How to carry out replacement: Brake Discs 1.6 16V VAUXHALL ASTRA Mk IV (G) Saloon
Disclaimer
Change VAUXHALL ASTRA Mk IV (G) Saloon 2.0 DI Brake Discs yourself – manuals and video tutorials

How to change front brake discs on VAUXHALL Astra Mk IV (G) Saloon (T98) – replacement guide

downloads: 1
Views: 15
Download your free tutorial and fix VAUXHALL Astra Mk IV (G) Saloon (T98) 1.7 TD problems yourself Download for free 1.95 MB Brake Discs for VAUXHALL ASTRA Mk IV (G) Saloon Shop now
Leave a comment Open in a new tab
When to replace the Brake Discs on your VAUXHALL ASTRA
Recommended replacement interval for the part category Brake disc : 50000 km
Important!
This replacement procedure can be used for:
VAUXHALL Astra Mk IV (G) Saloon (T98) 1.4 16V, VAUXHALL Astra Mk IV (G) Saloon (T98) 1.8 16V, VAUXHALL Astra Mk IV (G) Saloon (T98) 2.0 16V, VAUXHALL Astra Mk IV (G) Saloon (T98) 2.0 DI, VAUXHALL Astra Mk IV (G) Saloon (T98) 2.0 DTI 16V, VAUXHALL Astra Mk IV (G) Saloon (T98) 1.8 16V, VAUXHALL Astra Mk IV (G) Saloon (T98) 1.8 16V Dualfuel … View more

The steps may slightly vary depending on the car design.

This video shows the replacement procedure of a similar car part on another vehicle

All the parts you need to replace – Brake Discs for Astra Mk IV (G) Saloon (T98) and other VAUXHALL models
Alternative products
How to change Brake disc on VAUXHALL ASTRA Mk IV (G) Saloon 1.6 16V – step-by-step instructions for straightforward car repair Brake disc
Tools
Replacement: brake discs – VAUXHALL ASTRA Mk IV (G) Saloon. List of the tools you'll need:
Wire brush
Nylon cleaning brush
WD-40 spray
Brake cleaner
Copper grease
Drive socket # 18
HEX bit No.H5.
HEX bit No.H7.
Wheel impact socket #17
Ratchet wrench
Torque wrench
Brake caliper wind back tool
Flat Screwdriver
Crow bar
Pliers
Wheel chock
Buy tools
Replacement: brake discs – VAUXHALL ASTRA Mk IV (G) Saloon. AUTODOC recommends:
  • Replace the brake disks on the car VAUXHALL ASTRA Mk IV (G) Saloon in complete set for each axis. Regardless of the state of components. This will ensure even braking.
  • The replacement procedure is identical for both brake disks on the same axle.
  • When changing the brake discs, always replace the brake pads.
  • All work should be done with the engine stopped.
Replacement: brake discs – VAUXHALL ASTRA Mk IV (G) Saloon. Use the following procedure:
  1. Step 1
    Open the bonnet. Unscrew the brake fluid reservoir cap.
    Step 2
    How to change Brake Discs on VAUXHALL ASTRA Mk IV (G) Saloon 1998 - free PDF and video manuals
    Secure the wheels with chocks.
  2. Step 3
    How to replace VAUXHALL Astra Mk IV (G) Saloon (T98) 1.6 16V 1999 Brake Discs - step-by-step manuals and video guides
    Loosen the wheel mounting bolts. Use wheel impact socket #17.
  3. Step 4
    Raise the front of the car and secure on supports.
    Step 5
    VAUXHALL ASTRA Mk IV (G) Saloon 1.4 16V 2000 Brake Discs replacement: free workshop manuals
    Unscrew the wheel bolts.
    AUTODOC recommends:
    Important! Hold the wheel while unscrewing the fastening bolts. VAUXHALL ASTRA Mk IV (G) Saloon
  4. Step 6
    Changing Brake Discs on VAUXHALL Astra Mk IV (G) Saloon (T98) 1.2 16V 2001 by yourself
    Remove the wheel.
  5. Step 7
    How to remove VAUXHALL ASTRA 1.6 2002 Brake Discs - online easy-to-follow instructions
    Detach the brake caliper retaining spring. Use a flat screwdriver.
  6. Step 8
    How to replace Brake Discs on VAUXHALL Astra Mk IV (G) Saloon (T98) 2003: download PDF manuals and video instructions
    Remove the dust boot caps of the brake caliper guide pins. Use a flat screwdriver.
  7. Step 9
    Clean the brake caliper fasteners. Use a wire brush. Use WD-40 spray.
    Step 10
    How hard is it to do yourself: Brake Discs replacement on VAUXHALL ASTRA Mk IV (G) Saloon 2.0 16V 2004 - download illustrated guide
    Unscrew the brake caliper fastening. Use HEX No.H7. Use a ratchet wrench.
  8. Step 11
    Need to know how to renew Brake Discs on VAUXHALL ASTRA 2005? This free workshop manual will help you to do it yourself
    Spread the brake pads. Use a crowbar.
  9. Step 12
    Changing of Brake Discs on VAUXHALL ASTRA Mk IV (G) Saloon 1998 won't be an issue if you follow this illustrated step-by-step guide
    Remove the brake caliper.
    Replacement: brake discs – VAUXHALL ASTRA Mk IV (G) Saloon. Professionals recommend:
    Tie the caliper to the suspension or to the body with a wire without disconnecting from the brake hose to prevent depressurization of the brake system.Make sure that the brake caliper is not hanging on the brake hose.Don't press the brake pedal after the brake caliper has been removed. As a result, the piston can fall out from the brake cylinder, and brake fluid leakage and depressurization of the system may occur. Check the brake caliper bracket, brake caliper guide pins and boots. Clean them. Replace, if necessary.
  10. Step 13
    VAUXHALL ASTRA 2.0 DI Brake Discs replacement: online guides and video tutorials
    Remove the brake pads.
  11. Step 14
    Replacing Brake Discs on VAUXHALL ASTRA Mk IV (G) Saloon 2000 1.6 16V by yourself
    Clean the brake caliper bracket fasteners. Use a wire brush. Use WD-40 spray.
  12. Step 15
    Astra Mk IV (G) Saloon (T98) 1.6 2001 Brake Discs DIY replacement workshop manual
    Unscrew the caliper bracket fastening. Use a drive socket #18. Use a ratchet wrench.
  13. Step 16
    Remove the fastening bolts (2 pieces).
    Step 17
    How to change Brake Discs on VAUXHALL Astra Mk IV (G) Saloon (T98) 2002 - tips and tricks
    Remove the caliper bracket.
  14. Step 18
    Step-by-step recommendations for DIY replacement VAUXHALL ASTRA Mk IV (G) Saloon 2003 1.6 Brake Discs
    Clean the brake disc fastener. Use a wire brush. Use WD-40 spray.
  15. Step 19
    DIY replacement of Brake Discs on VAUXHALL Astra Mk IV (G) Saloon (T98) 1.7 CDTI 16V 2004 is not an issue anymore with our step-by-step tutorial
    Unscrew the brake disc fastening. Use HEX No.H5. Use a ratchet wrench.
  16. Step 20
    How to change Brake Discs on VAUXHALL ASTRA Mk IV (G) Saloon 1998 - free PDF and video manuals
    Remove the brake disc.
  17. Step 21
    How to replace VAUXHALL Astra Mk IV (G) Saloon (T98) 1.6 16V 1999 Brake Discs - step-by-step manuals and video guides
    Clean the hub. Use a wire brush. Treat the contacting surface. Use copper grease.
  18. Step 22
    VAUXHALL ASTRA Mk IV (G) Saloon 1.4 16V 2000 Brake Discs replacement: free workshop manuals
    Install the brake disc.
  19. Step 23
    Changing Brake Discs on VAUXHALL Astra Mk IV (G) Saloon (T98) 1.2 16V 2001 by yourself
    Tighten the brake disc fastening. Use HEX No.H5. Use a torque wrench. Tighten it to 7 Nm torque.
  20. Step 24
    How to remove VAUXHALL ASTRA 1.6 2002 Brake Discs - online easy-to-follow instructions
    Clean the brake caliper bracket from dirt and dust. Use a wire brush. Use a brake cleaner.
    AUTODOC recommends:
    Replacement: brake discs – VAUXHALL ASTRA Mk IV (G) Saloon. After applying the spray, wait a few minutes.
Was this manual helpful?
Please rate this manual on a scale from 1 to 5. If you have any questions, feel free to ask us.
Users voted – 0
Need New Tyres?

