How to carry out replacement: Brake Discs 1.6 i VAUXHALL Astra Mk3 (F) Cabrio (T92)
Disclaimer
Change VAUXHALL Astra Mk3 (F) Cabrio (T92) 2.0 i Brake Discs yourself – manuals and video tutorials

How to change front brake discs on VAUXHALL Astra Mk3 (F) Convertible (T92) – replacement guide

downloads: 1
Views: 14
Download your free tutorial and fix VAUXHALL Astra Mk3 (F) Convertible (T92) 1.6 i problems yourself Download for free 1.79 MB Brake Discs for VAUXHALL Astra Mk3 (F) Cabrio (T92) Shop now
Leave a comment Open in a new tab
When to replace the Brake Discs on your VAUXHALL ASTRA
Recommended replacement interval for the part category Brake disc : 50000 km
Important!
This replacement procedure can be used for:
VAUXHALL Astra Mk3 (F) Convertible (T92) 1.6 i, VAUXHALL Astra Mk3 (F) Convertible (T92) 1.8 16V … View more

The steps may slightly vary depending on the car design.

This video shows the replacement procedure of a similar car part on another vehicle

All the parts you need to replace – Brake Discs for Astra Mk3 (F) Convertible (T92) and other VAUXHALL models
How to change Brake disc on VAUXHALL Astra Mk3 (F) Cabrio (T92) 1.6 i – step-by-step instructions for straightforward car repair Brake disc
How to change Brake disc on Astra Mk3 (F) Convertible (T92) – tips for proper car maintenance
Brake disc for Astra Mk3 (F) Convertible (T92) Petrol (75 hp)
Simple DIY car repair steps – Replacing Brake disc on Astra Mk3 (F) Convertible (T92)
Brake disc for Astra Mk3 (F) Convertible (T92) Petrol (116 hp)
Tools
Replacement: brake discs – VAUXHALL Astra Mk3 (F) Cabrio (T92). Tools you might need:
Wire brush
WD-40 spray
Brake cleaner
Copper grease
Anti-squeal paste
HEX bit No.H7.
Torx bit T30
Wheel impact socket #17
Brake caliper wind back tool
Flat screwdriver
Ratchet wrench
Torque wrench
Rubber mallet
Crow bar
Wheel chock
Buy tools
Replacement: brake discs – VAUXHALL Astra Mk3 (F) Cabrio (T92). AUTODOC recommends:
  • Replace the brake disks on the car VAUXHALL Astra Mk3 (F) Cabrio (T92) in complete set for each axis. Regardless of the state of components. This will ensure even braking.
  • The replacement procedure is identical for both brake disks on the same axle.
  • When changing the brake discs, always replace the brake pads.
  • Please note: all work on the car – VAUXHALL Astra Mk3 (F) Cabrio (T92) – should be done with the engine switched off.
Carry out replacement in the following order:
  1. Step 1
    Open the bonnet. Unscrew the brake fluid reservoir cap.
    Step 2
    How to change Brake Discs on VAUXHALL Astra Mk3 (F) Cabrio (T92) 1993 - free PDF and video manuals
    Secure the wheels with chocks.
  2. Step 3
    How to replace VAUXHALL Astra Mk3 (F) Convertible (T92) 1.6 i 1994 Brake Discs - step-by-step manuals and video guides
    Loosen the wheel mounting bolts. Use wheel impact socket #17.
  3. Step 4
    Raise the front of the car and secure on supports.
    Step 5
    VAUXHALL Astra Mk3 (F) Cabrio (T92) 2.0 i 1995 Brake Discs replacement: free workshop manuals
    Unscrew the wheel bolts.
    Replacement: brake discs – VAUXHALL Astra Mk3 (F) Cabrio (T92). Tip:
    To avoid injury, hold up the wheel when unscrewing the bolts.
  4. Step 6
    Changing Brake Discs on VAUXHALL Astra Mk3 (F) Convertible (T92) 2.0 i 16V 1996 by yourself
    Remove the wheel.
  5. Step 7
    How to remove VAUXHALL ASTRA 1.8 1997 Brake Discs - online easy-to-follow instructions
    Spread the brake pads. Use a crowbar.
  6. Step 8
    How to replace Brake Discs on VAUXHALL Astra Mk3 (F) Convertible (T92) 1998: download PDF manuals and video instructions
    Remove the dust boot caps of the brake caliper guide pins. Use a flat screwdriver.
  7. Step 9
    How hard is it to do yourself: Brake Discs replacement on VAUXHALL Astra Mk3 (F) Cabrio (T92) 1.8 i (F08) 1999 - download illustrated guide
    Unscrew the brake caliper fastening. Use HEX No.H7. Use a ratchet wrench.
  8. Step 10
    Need to know how to renew Brake Discs on VAUXHALL ASTRA 2000? This free workshop manual will help you to do it yourself
    Remove the fastener attaching the brake hose to the shock strut. Use a crowbar.
  9. Step 11
    Changing of Brake Discs on VAUXHALL Astra Mk3 (F) Cabrio (T92) 2001 won't be an issue if you follow this illustrated step-by-step guide
    Pull aside the brake caliper retaining spring. Use a crowbar.
  10. Step 12
    VAUXHALL ASTRA 2.0 i Brake Discs replacement: online guides and video tutorials
    Remove the brake caliper.
    Replacement: brake discs – VAUXHALL Astra Mk3 (F) Cabrio (T92). AUTODOC experts recommend:
    Tie the caliper to the suspension or to the body with a wire without disconnecting from the brake hose to prevent depressurization of the brake system.Make sure that the brake caliper is not hanging on the brake hose.Don't press the brake pedal after the brake caliper has been removed. As a result, the piston can fall out from the brake cylinder, and brake fluid leakage and depressurization of the system may occur.
  11. Step 13
    Replacing Brake Discs on VAUXHALL Astra Mk3 (F) Cabrio (T92) 1994 1.6 i by yourself
    Clean the brake disc fasteners. Use a wire brush. Use WD-40 spray.
  12. Step 14
    Astra Mk3 (F) Convertible (T92) 1.8 1995 Brake Discs DIY replacement workshop manual
    Unscrew the brake disc fastening. Use Torx T30. Use a ratchet wrench.
  13. Step 15
    How to change Brake Discs on VAUXHALL Astra Mk3 (F) Convertible (T92) 1996 - tips and tricks
    Remove the brake disc.
    Replacement: brake discs – VAUXHALL Astra Mk3 (F) Cabrio (T92). Tip from AUTODOC:
    If necessary, use a rubber mallet.
  14. Step 16
    Step-by-step recommendations for DIY replacement VAUXHALL Astra Mk3 (F) Cabrio (T92) 1997 1.8 Brake Discs
    Clean the hub. Use a wire brush. Treat the contacting surface. Use copper grease.
  15. Step 17
    DIY replacement of Brake Discs on VAUXHALL Astra Mk3 (F) Convertible (T92) 1.8 16V 1998 is not an issue anymore with our step-by-step tutorial
    Install the brake disc.
  16. Step 18
    How to change Brake Discs on VAUXHALL Astra Mk3 (F) Cabrio (T92) 1993 - free PDF and video manuals
    Tighten the brake disc fastening. Use Torx T30. Use a torque wrench. Tighten it to 7 Nm torque.
  17. Step 19
    How to replace VAUXHALL Astra Mk3 (F) Convertible (T92) 1.6 i 1994 Brake Discs - step-by-step manuals and video guides
    Press in the brake caliper piston. Use brake caliper wind back tool.
  18. Step 20
    VAUXHALL Astra Mk3 (F) Cabrio (T92) 2.0 i 1995 Brake Discs replacement: free workshop manuals
    Clean the brake caliper bracket from dirt and dust. Use a wire brush.
Was this manual helpful?
Please rate this manual on a scale from 1 to 5. If you have any questions, feel free to ask us.
Users voted – 0
Searching for the right tyres?

