Recommended replacement interval for the part category Brake pad set : 30000 km

Important!

This replacement procedure can be used for:
BMW X1 (E84) xDrive 28 i, BMW X1 (E84) sDrive 18 d, BMW X1 (E84) xDrive 18 d, BMW X1 (E84) xDrive 20 d, BMW X1 (E84) sDrive 20 d, BMW X1 (E84) xDrive 23 d, BMW X1 (E84) xDrive 20 d, BMW X1 (E84) sDrive 20 d, BMW X1 (E84) sDrive 18 d, BMW X1 (E84) xDrive 18 d, BMW X1 (E84) xDrive 25 i … View more

The steps may slightly vary depending on the car design.

This video shows the replacement procedure of a similar car part on another vehicle

All the parts you need to replace – Brake Pads for X1 (E84) and other BMW models

Brake pad set

        Brake pad set for X1 (E84) Petrol (245 hp)
      
        Brake pad set for X1 (E84) Diesel (143 hp)
      
        Brake pad set for X1 (E84) Diesel (143 hp)
      
        Brake pad set for X1 (E84) Diesel (177 hp)
      
        Brake pad set for X1 (E84) Diesel (177 hp)
      
        Brake pad set for X1 (E84) Diesel (204 hp)
      
        Brake pad set for X1 (E84) Diesel (163 hp)
      
        Brake pad set for X1 (E84) Diesel (163 hp)
      
        Brake pad set for X1 (E84) Diesel (136 hp)

Replacement: brake pads – BMW X1 (E84). Tools you might need:

                        Wire brush
                      
                        WD-40 spray
                      
                        Brake cleaner 
                      
                        Anti-squeal paste
                      
                        Copper grease 
                      
                        HEX bit no.H7.
                      
                        Wheel impact socket #17
                      
                        Ratchet wrench
                      
                        Torque wrench
                      
                        Brake caliper wind back tool
                      
                        Crow bar
                      
                        Fender cover
                      
                        Wheel chock

Buy tools

Replacement: brake pads – BMW X1 (E84). AUTODOC experts recommend:

Perform the replacement of brake pads in complete set for each axis. This provides effective braking.
The replacement procedure is identical for all brake pads on the same axle.
All work should be done with the engine stopped.

Replacement: brake pads – BMW X1 (E84). Use the following procedure:

Step 1

Open the hood.

Step 2

Use a fender protection cover to prevent damaging paintwork and plastic parts of the car.

Step 3

Remove the wiper arm cover.
Step 4

Unscrew the brake fluid reservoir cap.
Step 5

Secure the wheels with chocks.
Step 6

Loosen the wheel mounting bolts. Use wheel impact socket #17.
Step 7

Raise the front of the car and secure on supports.

Step 8

Unscrew the wheel bolts.

Replacement: brake pads – BMW X1 (E84). Tip:
To avoid injury, hold up the wheel when unscrewing the bolts.
Step 9

Remove the wheel.
Step 10

Spread the brake pads. Use a crowbar.
Step 11

Remove the dust boot caps of the brake caliper guide pins. Use a crowbar.
Step 12

Unscrew the brake caliper fastening. Use HEX No.H7. Use a ratchet wrench.
Step 13

Detach the brake caliper retaining spring. Use a crowbar.
Step 14

Remove the brake caliper.

Replacement: brake pads – BMW X1 (E84). Tip from AUTODOC experts:
Tie the caliper to the suspension or to the body with a wire without disconnecting from the brake hose to prevent depressurization of the brake system.Make sure that the brake caliper is not hanging on the brake hose.Don't press the brake pedal after the brake caliper has been removed. As a result, the piston can fall out from the brake cylinder, and brake fluid leakage and depressurization of the system may occur. Check the brake caliper bracket, brake caliper guide pins and boots. Clean them. Replace, if necessary.
Step 15

Remove the brake pads.

AUTODOC recommends:
Measure the brake disc thickness. Upon reaching the wear limit the part must be replaced.
Step 16

Clean the brake caliper bracket from dirt and dust. Use a wire brush. Use a brake cleaner.

AUTODOC recommends:
Replacement: brake pads – BMW X1 (E84). After applying the spray, wait a few minutes.
Step 17

Treat the brake caliper piston. Use a brake cleaner.

