How to carry out replacement: Brake Discs 1.2 S Opel Kadett D
Disclaimer
Change Opel Kadett D 1.6 D Brake Discs yourself – manuals and video tutorials

How to change front brake discs on OPEL KADETT D (32_,37_,39, _42) – replacement guide

downloads: 1
Views: 5
Download your free tutorial and fix OPEL KADETT D (32_,37_,39, _42) 1.3 N problems yourself Download for free 1.92 MB Brake Discs for Opel Kadett D Shop now
Leave a comment Open in a new tab
When to replace the Brake Discs on your OPEL KADETT
Recommended replacement interval for the part category Brake disc : 50000 km
Important!
This replacement procedure can be used for:
OPEL KADETT D (32_,37_,39, _42) 1.6 D … View more

The steps may slightly vary depending on the car design.

This video shows the replacement procedure of a similar car part on another vehicle

All the parts you need to replace – Brake Discs for KADETT D (32_,37_,39, _42) and other OPEL models
How to change Brake disc on Opel Kadett D 1.2 S – step-by-step instructions for straightforward car repair Brake disc
How to change Brake disc on Kadett D Saloon – tips for proper car maintenance
Brake disc for Kadett D Saloon Diesel (54 hp)
Tools
Replacement: brake discs – OPEL KADETT D (32_,37_,39, _42). Tools you need:
Wire brush
Nylon cleaning brush
WD-40 spray
Brake cleaner
Anti-squeal paste
High-temperature ceramic grease
Torque wrench
HEX bit No.H7
HEX bit No.H10
Wheel impact socket #17
Ratchet wrench
Tap wrench
Phillips Screwdriver
Rubber mallet
Impact screwdriver
Brake caliper wind back tool
Crow bar
Wheel chock
Buy tools
AUTODOC recommends:
  • Replace the brake disks on the car OPEL KADETT D (32_,37_,39, _42) in complete set for each axis. Regardless of the state of components. This will ensure even braking.
  • The replacement procedure is identical for both brake disks on the same axle.
  • When changing the brake discs, always replace the brake pads.
  • Please note: all work on the car – OPEL KADETT D (32_,37_,39, _42) – should be done with the engine switched off.
Carry out replacement in the following order:
  1. Step 1
    Open the bonnet.
    Step 2
    Unscrew the brake fluid reservoir cap.
    Step 3
    Secure the wheels with chocks.
    Step 4
    How to change Brake Discs on Opel Kadett D 1979 - free PDF and video manuals
    Loosen the wheel mounting bolts. Use wheel impact socket #17.
  2. Step 5
    Raise the car.
    Replacement: brake discs – OPEL KADETT D (32_,37_,39, _42). Tip from AUTODOC experts:
    If you are using a jack, make sure it rests on a flat surface without any unevenness.Be sure to additionally secure the car with jack stands.
    Step 6
    How to replace OPEL KADETT D (32_,37_,39, _42) 1.2 S 1980 Brake Discs - step-by-step manuals and video guides
    Unscrew the wheel bolts.
    AUTODOC recommends:
    Warning! To avoid injury, hold the wheel while unscrewing the fastening bolts. OPEL KADETT D (32_,37_,39, _42)
  3. Step 7
    Opel Kadett D 1.3 S 1981 Brake Discs replacement: free workshop manuals
    Remove the wheel.
  4. Step 8
    Changing Brake Discs on OPEL KADETT D (32_,37_,39, _42) 1.6 D 1982 by yourself
    Detach the brake caliper retaining spring. Use a crowbar.
  5. Step 9
    How to remove OPEL KADETT 1.0 1983 Brake Discs - online easy-to-follow instructions
    Spread the brake pads. Use a crowbar.
  6. Step 10
    How to replace Brake Discs on OPEL KADETT D (32_,37_,39, _42) 1984: download PDF manuals and video instructions
    Remove the dust boot caps of the brake caliper guide pins. Use a crowbar.
  7. Step 11
    How hard is it to do yourself: Brake Discs replacement on Opel Kadett D 1.3 S 1979 - download illustrated guide
    Unscrew the brake caliper fastening. Use HEX No.H7. Use a ratchet wrench.
  8. Step 12
    Need to know how to renew Brake Discs on OPEL KADETT 1980? This free workshop manual will help you to do it yourself
    Remove the brake caliper.
    Replacement: brake discs – OPEL KADETT D (32_,37_,39, _42). Professionals recommend:
    Tie the caliper to the suspension or to the body with a wire without disconnecting from the brake hose to prevent depressurization of the brake system.Make sure that the brake caliper is not hanging on the brake hose.Don't press the brake pedal after the brake caliper has been removed. As a result, the piston can fall out from the brake cylinder, and brake fluid leakage and depressurization of the system may occur.
  9. Step 13
    Changing of Brake Discs on Opel Kadett D 1981 won't be an issue if you follow this illustrated step-by-step guide
    Remove the brake pads.
  10. Step 14
    OPEL KADETT 1.6 D Brake Discs replacement: online guides and video tutorials
    Clean the brake caliper bracket fasteners. Use a wire brush. Use WD-40 spray.
  11. Step 15
    Replacing Brake Discs on Opel Kadett D 1983 1.2 S by yourself
    Unscrew the caliper bracket fastening. Use HEX No.H10. Use a ratchet wrench. Use a tap wrench.
  12. Step 16
    KADETT D (32_,37_,39, _42) 1.0 1984 Brake Discs DIY replacement workshop manual
    Remove the caliper bracket.
  13. Step 17
    How to change Brake Discs on OPEL KADETT D (32_,37_,39, _42) 1979 - tips and tricks
    Unscrew the brake disc fastening. Use a Phillips screwdriver. Use an impact screwdriver.
  14. Step 18
    Step-by-step recommendations for DIY replacement Opel Kadett D 1980 1.0 Brake Discs
    Remove the brake disc.
    Replacement: brake discs – OPEL KADETT D (32_,37_,39, _42). Tip from AUTODOC:
    If necessary, use a rubber mallet.
  15. Step 19
    DIY replacement of Brake Discs on OPEL KADETT D (32_,37_,39, _42) 1.3 N 1981 is not an issue anymore with our step-by-step tutorial
    Clean the hub. Use a wire brush. Treat the contacting surface. Use high-temperature ceramic grease.
  16. Step 20
    How to change Brake Discs on Opel Kadett D 1979 - free PDF and video manuals
    Install the brake disc.
  17. Step 21
    How to replace OPEL KADETT D (32_,37_,39, _42) 1.2 S 1980 Brake Discs - step-by-step manuals and video guides
    Screw in the brake disc fastener. Use a Phillips screwdriver.
  18. Step 22
    Opel Kadett D 1.3 S 1981 Brake Discs replacement: free workshop manuals
    Tighten the brake disc fastening. Use a Phillips screwdriver. Use a torque wrench. Tighten it to 7 Nm torque.
  19. Step 23
    Changing Brake Discs on OPEL KADETT D (32_,37_,39, _42) 1.6 D 1982 by yourself
    Clean the brake caliper bracket from dirt and dust. Use a wire brush. Use a brake cleaner.
    AUTODOC recommends:
    Replacement: brake discs – OPEL KADETT D (32_,37_,39, _42). After applying the spray, wait a few minutes.
Was this manual helpful?
Please rate this manual on a scale from 1 to 5. If you have any questions, feel free to ask us.
Users voted – 0
Searching for the right tyres?

