How to carry out replacement: ABS Sensor 1.9 TDI Seat Cordoba 6K5
Disclaimer
Change Seat Cordoba 6K5 1.9 SDI ABS Sensor yourself – manuals and video tutorials

How to change front ABS sensor on SEAT Cordoba Vario (6K5) – replacement guide

downloads: 5
Views: 61
Download your free tutorial and fix SEAT Cordoba Vario (6K5) 1.6 i problems yourself Download for free 1.94 MB ABS Sensor for Seat Cordoba 6K5 Shop now
Leave a comment Open in a new tab
Important!
This replacement procedure can be used for:
SEAT Cordoba Vario (6K5) 1.4 i, SEAT Cordoba Vario (6K5) 1.9 SDI, SEAT Cordoba Vario (6K5) 1.6 i, SEAT Cordoba Vario (6K5) 1.9 TDI, SEAT Cordoba Vario (6K5) 1.6 i, SEAT Cordoba Vario (6K5) 1.9 TDI, SEAT Cordoba Vario (6K5) 1.8 i, SEAT Cordoba Vario (6K5) 1.6 i, SEAT Cordoba Vario (6K5) 1.4 … View more

The steps may slightly vary depending on the car design.

This video shows the replacement procedure of a similar car part on another vehicle

All the parts you need to replace – ABS Sensor for Cordoba Vario (6K5) and other SEAT models
Alternative products
How to change ABS sensor on Seat Cordoba 6K5 1.9 TDI – step-by-step instructions for straightforward car repair ABS sensor
Tools
Replacement: ABS sensor – SEAT CORDOBA Vario (6K5). Tools you might need:
Wire brush
Nylon cleaning brush
WD-40 spray
Brake cleaner
Electronic spray
Copper grease
Multipurpose grease
Torque wrench
Torx bit T30
HEX bit No.H5
HEX bit No.H7
Wheel impact socket #17
Ratchet wrench
Flat screwdriver
Pin punch
Tap wrench
Hammer
Crow bar
Wheel chock
Buy tools
Replacement: ABS sensor – SEAT CORDOBA Vario (6K5). Tip from AUTODOC:
  • All work should be done with the engine stopped.
Replacement: ABS sensor – SEAT CORDOBA Vario (6K5). Take the following steps:
  1. Step 1
    Secure the wheels with chocks.
    Step 2
    How to change ABS Sensor on Seat Cordoba 6K5 1996 - free PDF and video manuals
    Loosen the wheel mounting bolts. Use wheel impact socket #17.
  2. Step 3
    Raise the front of the car and secure on supports.
    Step 4
    How to replace SEAT Cordoba Vario (6K5) 1.9 TDI 1997 ABS Sensor - step-by-step manuals and video guides
    Unscrew the wheel bolts.
    AUTODOC recommends:
    Warning! To avoid injury, hold the wheel while unscrewing the fastening bolts. SEAT CORDOBA Vario (6K5)
  3. Step 5
    Seat Cordoba 6K5 1.6 i 1998 ABS Sensor replacement: free workshop manuals
    Remove the wheel.
  4. Step 6
    Changing ABS Sensor on SEAT Cordoba Vario (6K5) 1.4 i 1999 by yourself
    Clean the ABS sensor fastener. Use a nylon cleaning brush. Use WD-40 spray.
  5. Step 7
    How to remove SEAT CORDOBA 1.4 16V 2000 ABS Sensor - online easy-to-follow instructions
    Detach the ABS sensor connector. Use a flat screwdriver.
  6. Step 8
    How to replace ABS Sensor on SEAT Cordoba Vario (6K5) 2001: download PDF manuals and video instructions
    Clean the ABS sensor fastener. Use a wire brush. Use WD-40 spray.
  7. Step 9
    How hard is it to do yourself: ABS Sensor replacement on Seat Cordoba 6K5 1.9 TDI 2002 - download illustrated guide
    Unscrew the ABS sensor fastener. Use HEX No.H5. Use a ratchet wrench.
  8. Step 10
    Need to know how to renew ABS Sensor on SEAT CORDOBA 1996? This free workshop manual will help you to do it yourself
    Remove the caps from the brake caliper guide pin boots. Use a crowbar.
  9. Step 11
    Changing of ABS Sensor on Seat Cordoba 6K5 1997 won't be an issue if you follow this illustrated step-by-step guide
    Unscrew the brake caliper fastening. Use HEX No.H7. Use a ratchet wrench. Use a tap wrench.
  10. Step 12
    SEAT CORDOBA 1.9 SDI ABS Sensor replacement: online guides and video tutorials
    Spread the brake pads. Use a crowbar.
  11. Step 13
    Replacing ABS Sensor on Seat Cordoba 6K5 1999 1.9 TDI by yourself
    Remove the brake caliper.
    Replacement: ABS sensor – SEAT CORDOBA Vario (6K5). Professionals recommend:
    Tie the caliper to the suspension or to the body with a wire without disconnecting from the brake hose to prevent depressurization of the brake system.Make sure that the brake caliper is not hanging on the brake hose.Don't press the brake pedal after the brake caliper has been removed. As a result, the piston can fall out from the brake cylinder, and brake fluid leakage and depressurization of the system may occur. Check the brake caliper bracket, brake caliper guide pins and boots. Clean them. Replace, if necessary.
  12. Step 14
    Cordoba Vario (6K5) 1.4 16V 2000 ABS Sensor DIY replacement workshop manual
    Clean the brake disc fastener. Use a wire brush. Use WD-40 spray.
  13. Step 15
    How to change ABS Sensor on SEAT Cordoba Vario (6K5) 2001 - tips and tricks
    Unscrew the brake disc fastening. Use Torx T30. Use a ratchet wrench.
  14. Step 16
    Step-by-step recommendations for DIY replacement Seat Cordoba 6K5 2002 1.4 16V ABS Sensor
    Remove the brake disc.
  15. Step 17
    DIY replacement of ABS Sensor on SEAT Cordoba Vario (6K5) 1.9 SDI 1996 is not an issue anymore with our step-by-step tutorial
    Disconnect the ABS sensor. Use a pin punch. Use a hammer. Use a crowbar.
  16. Step 18
    How to change ABS Sensor on Seat Cordoba 6K5 1996 - free PDF and video manuals
    Clean the ABS sensor mounting seat. Use a wire brush. Use WD-40 spray.
  17. Step 19
    How to replace SEAT Cordoba Vario (6K5) 1.9 TDI 1997 ABS Sensor - step-by-step manuals and video guides
    Treat the ABS sensor fastener. Use a multipurpose grease.
  18. Step 20
    Seat Cordoba 6K5 1.6 i 1998 ABS Sensor replacement: free workshop manuals
    Connect the ABS sensor.
Was this manual helpful?
Please rate this manual on a scale from 1 to 5. If you have any questions, feel free to ask us.
Users voted – 0
Need New Tyres?