Find out which tyre and wheel sizes are compatible with the VAUXHALL Astra Mk3 (F) Convertible (T92) model.

VAUXHALL Astra Mk3 (F) Cabrio (T92) tyre size

Popular maintenance tutorials for VAUXHALL Astra Mk3 (F) Cabrio (T92)

More manuals for VAUXHALL Astra Mk3 (F) Cabrio (T92)

Complete guides for changing the Brake rotors on different VAUXHALL ASTRA models

Your profile is your personal assistant.

It can track car expenses, keep a car log and replacement schedule, and save favourite materials, notes and documents

Install the AUTODOC CLUB app!
Your personal car expenses manager, maintenance tips, reminders about upcoming appointments and service intervals, DIY repair instructions – all this on your phone.
VAUXHALL Astra Mk3 (F) Convertible (T92) Brake Discs replace by yourself - Scan QR-code and download AUTODOC CLUB app
Scan

To download the app:

  • - scan the QR code
  • - download from App Store
  • - download from Google Play
DIY VAUXHALL Astra Mk3 (F) Convertible (T92) Brake Discs replacement - online guide
Tips & tricks for your VAUXHALL Astra Mk3 (F) Convertible (T92)
View more
  • How to change Brake rotors on VAUXHALL Astra Mk3 (F) Convertible (T92) 1.8 16V - replacement tricks
    DIY starter repair | AUTODOC tips
    41K views
    Published on: 31/08/2023
  • Changing Brake disc VAUXHALL Astra Mk3 (F) Cabrio (T92) 1.6 i - Replacement Tips
    5 most common causes of oil leaks | AUTODOC tips
    16K views
    Published on: 30/03/2023
  • Maintenance Hacks - VAUXHALL Astra Mk3 (F) Convertible (T92) 2.0 i Brake disc kit replacement guide
    5 mistakes made when washing the engine | AUTODOC tips
    29K views
    Published on: 22/04/2021
  • Replace Disc brake set on VAUXHALL Astra Mk3 (F) Cabrio (T92) - free video tips
    DIY jack restoration | AUTODOC tips
    12K views
    Published on: 22/09/2022

Most commonly replaced car parts on VAUXHALL ASTRA

Professional manuals for the most common VAUXHALL models