How to carry out replacement: Brake Discs 1.7 CDTi OPEL Corsa C Limousine (X01)
Disclaimer
Change OPEL Corsa C Limousine (X01) 1.7 CDTi Brake Discs yourself – manuals and video tutorials

How to change front brake discs on OPEL Corsa C Saloon (X01) – replacement guide

downloads: 1
Views: 6
Download your free tutorial and fix OPEL Corsa C Saloon (X01) 1.6 problems yourself Download for free 1.86 MB Brake Discs for OPEL Corsa C Limousine (X01) Shop now
Leave a comment Open in a new tab
When to replace the Brake Discs on your OPEL CORSA
Recommended replacement interval for the part category Brake disc : 50000 km
Important!
This replacement procedure can be used for:
OPEL Corsa C Saloon (X01) 1.7 CDTi … View more

The steps may slightly vary depending on the car design.

This video shows the replacement procedure of a similar car part on another vehicle

All the parts you need to replace – Brake Discs for Corsa C Saloon (X01) and other OPEL models
Alternative products
How to change Brake disc on OPEL Corsa C Limousine (X01) 1.7 CDTi – step-by-step instructions for straightforward car repair Brake disc
Tools
Replacement: brake discs – OPEL Corsa C Limousine (X01). List of the tools you'll need:
Wire brush
WD-40 spray
Brake cleaner
Copper grease
Drive socket # 18
HEX bit No.H5.
HEX bit No.H7.
Wheel impact socket #17
Brake caliper wind back tool
Ratchet wrench
Torque wrench
Tap wrench
Rubber mallet
Crow bar
Wheel chock
Buy tools
Replacement: brake discs – OPEL Corsa C Limousine (X01). Tip from AUTODOC experts:
  • Replace the brake disks on the car OPEL Corsa C Limousine (X01) in complete set for each axis. Regardless of the state of components. This will ensure even braking.
  • The replacement procedure is identical for both brake disks on the same axle.
  • When changing the brake discs, always replace the brake pads.
  • All work should be done with the engine stopped.
Replacement: brake discs – OPEL Corsa C Limousine (X01). Take the following steps:
  1. Step 1
    Open the bonnet. Unscrew the brake fluid reservoir cap.
    Step 2
    How to change Brake Discs on OPEL Corsa C Limousine (X01) 2000 - free PDF and video manuals
    Secure the wheels with chocks.
  2. Step 3
    How to replace OPEL Corsa C Saloon (X01) 1.7 CDTi 2001 Brake Discs - step-by-step manuals and video guides
    Loosen the wheel mounting bolts. Use wheel impact socket #17.
  3. Step 4
    Raise the front of the car and secure on supports.
    Step 5
    OPEL Corsa C Limousine (X01) 1.6 2002 Brake Discs replacement: free workshop manuals
    Unscrew the wheel bolts.
    Replacement: brake discs – OPEL Corsa C Limousine (X01). AUTODOC recommends:
    To avoid injury, hold up the wheel when unscrewing the bolts.
  4. Step 6
    Changing Brake Discs on OPEL Corsa C Saloon (X01) 1.6 2003 by yourself
    Remove the wheel.
  5. Step 7
    How to remove OPEL CORSA 1.7 CDTi 2004 Brake Discs - online easy-to-follow instructions
    Remove the dust boot caps of the brake caliper guide pins. Use a crowbar.
  6. Step 8
    How to replace Brake Discs on OPEL Corsa C Saloon (X01) 2005: download PDF manuals and video instructions
    Unscrew the brake caliper fastening. Use HEX No.H7. Use a ratchet wrench.
  7. Step 9
    How hard is it to do yourself: Brake Discs replacement on OPEL Corsa C Limousine (X01) 1.7 CDTi 2006 - download illustrated guide
    Spread the brake pads. Use a crowbar.
  8. Step 10
    Need to know how to renew Brake Discs on OPEL CORSA 2007? This free workshop manual will help you to do it yourself
    Pull aside the brake caliper retaining spring. Use a crowbar.
  9. Step 11
    Changing of Brake Discs on OPEL Corsa C Limousine (X01) 2008 won't be an issue if you follow this illustrated step-by-step guide
    Remove the brake caliper.
    Replacement: brake discs – OPEL Corsa C Limousine (X01). Professionals recommend:
    Tie the caliper to the suspension or to the body with a wire without disconnecting from the brake hose to prevent depressurization of the brake system.Make sure that the brake caliper is not hanging on the brake hose.Don't press the brake pedal after the brake caliper has been removed. As a result, the piston can fall out from the brake cylinder, and brake fluid leakage and depressurization of the system may occur. Check the brake caliper bracket, brake caliper guide pins and boots. Clean them. Replace, if necessary.
  10. Step 12
    OPEL CORSA 1.7 CDTi Brake Discs replacement: online guides and video tutorials
    Remove the brake pads.
  11. Step 13
    Replacing Brake Discs on OPEL Corsa C Limousine (X01) 2000 1.7 CDTi by yourself
    Clean the brake caliper bracket fasteners. Use a wire brush. Use WD-40 spray.
  12. Step 14
    Corsa C Saloon (X01) 1.7 CDTi 2001 Brake Discs DIY replacement workshop manual
    Unscrew the caliper bracket fastening. Use a drive socket #18. Use a tap wrench.
  13. Step 15
    How to change Brake Discs on OPEL Corsa C Saloon (X01) 2002 - tips and tricks
    Remove the caliper bracket.
  14. Step 16
    Step-by-step recommendations for DIY replacement OPEL Corsa C Limousine (X01) 2003 1.7 CDTi Brake Discs
    Clean the brake disc fasteners. Use a wire brush. Use WD-40 spray.
  15. Step 17
    DIY replacement of Brake Discs on OPEL Corsa C Saloon (X01) 1.7 CDTi 2004 is not an issue anymore with our step-by-step tutorial
    Unscrew the brake disc fastening. Use HEX No.H5. Use a ratchet wrench.
  16. Step 18
    How to change Brake Discs on OPEL Corsa C Limousine (X01) 2000 - free PDF and video manuals
    Remove the brake disc.
    Replacement: brake discs – OPEL Corsa C Limousine (X01). Tip from AUTODOC:
    If necessary, use a rubber mallet.
  17. Step 19
    How to replace OPEL Corsa C Saloon (X01) 1.7 CDTi 2001 Brake Discs - step-by-step manuals and video guides
    Clean the hub. Use a wire brush. Treat the contacting surface. Use copper grease.
  18. Step 20
    OPEL Corsa C Limousine (X01) 1.6 2002 Brake Discs replacement: free workshop manuals
    Install the brake disc.
  19. Step 21
    Changing Brake Discs on OPEL Corsa C Saloon (X01) 1.6 2003 by yourself
    Tighten the brake disc fastening. Use HEX No.H5. Use a torque wrench. Tighten it to 7 Nm torque.
  20. Step 22
    How to remove OPEL CORSA 1.7 CDTi 2004 Brake Discs - online easy-to-follow instructions
    Clean the brake caliper bracket from dirt and dust. Use a wire brush. Use a brake cleaner.
    AUTODOC recommends:
    Replacement: brake discs – OPEL Corsa C Limousine (X01). After applying the spray, wait a few minutes.
Was this manual helpful?
Please rate this manual on a scale from 1 to 5. If you have any questions, feel free to ask us.
Users voted – 0
Need New Tyres?

