from AUTODOC experts:
Tie the caliper to the suspension or to the body with a wire without disconnecting from the brake hose to prevent depressurization of the brake system.Make sure that the brake caliper is not hanging on the brake hose.Don't press the brake pedal after the brake caliper has been removed. As a result, the piston can fall out from the brake cylinder, and brake fluid leakage and depressurization of the system may occur. Check the brake caliper bracket, brake caliper guide pins and boots. Clean them. Replace, if necessary.
Step 13

Remove the brake pads.

Replacement: brake pads – DACIA DOKKER Express. AUTODOC recommends:
Measure the brake disc thickness. Upon reaching the wear limit the part must be replaced.
Step 14

Clean the brake caliper bracket from dirt and dust. Use a wire brush. Use a brake cleaner.

AUTODOC recommends:
Replacement: brake pads – DACIA DOKKER Express. After applying the spray, wait a few minutes.
Step 15

Treat the brake caliper piston. Use a nylon cleaning brush. Use a brake cleaner.

Replacement: brake pads – DACIA DOKKER Express. Tip from AUTODOC experts:
After applying the spray, wait a few minutes.
Step 16

Press in the brake caliper piston. Use brake caliper wind back tool.
Step 17

Treat the brake pads in the area where their surface comes into contact with the brake caliper bracket. Use anti-squeal paste.

Replacement: brake pads – DACIA DOKKER Express. Tip from AUTODOC:
Make sure the disc surface is clean before installing the pads.
Step 18

Install new brake pads.

AUTODOC recommends:
Make sure the pads are installed with linings facing the disc.
Step 19

Install the brake caliper and fix it. Use a combination spanner #13. Use a combination spanner #19. Use a drive socket #13. Use a torque wrench. Tighten it to 32 Nm torque.
Step 20

Treat the surface where the brake disc contacts the wheel rim. Use copper grease.
Step 21

Clean the brake disk surface. Use a brake cleaner.

Replacement: brake pads – DACIA DOKKER Express. AUTODOC recommends:
After applying the spray, wait a few minutes.
Step 22

Install the wheel.

AUTODOC recommends:
Warning! To avoid injury, hold the wheel while screwing in the fastening bolts on the car. DACIA DOKKER Express
Step 23

Screw in the wheel bolts. Use wheel impact socket #17.
Step 24

Lower the car and working in a cross order, tighten the wheel bolts. Use wheel impact socket #17. Use a torque wrench. Tighten it to 105 Nm torque.

Step 25

Remove the jacks and chocks.

Replacement: brake pads – DACIA DOKKER Express. Tip from AUTODOC experts:
Check the brake fluid level in the expansion tank and refill if necessary.
Step 26

Tighten the brake fluid reservoir cap.

AUTODOC recommends:
DACIA DOKKER Express – Without starting the engine, press the brake pedal several times until it feels firm.
Step 27

Remove the fender protection cover.

Step 28

Close the hood.

Replacement: brake pads – DACIA DOKKER Express. Professionals recommend:
Slow down smoothly for first 150-200 km after the brake pads replacement. Avoid unneccessary and sharp braking to a stop.

Was this manual helpful?

Please rate this manual on a scale from 1 to 5. If you have any questions, feel free to ask us.

Searching for the right tyres?

Find out which tyre and wheel sizes are compatible with the DACIA Dokker Express model.

Browse tyres

How to change front brake discs on DACIA DOKKER Express – replacement guide

Free download PDF
1.78 MB
How to change serpentine belt on DACIA DOKKER Express – replacement guide

Free download PDF
1.62 MB
How to change spark plugs on DACIA DOKKER Express – replacement guide

Free download PDF
880.64 KB
How to change engine oil and filter on DACIA DOKKER Express – replacement guide

Free download PDF
1.17 MB
How to change fuel filter on DACIA DOKKER Express – replacement guide

Free download PDF
849.92 KB
How to change glow plugs on DACIA DOKKER Express – replacement guide

Free download PDF
1.55 MB

How to change front brake pads on DACIA Dokker Estate (KE_) – replacement guide

Free download PDF
1.48 MB
How to change brake pads on a car – replacement tutorial

Universal

Free download PDF
2.84 MB
How to change front brake pads on DACIA Duster II – replacement guide

Free download PDF
1.49 MB
How to change front brake pads on DACIA DUSTER – replacement guide

Free download PDF
1.49 MB
How to change front brake pads on DACIA Lodgy (JS_) – replacement guide

Free download PDF
1.49 MB
How to change front brake pads on DACIA LOGAN MCV (KS_) – replacement guide

Free download PDF
1.48 MB

Your profile is your personal assistant.

It can track car expenses, keep a car log and replacement schedule, and save favourite materials, notes and documents

Install the AUTODOC CLUB app!

Your personal car expenses manager, maintenance tips, reminders about upcoming appointments and service intervals, DIY repair instructions – all this on your phone.

Scan

To download the app:

- scan the QR code
- download from App Store
- download from Google Play

How to polish your car | AUTODOC tips

5K views

Published on: 31/03/2022
How do EGR valves work? | AUTODOC

18K views

Published on: 18/07/2020
The most common problems when buying a used car | AUTODOC

4K views

Published on: 10/11/2022
DIY jack restoration | AUTODOC tips

12K views

Published on: 22/09/2022