Recommended replacement interval for the part category Oil filter : 12 month / 15000 km

Important!

This replacement procedure can be used for:
VAUXHALL Movano Mk1 (A) Platform / Chassis (X70) 2.5 CDTI (UD0, ED), VAUXHALL Movano Mk1 (A) Platform / Chassis (X70) 2.5 CDTI (ED, UD0), VAUXHALL Movano Mk1 (A) Platform / Chassis (X70) 2.5 CDTI (ED, UD0), VAUXHALL Movano Mk1 (A) Platform / Chassis (X70) 2.5 CDTI (UD0, ED) … View more

The steps may slightly vary depending on the car design.

This video shows the replacement procedure of a similar car part on another vehicle

Alternative products

Oil filter

Replacement: engine oil and filter – VAUXHALL Movano Mk1 (A) Pritsche / Fahrgestell (X70). List of the tools you'll need:

                      Wire brush
                    
                      All-purpose cleaning spray
                    
                      Torque wrench
                    
                      8 mm square head drain plug socket
                    
                      27 mm socket
                    
                      Ratchet wrench
                    
                      Slotted screwdriver
                    
                      Funnel
                    
                      Oil drain pan
                    
                      Fender cover
                    
                      Car lift or inspection pit

Buy tools

Replacement: engine oil and filter – VAUXHALL Movano Mk1 (A) Pritsche / Fahrgestell (X70). AUTODOC recommends:

Replace the oil filter every time you change the engine oil.
Before getting down to work, warm up the engine to reduce the viscosity of the oil.
Wear gloves to prevent contact with hot liquid.
All the work should be carried out with the ignition switched off.

Replacement: engine oil and filter – VAUXHALL Movano Mk1 (A) Pritsche / Fahrgestell (X70). Recommended sequence of steps:

Step 1

Open the bonnet.

Step 2

Use a fender protection cover to avoid damaging the paintwork and plastic parts of the car.

Step 3

Unscrew the oil filler cap.
Step 4

Pull up the oil dipstick.
Step 5

Lift the vehicle using a vehicle lift or place it over an inspection pit.

Replacement: engine oil and filter – VAUXHALL Movano Mk1 (A) Pritsche / Fahrgestell (X70). Professionals recommend:
The vehicle must be level, but if it is at an angle, the drain plug must be at the lowest point.
Step 6

Put an oil drain pan with a capacity of at least 8 litres under the drain hole.
Step 7

Clean the area of the oil pan drain hole. Use a wire brush. Use an all-purpose cleaning spray.
Step 8

Unscrew the drain plug. Use an 8 mm square head drain plug socket. Use a ratchet wrench.
Step 9

Drain the used oil.

Caution!
The oil may be hot.Wait until the oil has completely flowed out of the drain hole.
Step 10

Clean the oil filter cap. Use an all-purpose cleaning spray.
Step 11

Unscrew the filter cap together with the old filter element. Use a 27 mm socket. Use a ratchet wrench.

Caution!
The oil may be hot.
Step 12

Clean the oil filter mounting seat. Use an all-purpose cleaning spray.
Step 13

Remove the filter element from the filter cap. Remove the old O-ring of the oil filter cap. Use a slotted screwdriver.
Step 14

Clean the oil filter cap. Use an all-purpose cleaning spray.
Step 15

Install a new O-ring on the oil filter cap. Install a new filter element into the oil filter cap.
Step 16

Lubricate the new O-ring of the oil filter cap with a small amount of fresh oil.
Step 17

Install the oil filter cap and screw it in. Use a 27 mm socket. Use a torque wrench. Tightening torque: 25 N·m.
Step 18

Clean the area of the oil pan drain hole. Use an all-purpose cleaning spray.
Step 19

Screw in the drain plug and tighten it. Use an 8 mm square head drain plug socket. Use a torque wrench. Tightening torque: 20 N·m.
Step 20

Lower the vehicle.

Step 21

Remove the oil filler cap.
Step 22

Pour oil into the engine through the filler neck. Required amount of oil: 8 L.