Find out which tyre and wheel sizes are compatible with the VAUXHALL Astra Mk4 (G) Saloon (T98) model

VAUXHALL ASTRA Mk IV (G) Saloon tyre size

Popular maintenance tutorials for VAUXHALL ASTRA Mk IV (G) Saloon

More manuals for VAUXHALL ASTRA Mk IV (G) Saloon

Complete guides for changing the Brake rotors on different VAUXHALL ASTRA models

Unlock your car maintenance assistant!

Track expenses, manage logs, schedule replacements, and more.

DIY VAUXHALL Astra Mk IV (G) Saloon (T98) Brake Discs replacement - online guide
Tips & tricks for your VAUXHALL Astra Mk IV (G) Saloon (T98)
View more
  • How to change Brake rotors on VAUXHALL Astra Mk IV (G) Saloon (T98) 1.7 CDTI 16V - replacement tricks
    How to Polish Your Car Yourself and Save Money on Garage Services | AUTODOC tips
    6K views
    Published on: 31/03/2022
  • Changing Brake disc VAUXHALL ASTRA Mk IV (G) Saloon 1.6 16V - Replacement Tips
    Top Automatic Transmission Blunders You Must Dodge | AUTODOC Insights
    7K views
    Published on: 26/01/2021
  • Maintenance Hacks - VAUXHALL Astra Mk IV (G) Saloon (T98) 1.4 16V Rotors replacement guide
    Preventing Engine Failure: Head Gasket Inspection Tutorial | AUTODOC
    11K views
    Published on: 13/10/2020
  • Replace Disc brakes on VAUXHALL ASTRA Mk IV (G) Saloon - free video tips
    7 signs of faulty fuel injectors | AUTODOC tips
    9K views
    Published on: 09/01/2025

Most commonly replaced car parts on VAUXHALL ASTRA

Professional manuals for the most common VAUXHALL models

Autodoc CLUB App icon
Time to replace parts? Get even better deals in our Shop app.
VAUXHALL Astra Mk IV (G) Saloon (T98) Brake Discs replace by yourself - Scan QR-code and download AUTODOC CLUB app
SCAN ME