Recommended replacement interval for the part category Brake disc : 50000 km

Important!

This replacement procedure can be used for:
VOLVO V70 III Box Body / Estate (135) 2.0 D3 DRIVe, VOLVO V70 III Box Body / Estate (135) 2.4 D4 AWD, VOLVO V70 III Box Body / Estate (135) 2.4 D5 … View more

The steps may slightly vary depending on the car design.

This video shows the replacement procedure of a similar car part on another vehicle

All the parts you need to replace – Brake Discs for V70 III Box Body / Estate (135) and other VOLVO models

Alternative products

Brake disc

Replacement: brake discs – VOLVO V70 III Kasten / Kombi (135). Tools you need:

                      Wire brush
                    
                      Nylon cleaning brush
                    
                      WD-40 spray
                    
                      Brake cleaner
                    
                      Anti-squeal paste
                    
                      Ceramic grease
                    
                      Torque wrench
                    
                      Drive socket # 18
                    
                      HEX bit No.H7
                    
                      Torx bit T50
                    
                      Wheel impact socket #19
                    
                      Ratchet wrench
                    
                      Tap wrench
                    
                      Brake caliper wind back tool
                    
                      Hammer
                    
                      Crow bar
                    
                      Impact screwdriver
                    
                      Wheel chock

Buy tools

Replacement: brake discs – VOLVO V70 III Kasten / Kombi (135). AUTODOC experts recommend:

Replace the brake disks on the car VOLVO V70 III Kasten / Kombi (135) in pairs on an axle, regardless of the condition of the components. This will ensure even braking.
The replacement procedure is identical for both brake disks on the same axle.
When changing the brake discs, always replace the brake pads.
All work should be done with the engine stopped.

Replacement: brake discs – VOLVO V70 III Kasten / Kombi (135). Take the following steps:

Step 1

Open the bonnet.

Step 2

Unscrew the brake fluid reservoir cap.
Step 3

Secure the wheels with chocks.

Step 4

Loosen the wheel bolts. Use wheel impact socket #19. Use a tap wrench.
Step 5

Raise the car.

AUTODOC recommends:
If you are using a jack, make sure it rests on a flat surface without any unevenness.Be sure to additionally secure the car with jack stands.
Step 6

Unscrew the wheel bolts.

AUTODOC recommends:
Important! Hold the wheel while unscrewing the fastening bolts. VOLVO V70 III Kasten / Kombi (135)
Step 7

Remove the wheel.
Step 8

Spread the brake pads. Use a crowbar.
Step 9

Detach the brake caliper retaining spring. Use a crowbar.
Step 10

Remove the caps from the brake caliper guide pin boots. Use a crowbar.
Step 11

Unscrew the brake caliper fasteners. Use HEX No.H7. Use a ratchet wrench.
Step 12

Remove the brake caliper.

Replacement: brake discs – VOLVO V70 III Kasten / Kombi (135). Professionals recommend:
Tie the caliper to the suspension or to the body with a wire without disconnecting from the brake hose to prevent depressurization of the brake system.Make sure that the brake caliper is not hanging on the brake hose.Don't press the brake pedal after the brake caliper has been removed. As a result, the piston can fall out from the brake cylinder, and brake fluid leakage and depressurization of the system may occur.
Step 13

Remove the brake pads.
Step 14

Clean the brake caliper bracket fasteners. Use a wire brush. Use WD-40 spray.
Step 15

Unscrew the brake caliper bracket fasteners. Use a drive socket #18. Use a ratchet wrench.
Step 16

Remove the fastening bolts.
Step 17

Remove the brake caliper bracket.
Step 18

Clean the brake disc fastener. Use a wire brush. Use WD-40 spray.
Step 19

Unscrew the brake disc fasteners. Use Torx T50. Use an impact screwdriver. Use a hammer.
Step 20

Remove the fastening bolt.
Step 21

Remove the brake disc.
Step 22

Clean the wheel hub. Use a wire brush.

Step 23

Treat the contacting surface. Use ceramic grease.

