Recommended replacement interval for the part category Brake disc : 50000 km

Important!

This replacement procedure can be used for:
SKODA YETI (5L) 1.6 TDI, SKODA YETI (5L) 1.8 TSI 4x4, SKODA YETI (5L) 2.0 TDI, SKODA YETI (5L) 1.2 TSI, SKODA YETI (5L) 1.8 TSI 4x4, SKODA YETI (5L) 2.0 TDI, SKODA YETI (5L) 2.0 TDI 4x4, SKODA YETI (5L) 2.0 TDI 4x4, SKODA YETI (5L) 2.0 TDI 4x4, SKODA YETI (5L) 1.4 TSI, SKODA YETI (5L) 1.6, SKODA YETI (5L) 1.2 TSI, SKODA YETI (5L) 1.4 TSI, SKODA YETI (5L) 1.4 TSI 4x4, SKODA YETI (5L) 2.0 TDI, SKODA YETI (5L) 2.0 TDI 4x4 … View more

The steps may slightly vary depending on the car design.

This video shows the replacement procedure of a similar car part on another vehicle

Alternative products

Brake disc

Replacement: brake discs – SKODA YETI (5L). List of the tools you'll need:

                      Wire brush
                    
                      Nylon cleaning brush
                    
                      WD-40 spray
                    
                      Brake cleaner
                    
                      Copper grease
                    
                      HEX bit no.H7.
                    
                      Drive socket # 21
                    
                      Torx bit T30
                    
                      Wheel impact socket #17
                    
                      Ratchet wrench
                    
                      Torque wrench
                    
                      Tap wrench
                    
                      Brake caliper wind back tool
                    
                      Crow bar
                    
                      Wheel chock

Buy tools

Replacement: brake discs – SKODA YETI (5L). Tip from AUTODOC:

Replace the brake disks on the car SKODA YETI (5L) in complete set for each axis. Regardless of the state of components. This will ensure even braking.
The replacement procedure is identical for both brake disks on the same axle.
When changing the brake discs, always replace the brake pads.
Please note: all work on the car – SKODA YETI (5L) – should be done with the engine switched off.

Carry out replacement in the following order:

Step 1

Open the bonnet. Unscrew the brake fluid reservoir cap.

Step 2

Secure the wheels with chocks.
Step 3

Loosen the wheel mounting bolts. Use wheel impact socket #17.
Step 4

Raise the front of the car and secure on supports.

Step 5

Unscrew the wheel bolts.

Replacement: brake discs – SKODA YETI (5L). AUTODOC recommends:
To avoid injury, hold up the wheel when unscrewing the bolts.
Step 6

Remove the wheel.
Step 7

Remove the dust boot caps of the brake caliper guide pins. Use a crowbar.
Step 8

Unscrew the brake caliper fastening. Use HEX No.H7. Use a ratchet wrench.
Step 9

Spread the brake pads. Use a crowbar.
Step 10

Detach the brake caliper retaining spring. Use a crowbar.
Step 11

Remove the brake caliper.

Replacement: brake discs – SKODA YETI (5L). AUTODOC experts recommend:
Tie the caliper to the suspension or to the body with a wire without disconnecting from the brake hose to prevent depressurization of the brake system.Make sure that the brake caliper is not hanging on the brake hose.Don't press the brake pedal after the brake caliper has been removed. As a result, the piston can fall out from the brake cylinder, and brake fluid leakage and depressurization of the system may occur. Check the brake caliper bracket, brake caliper guide pins and boots. Clean them. Replace, if necessary.
Step 12

Remove the brake pads.
Step 13

Clean the brake caliper bracket fasteners. Use a wire brush. Use WD-40 spray.
Step 14

Unscrew the caliper bracket fastening. Use a drive socket #21. Use a ratchet wrench. Use a tap wrench.
Step 15

Remove the caliper bracket.
Step 16

Clean the brake disc fasteners. Use a wire brush. Use WD-40 spray.
Step 17

Unscrew the brake disc fastening. Use Torx T30. Use a ratchet wrench.
Step 18

Remove the brake disc.
Step 19

Clean the hub. Use a wire brush. Treat the contacting surface. Use copper grease.
Step 20

Install the brake disc.
Step 21

Tighten the brake disc fastening. Use Torx T30. Use a torque wrench. Tighten it to 4 Nm torque.
Step 22

Clean the brake caliper bracket from dirt and dust. Use a wire brush. Use a brake cleaner.