Replacement: engine oil and filter – VAUXHALL Movano Mk1 (A) Pritsche / Fahrgestell (X70). Tip from AUTODOC:
Use the oil recommended by the manufacturer.
Step 23

Check the oil level using the dipstick.

Important!
The oil level should be between the Min and Max marks.Top up oil if necessary.
Step 24

Screw on the oil filler cap.
Step 25

Run the engine for a few minutes.

Replacement: engine oil and filter – VAUXHALL Movano Mk1 (A) Pritsche / Fahrgestell (X70). AUTODOC experts recommend:
The oil pressure warning light, which indicates insufficient pressure in the lubrication system, may be on for a longer time than usual. After a few seconds, the oil will fill all the passages, and the light will go out.
Step 26

Check the oil level with a dipstick in 5 minutes after turning the engine off and add oil if necessary.

Caution!
The oil level should be between the Min and Max marks.
Step 27

Make sure that the oil filler cap is properly tightened.

Step 28

Check the threaded plug of the drain hole and the oil filter seal for tightness. If necessary, tighten them up carefully.

Step 29

Remove the fender cover.

Step 30

Close the bonnet.

Replacement: engine oil and filter – VAUXHALL Movano Mk1 (A) Pritsche / Fahrgestell (X70). Tip:
To protect the environment from pollution, be sure to dispose of the used filters and oil at special collection points.

Was this manual helpful?

Please rate this manual on a scale from 1 to 5. If you have any questions, feel free to ask us.

Need New Tyres?

Find out which tyre and wheel sizes are compatible with the VAUXHALL Movano Mk1 (A) Platform / Chassis (X70) model

VAUXHALL Movano Mk1 (A) Pritsche / Fahrgestell (X70) tyre size

How to change crankshaft position sensor on VAUXHALL Movano Mk1 (A) Platform / Chassis (X70) – replacement guide

Free download PDF
901.12 KB
How to change rear coil springs on VAUXHALL Zafira Mk II (B) (A05) – replacement guide

Free download PDF
1.44 MB
How to change front coil springs on VAUXHALL Meriva Mk II (B) (S10) – replacement guide

Free download PDF
2.78 MB
How to change front coil springs on VAUXHALL Zafira Mk II (B) (A05) – replacement guide

Free download PDF
2.77 MB
How to change front coil springs on VAUXHALL Zafira Mk I (A) (T98) – replacement guide

Free download PDF
3.49 MB
How to change rear coil springs on VAUXHALL Zafira Mk I (A) (T98) – replacement guide

Free download PDF
1.66 MB

How to change engine oil and filter on VAUXHALL Movano Mk1 (A) Van (X70) – replacement guide

Free download PDF
1.6 MB
How to change engine oil and filter on VAUXHALL Movano Mk1 (A) Combi (X70) – replacement guide

Free download PDF
1.6 MB
How to change engine oil and filter on a car – replacement tutorial

Universal

Free download PDF
2.82 MB
How to change engine oil and filter on VAUXHALL Ampera (R12) – replacement guide

Free download PDF
1.56 MB
How to change engine oil and filter on VAUXHALL Astra Mk IV (G) Convertible (T98) – replacement guide

Free download PDF
1.56 MB
How to change engine oil and filter on VAUXHALL Astra Mk3 (F) Convertible (T92) – replacement guide

Free download PDF
1.56 MB

Unlock your car maintenance assistant!

Track expenses, manage logs, schedule replacements, and more.

#DIY Guide: How to Fix a Cracked Windscreen Without a Garage Visit

9K views

Published on: 14/12/2023
Understanding Airbag Light Warnings | Essential Tips for Car Safety

6K views

Published on: 10/04/2023
Stop Rust Before It Starts: Top 5 Tips for Car Body Protection | AUTODOC Insights

7K views

Published on: 27/07/2023
The Ultimate Guide to Engine Bay Cleaning | AUTODOC

6K views

Published on: 11/09/2020