Recommended replacement interval for the part category Fuel filter : 4 year / 50000 km

Important!

This replacement procedure can be used for:
CITROËN C3 Aircross II (2R_, 2C_) 1.2 PureTech 82 (2RHMRC, 2RHMZB), CITROËN C3 Aircross II (2R_, 2C_) 1.2 PureTech 110 (2RHNZB, 2RHNZW, 2RHNPX, 2RHNPJ), CITROËN C3 Aircross II (2R_, 2C_) 1.2 PureTech 130 (2RHNYH) … View more

The steps may slightly vary depending on the car design.

This video shows the replacement procedure of a similar car part on another vehicle

All the parts you need to replace – Fuel Filter for C3 Aircross II (2R_, 2C_) and other CITROËN models

Fuel filter

        Fuel filter for C3 Aircross II (2R, 2C) Petrol (82 hp)
      
        Fuel filter for C3 Aircross II (2R, 2C) Petrol (110 hp)
      
        Fuel filter for C3 Aircross II (2R, 2C) Petrol (131 hp)

Replacement: fuel filter – CITROËN C3 AIRCROSS II. List of the tools you'll need:

                        All-purpose cleaning spray
                      
                        Fuel line pliers
                      
                        Crow bar
                      
                        Fluid container

Buy tools

Replacement: fuel filter – CITROËN C3 AIRCROSS II. Tip from AUTODOC experts:

Ensure adequate ventilation of the workplace. Fuel vapors are poisonous.
Please note: all work on the car – CITROËN C3 AIRCROSS II – should be done with the engine switched off.

Carry out replacement in the following order:

Step 1

Open the fuel door.

Step 2

Unscrew the fuel filler cap.
Step 3

Lift the car using a jack or place it over an inspection pit.

Step 4

Prepare a container for fluids.
Step 5

Clean the fasteners of the fuel supply lines. Use all-purpose cleaning spray.
Step 6

Remove the fuel lines from the car body.
Step 7

Squeeze the clips and detach the fuel supply lines from the fuel filter housing. Use fuel line pliers. Use a crowbar.

Replacement: fuel filter – CITROËN C3 AIRCROSS II. Tip from AUTODOC experts:
Be careful! Fuel may leak from the filter housing and hoses.
Step 8

Remove the fuel filter. Use a crowbar.
Step 9

Put the old filter cartridge in the container.

Step 10

Install a new fuel filter.

Replacement: fuel filter – CITROËN C3 AIRCROSS II. AUTODOC experts recommend:
Make sure that the fuel filter is positioned correctly. Consider the fuel flow direction mark.During installation, take care to prevent dust and dirt from getting into the fuel filter housing.Take care to only use quality filters.
Step 11

Connect the fuel supply lines to the fuel filter.
Step 12

Install the fuel lines on the car body.
Step 13

Take the fluid container away from under the fuel filter.
Step 14

Lower the car.

Step 15

Tighten the fuel filler cap.

Step 16

Close the fuel door.

Replacement: fuel filter – CITROËN C3 AIRCROSS II. Tip from AUTODOC:
Before starting off, switch the ignition on and off several times. This should be done to activate the fuel pump to make it pump fuel through the fuel system.
Step 17

Run the engine for a few minutes. This is necessary in order to make sure that the component operates properly.

Step 18

Shut off the engine.

Replacement: fuel filter – CITROËN C3 AIRCROSS II. Tip from AUTODOC experts:
To protect the environment from pollution, be sure to dispose of the used filters at special collection points.

Was this manual helpful?

Please rate this manual on a scale from 1 to 5. If you have any questions, feel free to ask us.

Searching for the right tyres?

Find out which tyre and wheel sizes are compatible with the CITROËN C3 Aircross II (2R, 2C) model.

Browse tyres

How to change engine oil and filter on CITROËN C3 Aircross II (2R_, 2C_) – replacement guide

Free download PDF
1.18 MB
How to change air filter on CITROËN C3 Aircross II (2R_, 2C_) – replacement guide

Free download PDF
1.33 MB
How to change front brake pads on CITROËN C3 Aircross II (2R_, 2C_) – replacement guide

Free download PDF
1.29 MB
How to change rear brake pads on CITROËN C3 Aircross II (2R_, 2C_) – replacement guide

Free download PDF
1.59 MB
How to change front brake discs on CITROËN C3 Aircross II (2R_, 2C_) – replacement guide

Free download PDF
1.74 MB
How to change rear brake discs on CITROËN C3 Aircross II (2R_, 2C_) – replacement guide

Free download PDF
2.32 MB

How to change fuel filter on CITROËN C3 Picasso – replacement guide

Free download PDF
942.08 KB
How to change fuel filter on CITROËN C3 II (SC_) – replacement guide

Free download PDF
942.08 KB
How to change fuel filter on CITROËN C3 I Hatchback (FC_, FN_) – replacement guide

Free download PDF
942.08 KB
How to change fuel filter on CITROËN C3 Pluriel (HB_) – replacement guide

Free download PDF
931.84 KB
How to change fuel filter on CITROËN C3 III (SX) – replacement guide

Free download PDF
942.08 KB
How to change fuel filter on CITROËN C3 III Box Body / Hatchback (SX, SY) – replacement guide

Free download PDF
931.84 KB

Your profile is your personal assistant.

It can track car expenses, keep a car log and replacement schedule, and save favourite materials, notes and documents

Install the AUTODOC CLUB app!

Your personal car expenses manager, maintenance tips, reminders about upcoming appointments and service intervals, DIY repair instructions – all this on your phone.

Scan

To download the app:

- scan the QR code
- download from App Store
- download from Google Play

What to do if your check engine light is on | AUTODOC tips

16K views

Published on: 19/08/2020
How to check your head gasket | AUTODOC

9K views

Published on: 13/10/2020
How to remove scratches from car plastic | AUTODOC tips

101K views

Published on: 15/12/2022
How to remove rust | AUTODOC tips

25K views

Published on: 16/09/2021