Recommended replacement interval for the part category Oil filter : 1 year / 30000 km

Important!

This replacement procedure can be used for:
VOLVO XC70 II Estate (136) D5 AWD, VOLVO XC70 II Estate (136) 2.4 D / D4 AWD, VOLVO XC70 II Estate (136) D5 AWD, VOLVO XC70 II Estate (136) T5 AWD, VOLVO XC70 II Estate (136) T6 AWD, VOLVO XC70 II Estate (136) D5 AWD … View more

The steps may slightly vary depending on the car design.

This video shows the replacement procedure of a similar car part on another vehicle

All the parts you need to replace – Oil Filter for XC70 II Estate (136) and other VOLVO models

Alternative products

Oil filter

Replacement: engine oil and filter – VOLVO XC70 II. Tools you might need:

                      All-purpose cleaning spray
                    
                      Drive socket # 17 
                    
                      Drive socket # 36 
                    
                      Ratchet wrench
                    
                      Torque wrench
                    
                      Flat Screwdriver
                    
                      Funnel
                    
                      Oil drain pan
                    
                      Fender cover

Buy tools

Replacement: engine oil and filter – VOLVO XC70 II. AUTODOC experts recommend:

Replace the oil filter every time when changing motor oil.
Wear gloves to prevent contact with hot liquid.
Use only new O-rings during installation.
Please note: all work on the car – VOLVO XC70 II – should be done with the engine switched off.

Carry out replacement in the following order:

Step 1

Lift the car using a jack or place it over an inspection pit.

Replacement: engine oil and filter – VOLVO XC70 II. Tip from AUTODOC experts:
The vehicle must be on even keel, and if it is at an angle, the drain plug must be at the lowest point.All work should be done with the engine stopped.
Step 2

Put a waste oil container with at least 6 l capacity under the drainage hole.
Step 3

Unscrew the drain plug. Use a drive socket #17. Use a ratchet wrench.
Step 4

Drain the used oil.

Replacement: engine oil and filter – VOLVO XC70 II. Tip:
Caution! The oil may be hot.Wait until the oil has completely drained from the drainage hole.
Step 5

Clean the area of the oil pan drainage hole.

Step 6

Screw in the new drainage plug and tighten it. Use a drive socket #17. Use a torque wrench. Tighten it to 28 nm torque.
Step 7

Clean the area of the oil pan drainage hole. Use all-purpose cleaning spray.

Step 8

Lower the car.

Step 9

Open the hood.

Step 10

Use a fender protection cover to prevent damaging paintwork and plastic parts of the car.

Step 11

Remove the engine cover.

AUTODOC recommends:
Replacement: engine oil and filter – VOLVO XC70 II. Do not use excessive force when removing the part as this may damage it.
Step 12

Unscrew the filter housing cap together with the old filter element. Use a drive socket #36. Use a ratchet wrench.
Step 13

Prepare a container for the old oil filter.
Step 14

Put the old oil filter in the container.

Replacement: engine oil and filter – VOLVO XC70 II. Tip from AUTODOC experts:
Move up the container. The oil starts to drain out of the drainage hole immediately after you have removed the oil filter.
Step 15

Detach the oil filter from the filter cover.
Step 16

Remove the oil filter cover O-ring. Use a flat screwdriver.
Step 17

Install a new O-ring to its mounting seat on the filter cover. Use a flat screwdriver.
Step 18

Install the new oil filter to the mounting seat on the filter cover.

Please note!
Make sure to install the filter correctly. Don't mix up the sides of the part.
Step 19

Lubricate the rubber seal of the new filter with a little amount of fresh oil.

Step 20

Clean the oil filter seat.

Step 21

Install a new oil filter housing cover and tighten it. Use a drive socket #36. Use a torque wrench. Tighten it to 25 Nm torque.
Step 22

Unscrew the oil filler plug.

Step 23

Remove the oil filler cap.
Step 24

Insert the funnel.

Step 25

Pour oil into the engine through the filler. Required amount of oil: 5.9 L.

Replacement: engine oil and filter – VOLVO XC70 II. AUTODOC experts recommend:
Use the oil recommended by the manufacturer.
Step 26

Check the oil level using the dipstick. Top up oil if necessary.

Please note!
The oil level should be between the Min and Max marks.
Step 27

Install the oil filler cap.
Step 28

Tighten the oil filler cap.

Step 29

Run the engine for a few minutes. After the oil pressure warning light goes out, stop the engine.

Step 30

Check the oil level 5 minutes after the stop of the engine operation using a dipstick and add oil if necessary.

Please note!
The oil level should be between the Min and Max marks.Make sure that the oil filler cap is properly tightened.Check the threaded plug of the drainage hole and the oil filter seal for tightness. If necessary, carefully tighten them up.
Step 31

Install the engine cover and secure it.

AUTODOC recommends:
Replacement: engine oil and filter – VOLVO XC70 II. To avoid damaging the part during installation, do not use excessive force.
Step 32

Remove the fender protection cover. Close the hood.

Replacement: engine oil and filter – VOLVO XC70 II. AUTODOC recommends:
Note that oil pressure warning light, which indicates insufficient pressure in the lubrication system, may be on for a longer time than usual. After a few seconds, the oil will fill all the channels, and the light will go out.To protect the environment from pollution, be sure to dispose of the used filters at special collection points.

Was this manual helpful?

Please rate this manual on a scale from 1 to 5. If you have any questions, feel free to ask us.

Need New Tyres?

Find out which tyre and wheel sizes are compatible with the VOLVO XC70 II Estate (P24, 136) model

Volvo XC70 Estate tyre size

How to change pollen filter on VOLVO XC70 II Estate (136) – replacement guide

Free download PDF
1.4 MB
How to change fuel filter on VOLVO XC70 II Estate (136) – replacement guide

Free download PDF
921.6 KB
How to change front brake pads on VOLVO XC70 II Estate (136) – replacement guide

Free download PDF
1.54 MB
How to change rear brake pads on VOLVO XC70 II Estate (136) – replacement guide

Free download PDF
1.39 MB
How to change front brake discs on VOLVO XC70 II Estate (136) – replacement guide

Free download PDF
2.19 MB
How to change rear brake discs on VOLVO XC70 II Estate (136) – replacement guide

Free download PDF
2.08 MB

How to change engine oil and filter on VOLVO XC70 I Cross Country (P2, 295) – replacement guide

Free download PDF
2.3 MB
How to change engine oil and filter on a car – replacement tutorial

Universal

Free download PDF
2.82 MB
How to change engine oil and filter on Volvo XC90 1 – replacement guide

Free download PDF
2.67 MB
How to change engine oil and filter on Volvo V50 MW – replacement guide

Free download PDF
2.92 MB
How to change engine oil and filter on Volvo V70 SW – replacement guide

Free download PDF
1.99 MB
How to change engine oil and filter on Volvo V70 BW – replacement guide

Free download PDF
1.81 MB

Unlock your car maintenance assistant!

Track expenses, manage logs, schedule replacements, and more.

Understanding Car Tools: The Key Differences You Need to Know | AUTODOC tips

8K views

Published on: 16/12/2021
What to do if the ABS light comes on: DIY Diagnostics Tips

8K views

Published on: 11/03/2021
Stop Rust Before It Starts: Top 5 Tips for Car Body Protection | AUTODOC Insights

7K views

Published on: 27/07/2023
How to prevent car windows from fogging up | AUTODOC tips

13K views

Published on: 04/02/2021