Recommended replacement interval for the part category Oil filter : 1 year / 30000 km

Important!

This replacement procedure can be used for:
VAUXHALL Corsa Mk IV (E) Hatchback (X15) 1.3 CDTi … View more

The steps may slightly vary depending on the car design.

This video shows the replacement procedure of a similar car part on another vehicle

All the parts you need to replace – Oil Filter for Corsa Mk IV (E) Hatchback (X15) and other VAUXHALL models

Oil filter

Oil filter for Corsa Mk4 (E) Hatchback (X15) Diesel (75 hp)

Replacement: engine oil and filter – VAUXHALL CORSA Mk IV (E). Tools you might need:

                        All-purpose cleaning spray
                      
                        Torx bit T45
                      
                        Drive socket # 27
                      
                        Ratchet wrench
                      
                        Torque wrench
                      
                        Flat Screwdriver
                      
                        Funnel
                      
                        Oil drain pan
                      
                        Fender cover

Buy tools

Replacement: engine oil and filter – VAUXHALL CORSA Mk IV (E). AUTODOC recommends:

Replace the oil filter every time when changing motor oil.
Wear gloves to prevent contact with hot liquid.
Use only new O-rings during installation.
All work should be done with the engine stopped.

Carry out replacement in the following order:

Step 1

Lift the car using a jack or place it over an inspection pit.

Replacement: engine oil and filter – VAUXHALL CORSA Mk IV (E). Tip:
The vehicle must be on even keel, and if it is at an angle, the drain plug must be at the lowest point.All work should be done with the engine stopped.
Step 2

Put a waste oil container with at least 4 l capacity under the drainage hole.
Step 3

Unscrew the drain plug. Use Torx T45. Use a ratchet wrench.
Step 4

Drain the used oil.

AUTODOC recommends:
Caution! The oil may be hot.Wait until the oil has completely drained from the drainage hole.
Step 5

Clean the area of the oil pan drainage hole.
Step 6

Screw in the new drainage plug and tighten it. Use Torx T45. Use a torque wrench. Tighten it to 20 nm torque.
Step 7

Clean the area of the oil pan drainage hole. Use all-purpose cleaning spray.
Step 8

Lower the car.

Step 9

Open the hood.

Step 10

Use a fender protection cover to prevent damaging paintwork and plastic parts of the car.

Step 11

Unscrew the filter housing cap together with the old filter element. Use a drive socket #27. Use a ratchet wrench.
Step 12

Prepare a container for the old oil filter.
Step 13

Put the old oil filter in the container.

Replacement: engine oil and filter – VAUXHALL CORSA Mk IV (E). AUTODOC experts recommend:
Move up the container. The oil starts to drain out of the drainage hole immediately after you have removed the oil filter.
Step 14

Detach the oil filter from the filter cover.
Step 15

Clean the oil filter housing cap. Use all-purpose cleaning spray.
Step 16

Remove the oil filter cover O-ring. Use a flat screwdriver.
Step 17

Install a new O-ring to its mounting seat on the filter cover. Use a flat screwdriver.
Step 18

Lubricate the rubber seal of the new filter with a little amount of fresh oil.
Step 19

Install the new oil filter to the mounting seat on the filter cover.

Please note!
Make sure to install the filter correctly. Don't mix up the sides of the part.
Step 20

Clean the oil filter seat.

Step 21.1

Install a new oil filter housing cover and tighten it.

Step 21.2

Use a drive socket #27. Use a torque wrench. Tighten it to 25 Nm torque.
Step 22

Unscrew the oil filler plug.
Step 23

Remove the oil filler cap.

Step 24

Insert the funnel.
Step 25

Pour new oil into the engine in the amount recommended by the car manufacturer.

Replacement: engine oil and filter – VAUXHALL CORSA Mk IV (E). Tip from AUTODOC experts:
Use the oil recommended by the manufacturer.
Step 26

Check the oil level using the dipstick. Top up oil if necessary.

Please note!
The oil level should be between the Min and Max marks.
Step 27

Install the oil filler cap.

Step 28

Tighten the oil filler cap.

Step 29

Run the engine for a few minutes. After the oil pressure warning light goes out, stop the engine.

Step 30

Check the oil level 5 minutes after the stop of the engine operation using a dipstick and add oil if necessary.

Please note!
The oil level should be between the Min and Max marks.Make sure that the oil filler cap is properly tightened.Check the threaded plug of the drainage hole and the oil filter seal for tightness. If necessary, carefully tighten them up.
Step 31

Remove the fender protection cover.

Step 32

Close the hood.

Replacement: engine oil and filter – VAUXHALL CORSA Mk IV (E). Professionals recommend:
Note that oil pressure warning light, which indicates insufficient pressure in the lubrication system, may be on for a longer time than usual. After a few seconds, the oil will fill all the channels, and the light will go out.To protect the environment from pollution, be sure to dispose of the used filters at special collection points.

Was this manual helpful?

Please rate this manual on a scale from 1 to 5. If you have any questions, feel free to ask us.

Searching for the right tyres?

Find out which tyre and wheel sizes are compatible with the VAUXHALL Corsa Mk4 (E) Hatchback (X15) model.

Browse tyres

How to change fuel filter on VAUXHALL Corsa Mk IV (E) Hatchback (X15) – replacement guide

Free download PDF
1.02 MB
How to change air filter on VAUXHALL Corsa Mk IV (E) Hatchback (X15) – replacement guide

Free download PDF
1.17 MB
How to change front brake pads on VAUXHALL Corsa Mk IV (E) Hatchback (X15) – replacement guide

Free download PDF
1.5 MB
How to change front brake discs on VAUXHALL Corsa Mk IV (E) Hatchback (X15) – replacement guide

Free download PDF
2 MB
How to change front wheel bearing on VAUXHALL Corsa Mk IV (E) Hatchback (X15) – replacement guide

Free download PDF
4.09 MB
How to change spark plugs on VAUXHALL Corsa Mk IV (E) Hatchback (X15) – replacement guide

Free download PDF
1.17 MB

How to change engine oil and filter on VAUXHALL Corsa Mk III (D) Hatchback (S07) – replacement guide

Free download PDF
1.36 MB
How to change engine oil and filter on VAUXHALL Corsa Mk II (C) Hatchback (X01) – replacement guide

Free download PDF
1.36 MB
How to change engine oil and filter on VAUXHALL Corsa Mk I (B) Hatchback (S93) – replacement guide

Free download PDF
1.79 MB
How to change engine oil and filter on VAUXHALL Corsavan Mk III (D) (S07) – replacement guide

Free download PDF
1.36 MB
How to change engine oil and filter on VAUXHALL Corsavan Mk IV (E) Van (X15) – replacement guide

Free download PDF
1.53 MB
How to change engine oil and filter on VAUXHALL Corsavan Mk II (C) (X01) – replacement guide

Free download PDF
1.36 MB

Your profile is your personal assistant.

It can track car expenses, keep a car log and replacement schedule, and save favourite materials, notes and documents

Install the AUTODOC CLUB app!

Your personal car expenses manager, maintenance tips, reminders about upcoming appointments and service intervals, DIY repair instructions – all this on your phone.

Scan

To download the app:

- scan the QR code
- download from App Store
- download from Google Play

Car checks you need to carry out on your car after the winter | AUTODOC tips

3K views

Published on: 23/03/2023
Causes of a worn car boot damper | AUTODOC

3K views

Published on: 04/07/2021
What causes engine misfire? | AUTODOC

5K views

Published on: 10/07/2020
8 bad driving habits | AUTODOC tips

4K views

Published on: 01/04/2021