Find out which tyre and wheel sizes are compatible with the SEAT Córdoba I Vario (6K5) model

Seat Cordoba 6K5 tyre size

Popular maintenance tutorials for Seat Cordoba 6K5

More manuals for Seat Cordoba 6K5

Complete guides for changing the Wheel speed sensor on different SEAT CORDOBA models

Unlock your car maintenance assistant!

Track expenses, manage logs, schedule replacements, and more.

DIY SEAT Cordoba Vario (6K5) ABS Sensor replacement - online guide
Tips & tricks for your SEAT Cordoba Vario (6K5)
View more
  • How to change Wheel speed sensor on SEAT Cordoba Vario (6K5) 1.9 SDI - replacement tricks
    The Fast and Easy Way to Fix a Broken Wheel Stud | AUTODOC tips
    9K views
    Published on: 08/12/2020
  • Changing Sensor ABS Seat Cordoba 6K5 1.9 TDI - Replacement Tips
    Deep interior cleaning | Car transformation by detailing
    7K views
    Published on: 05/09/2024
  • Maintenance Hacks - SEAT Cordoba Vario (6K5) 1.6 i ABS wheel speed sensor replacement guide
    Petrol or diesel: The engine showdown! | AUTODOC
    4K views
    Published on: 04/05/2021
  • Replace Anti lock brake sensor (ABS) on Seat Cordoba 6K5 - free video tips
    Top 5 car noises you shouldn't ignore
    7K views
    Published on: 10/04/2025

Most commonly replaced car parts on SEAT CORDOBA

Professional manuals for the most common SEAT models

ОЕ number
Autodoc CLUB App icon
Time to replace parts? Get even better deals in our Shop app.
SEAT Cordoba Vario (6K5) ABS Sensor replace by yourself - Scan QR-code and download AUTODOC CLUB app
SCAN ME