Replacement: brake pads – BMW X1 (E84). Tip:
After applying the spray, wait a few minutes.
Step 18

Press in the brake caliper piston. Use brake caliper wind back tool.
Step 19

Treat the brake pads in the area where their surface comes into contact with the brake caliper bracket. Use anti-squeal paste.

Replacement: brake pads – BMW X1 (E84). Tip from AUTODOC:
Make sure the disc surface is clean before installing the pads.
Step 20

Install new brake pads.

Replacement: brake pads – BMW X1 (E84). AUTODOC experts recommend:
Make sure the pads are installed with linings facing the disc.
Step 21

Install the brake caliper and fix it. Use HEX No.H7. Use a torque wrench. Tighten it to 30 Nm torque.
Step 22

Install the dust boot caps of the brake caliper guide pins.
Step 23

Install the brake caliper retaining spring.
Step 24

Treat the surface where the brake disc contacts the wheel rim. Use copper grease.
Step 25

Clean the brake disk surface. Use a brake cleaner.

AUTODOC recommends:
Replacement: brake pads – BMW X1 (E84). After applying the spray, wait a few minutes.
Step 26

Install the wheel.

Replacement: brake pads – BMW X1 (E84). Professionals recommend:
To avoid injury, hold up the wheel when screwing in the fastening bolts.
Step 27

Screw in the wheel bolts. Use wheel impact socket #17.
Step 28

Lower the car and working in a cross order, tighten the wheel bolts. Use wheel impact socket #17. Use a torque wrench. Tighten it to 120 Nm torque.
Step 29

Remove the jacks and chocks.

AUTODOC recommends:
Important! Replacement: brake pads – BMW X1 (E84). Check the brake fluid level in the reservoir and top up if necessary.
Step 30

Tighten the brake fluid reservoir cap.
Step 31

Install the wiper arm cover.

Step 32

Remove the fender protection cover.

Step 33

Close the hood.

Replacement: brake pads – BMW X1 (E84). AUTODOC experts recommend:
Without starting the engine, press the brake pedal several times until you feel significant resistance.Slow down smoothly for first 150-200 km after the brake pads replacement. Avoid unneccessary and sharp braking to a stop.

Was this manual helpful?

Please rate this manual on a scale from 1 to 5. If you have any questions, feel free to ask us.

Searching for the right tyres?

Find out which tyre and wheel sizes are compatible with the BMW X1 (E84) model.

Browse tyres

How to change front brake discs on BMW X1 (E84) – replacement guide

Free download PDF
2.08 MB
How to change rear brake discs on BMW X1 (E84) – replacement guide

Free download PDF
2.18 MB
How to change rear brake pads on BMW X1 (E84) – replacement guide

Free download PDF
1.53 MB
How to change front wheel bearing on BMW X1 (E84) – replacement guide

Free download PDF
1.66 MB
How to change spark plugs on BMW X1 (E84) – replacement guide

Free download PDF
2.4 MB
How to change front windshield wipers on BMW X1 (E84) – replacement guide

Free download PDF
1.35 MB

How to change rear brake pads on BMW X1 (F48) – replacement guide

Free download PDF
1.91 MB
How to change rear brake pads on BMW X1 (E84) – replacement guide

Free download PDF
1.53 MB
How to change brake pads on a car – replacement tutorial

Universal

Free download PDF
2.84 MB
How to change front brake pads on BMW E90 – replacement guide

Free download PDF
1.7 MB
How to change rear brake pads on BMW E92 – replacement guide

Free download PDF
1.99 MB
How to change rear brake pads on BMW X3 E83 – replacement guide

Free download PDF
1.64 MB

Your profile is your personal assistant.

It can track car expenses, keep a car log and replacement schedule, and save favourite materials, notes and documents

Install the AUTODOC CLUB app!

Your personal car expenses manager, maintenance tips, reminders about upcoming appointments and service intervals, DIY repair instructions – all this on your phone.

Scan

To download the app:

- scan the QR code
- download from App Store
- download from Google Play

TOP 5 mistakes during DIY oil change | AUTODOC tips

34K views

Published on: 17/06/2021
Headlight Restoration | AUTODOC tips

8K views

Published on: 13/01/2021
5 tools that make car repair incredibly simple | AUTODOC tips

36K views

Published on: 25/01/2024
How to choose the right engine oil for your car | AUTODOC

8K views

Published on: 01/07/2020