Step 24

Install a new brake disc.
Step 25

Install the fastening bolt.
Step 26

Tighten the brake disc fasteners. Use Torx T50. Use a torque wrench. Tighten it to 15 Nm torque.
Step 27

Clean the brake caliper bracket of dirt and dust. Use a wire brush. Use a brake cleaner.
Step 28

Install the brake caliper bracket.
Step 29

Install the fastening bolts.
Step 30

Tighten the brake caliper bracket fasteners. Use a drive socket #18. Use a torque wrench. Tighten it to 150 Nm torque.
Step 31

Treat the brake caliper piston. Use a nylon cleaning brush. Use a brake cleaner.
Step 32

Press in the brake caliper piston. Use brake caliper wind back tool.
Step 33

Treat the brake pads in the area where their surface comes into contact with the brake caliper bracket. Use anti-squeal paste.

AUTODOC recommends:
Make sure the disc surface is clean before installing the pads.
Step 34

Install the brake pads.
Step 35

Install the brake caliper and fasten it.
Step 36

Tighten the brake caliper fasteners. Use HEX No.H7. Use a torque wrench. Tighten it to 28 Nm torque.
Step 37

Install the caps on the brake caliper guide pin boots.
Step 38

Install the brake pad retaining clip.
Step 39

Treat the surface where the brake disc contacts the wheel rim. Use ceramic grease.

Step 40

Clean the brake disk surface. Use a brake cleaner.
Step 41

Install the wheel.

Replacement: brake discs – VOLVO V70 III Kasten / Kombi (135). AUTODOC experts recommend:
To avoid injury, hold up the wheel when screwing in the fastening bolts.
Step 42

Screw in the wheel bolts. Use wheel impact socket #19. Use a ratchet wrench.
Step 43

Lower the car and working in a cross order, tighten the wheel bolts. Use wheel impact socket #19. Use a torque wrench. Tighten it to 140 Nm torque.
Step 44

Remove the jacks and chocks.

AUTODOC recommends:
VOLVO V70 III Kasten / Kombi (135) – Press the brake pedal several times with the engine shut down until you feel the resistance built up.Check the brake fluid level in the expansion tank and top up if necessary.
Step 45

Tighten the brake fluid reservoir cap.

Step 46

Close the bonnet.

Was this manual helpful?

Please rate this manual on a scale from 1 to 5. If you have any questions, feel free to ask us.

Need New Tyres?

Find out which tyre and wheel sizes are compatible with the VOLVO V70 III Box Body / Estate (135) model

VOLVO V70 III Kasten / Kombi (135) tyre size

How to change rear brake pads on VOLVO V70 III Box Body / Estate (135) – replacement guide

Free download PDF
1.38 MB
How to change front wheel bearing on VOLVO V70 III Box Body / Estate (135) – replacement guide

Free download PDF
4.07 MB
How to change front windshield wipers on VOLVO V70 III Box Body / Estate (135) – replacement guide

Free download PDF
604.16 KB
How to change engine oil and filter on VOLVO V70 III Box Body / Estate (135) – replacement guide

Free download PDF
2.29 MB
How to change front suspension strut on VOLVO V70 III Box Body / Estate (135) – replacement guide

Free download PDF
3.78 MB
How to change pollen filter on VOLVO V70 III Box Body / Estate (135) – replacement guide

Free download PDF
1.41 MB

How to change rear brake discs on Volvo V70 SW – replacement guide

Free download PDF
2.16 MB
How to change front brake discs on Volvo V70 SW – replacement guide

Free download PDF
2.25 MB
How to change front brake discs on Volvo V70 BW – replacement guide

Free download PDF
2.36 MB
How to change front brake pads on Volvo V70 BW – replacement guide

Free download PDF
1.72 MB
How to change rear brake discs on Volvo V70 BW – replacement guide

Free download PDF
2.25 MB
How to change rear brake pads on Volvo V70 BW – replacement guide

Free download PDF
1.6 MB

Unlock your car maintenance assistant!

Track expenses, manage logs, schedule replacements, and more.

How to Polish Your Car Yourself and Save Money on Garage Services | AUTODOC tips

6K views

Published on: 31/03/2022
Don’t Replace, Just Polish! Headlight Restoration with AUTODOC

9K views

Published on: 13/01/2021
5 possible reasons why your car heater isn't working

6K views

Published on: 21/11/2024
5 mistakes when replacing consumables

5K views

Published on: 06/02/2025