Find out which tyre and wheel sizes are compatible with the OPEL Kadett D Saloon model.

Browse tyres

Popular maintenance tutorials for Opel Kadett D

More manuals for Opel Kadett D

Complete guides for changing the Brake rotors on different OPEL KADETT models

Your profile is your personal assistant.

It can track car expenses, keep a car log and replacement schedule, and save favourite materials, notes and documents

Install the AUTODOC CLUB app!
Your personal car expenses manager, maintenance tips, reminders about upcoming appointments and service intervals, DIY repair instructions – all this on your phone.
OPEL KADETT D (32_,37_,39, _42) Brake Discs replace by yourself - Scan QR-code and download AUTODOC CLUB app
Scan

To download the app:

  • - scan the QR code
  • - download from App Store
  • - download from Google Play
DIY OPEL KADETT D (32_,37_,39, _42) Brake Discs replacement - online guide
Tips & tricks for your OPEL KADETT D (32_,37_,39, _42)
View more
  • How to change Brake rotors on OPEL KADETT D (32_,37_,39, _42) 1.3 N - replacement tricks
    How to remove rust | AUTODOC tips
    25K views
    Published on: 16/09/2021
  • Changing Brake disc Opel Kadett D 1.2 S - Replacement Tips
    How to restore wheel rims | AUTODOC tips
    6K views
    Published on: 13/05/2021
  • Maintenance Hacks - OPEL KADETT D (32_,37_,39, _42) 1.3 S Brake disc kit replacement guide
    What to do if the airbag light is on | AUTODOC tips
    5K views
    Published on: 10/04/2023
  • Replace Disc brake set on Opel Kadett D - free video tips
    What to do if your check engine light is on | AUTODOC tips
    16K views
    Published on: 19/08/2020

Most commonly replaced car parts on OPEL KADETT

Professional manuals for the most common OPEL models