AUTODOC recommends:
Replacement: brake discs – SKODA YETI (5L). After applying the spray, wait a few minutes.
Step 23

Install the brake caliper bracket.
Step 24

Tighten the brake caliper bracket. Use a drive socket #21. Use a torque wrench. Tighten it to 190 Nm torque.
Step 25

Treat the brake caliper piston. Use a nylon cleaning brush. Use a brake cleaner.

Replacement: brake discs – SKODA YETI (5L). Tip:
After applying the spray, wait a few minutes.
Step 26

Press in the brake caliper piston. Use brake caliper wind back tool.
Step 27

Install the brake pads.
Step 28

Install the brake caliper and fix it. Use HEX No.H7. Use a torque wrench. Tighten it to 30 Nm torque.
Step 29

Install the dust boot caps of the brake caliper guide pins.
Step 30

Install the brake caliper retaining spring.
Step 31

Treat the surface where the brake disc contacts the wheel rim. Use copper grease.
Step 32

Clean the brake disk surface. Use a brake cleaner.

Replacement: brake discs – SKODA YETI (5L). Tip from AUTODOC experts:
After applying the spray, wait a few minutes.
Step 33

Install the wheel.

AUTODOC recommends:
To avoid injury, hold up the wheel when screwing in the fastening bolts.
Step 34

Screw in the wheel bolts. Use wheel impact socket #17.
Step 35

Lower the car and working in a cross order, tighten the wheel bolts. Use wheel impact socket #17. Use a torque wrench. Tighten it to 120 Nm torque.
Step 36

Remove the jacks and chocks.

AUTODOC recommends:
Check the brake fluid level in the expansion tank and refill if necessary.
Step 37

Tighten the brake fluid reservoir cap.

AUTODOC recommends:
SKODA YETI (5L) – Press the brake pedal several times with the engine shut down until you feel the resistance built up.
Step 38

Close the hood.

Was this manual helpful?

Please rate this manual on a scale from 1 to 5. If you have any questions, feel free to ask us.

Need New Tyres?

Find out which tyre and wheel sizes are compatible with the SKODA Yeti (5L) model

Skoda Yeti 5L tyre size

How to change rear brake caliper on SKODA YETI (5L) – replacement guide

Free download PDF
2.14 MB
How to change front brake pads on SKODA YETI (5L) – replacement guide

Free download PDF
1.57 MB
How to change front brake caliper on SKODA YETI (5L) – replacement guide

Free download PDF
2.01 MB
How to change front ABS sensor on SKODA YETI (5L) – replacement guide

Free download PDF
1.28 MB
How to change rear ABS sensor on SKODA YETI (5L) – replacement guide

Free download PDF
1.26 MB
How to change rear brake discs on SKODA YETI (5L) – replacement guide

Free download PDF
2 MB

How to change rear brake discs on SKODA YETI (5L) – replacement guide

Free download PDF
2 MB
How to change brake discs on a car – replacement tutorial

Universal

Free download PDF
2.92 MB
How to change rear brake discs on Skoda Octavia 1Z5 – replacement guide

Free download PDF
2.1 MB
How to change front brake discs on Skoda Octavia 1Z5 – replacement guide

Free download PDF
2.26 MB
How to change front brake discs on Skoda Fabia 6Y5 – replacement guide

Free download PDF
1.83 MB
How to change front brake discs on SKODA FABIA (NJ3) – replacement guide

Free download PDF
1.54 MB

Unlock your car maintenance assistant!

Track expenses, manage logs, schedule replacements, and more.

Transform Your Old Engine Valve Cover: Quick Polishing Tips for a Shiny Finish | AUTODOC Tips

11K views

Published on: 30/11/2023
How to inspect and troubleshoot your car heater when it’s not working

5K views

Published on: 11/02/2021
How to choose the right engine oil for your car | AUTODOC

15K views

Published on: 01/07/2020
5 easy car repairs you can do without a garage visit

5K views

Published on: 09/10/2025