Find out which tyre and wheel sizes are compatible with the OPEL Corsa C Saloon (X01) model

OPEL Corsa C Limousine (X01) tyre size

Popular maintenance tutorials for OPEL Corsa C Limousine (X01)

More manuals for OPEL Corsa C Limousine (X01)

Complete guides for changing the Brake rotors on different OPEL CORSA models

Unlock your car maintenance assistant!

Track expenses, manage logs, schedule replacements, and more.

DIY OPEL Corsa C Saloon (X01) Brake Discs replacement - online guide
Tips & tricks for your OPEL Corsa C Saloon (X01)
View more
  • How to change Brake rotors on OPEL Corsa C Saloon (X01) 1.7 CDTi - replacement tricks
    BMW E30 Turbo Suspension Swap: Boost Your Handling | AUTODOC project
    2K views
    Published on: 04/03/2021
  • Changing Brake disc OPEL Corsa C Limousine (X01) 1.7 CDTi - Replacement Tips
    3 essential tips for choosing summer tyres | Get ready for warmer weather
    4K views
    Published on: 18/05/2023
  • Maintenance Hacks - OPEL Corsa C Saloon (X01) 1.6 Rotors replacement guide
    How to fix your car with AUTODOC CLUB
    17K views
    Published on: 30/11/2021
  • Replace Disc brakes on OPEL Corsa C Limousine (X01) - free video tips
    What causes engine misfire? | AUTODOC
    6K views
    Published on: 10/07/2020

Most commonly replaced car parts on OPEL CORSA

Professional manuals for the most common OPEL models

Autodoc CLUB App icon
Time to replace parts? Get even better deals in our Shop app.
OPEL Corsa C Saloon (X01) Brake Discs replace by yourself - Scan QR-code and download AUTODOC CLUB app
SCAN ME