Important!

This replacement procedure can be used for:
VAUXHALL Astra Mk V (H) Estate (A04) 1.6 (L35), VAUXHALL Astra Mk V (H) Estate (A04) 1.6 (L35), VAUXHALL Astra Mk V (H) Estate (A04) 1.4 (L35) … View more

The steps may slightly vary depending on the car design.

This video shows the replacement procedure of a similar car part on another vehicle

All the parts you need to replace – Springs for Astra Mk V (H) Estate (A04) and other VAUXHALL models

Alternative products

Coil spring

Replacement: coil springs – VAUXHALL ASTRA Mk V (H) Estate. Tools you might need:

                      Wire brush
                    
                      WD-40 spray
                    
                      Brake cleaner 
                    
                      Copper grease 
                    
                      Torque wrench
                    
                      Combination spanner #17
                    
                      Combination spanner #18
                    
                      Drive socket # 18
                    
                      Drive socket # 21
                    
                      HEX bit No.H6
                    
                      HEX bit No.H7
                    
                      Wheel impact socket #17
                    
                      Ratchet wrench
                    
                      Hammer
                    
                      Pliers
                    
                      Water pump pliers
                    
                      Flat Screwdriver
                    
                      Hydraulic strut spring compressor
                    
                      Hydraulic transmission jack
                    
                      Fender cover
                    
                      Wheel chock

Buy tools

Replacement: coil springs – VAUXHALL ASTRA Mk V (H) Estate. AUTODOC experts recommend:

Both coil springs of the front suspension should be replaced simultaneously.
The replacement procedure is identical for the left and right coil springs of the rear suspension.
Please note: all work on the car – VAUXHALL ASTRA Mk V (H) Estate – should be done with the engine switched off.

Carry out replacement in the following order:

Step 1

Open the bonnet.

Step 2

Use a fender protection cover to prevent damaging paintwork and plastic parts of the car.

Step 3

Secure the wheels with chocks.

Step 4

Loosen the wheel mounting bolts. Use wheel impact socket #17.
Step 5

Raise the front of the car and secure on supports.

Step 6

Unscrew the wheel bolts.

AUTODOC recommends:
Warning! To avoid injury, hold the wheel while unscrewing the fastening bolts. VAUXHALL ASTRA Mk V (H) Estate
Step 7

Remove the wheel.
Step 8

Clean the stabiliser link fasteners. Use a wire brush. Use WD-40 spray.
Step 9

Unscrew the fastener connecting the stabilizer link to the shock strut. Use a combination spanner #17. Use a drive socket #18. Use a ratchet wrench.
Step 10

Remove the stabilizer rod.
Step 11

Clean the fasteners connecting the brake hose to the shock strut. Use a wire brush. Use WD-40 spray.
Step 12

Remove the fastener attaching the brake hose to the shock strut. Use pliers.
Step 13

Detach the brake hose from the shock strut.
Step 14

Disconnect the ABS sensor wiring.
Step 15

Clean the fasteners connecting the shock strut to the steering knuckle. Use a wire brush. Use WD-40 spray.
Step 16

Unscrew the fasteners connecting the suspension strut to the steering knuckle. Use a combination spanner #18. Use a drive socket #18. Use a ratchet wrench.
Step 17

Prop up the steering knuckle. Use a hydraulic transmission jack.
Step 18

Remove the shock strut mount cap.
Step 19

Remove the retainer of the shock strut upper mount. Use a flat screwdriver.
Step 20

Remove the fastening bolts.
Step 21

Disconnect the steering knuckle from the shock absorber strut.
Step 22

Remove the suspension strut.
Step 23

Set the shock absorber strut on the spring compressor tool.

Replacement: coil springs – VAUXHALL ASTRA Mk V (H) Estate. Professionals recommend:
Note that when using a spring compressor, spring coils need to be securely gripped, compressing the spring on the opposite sides.Ensure the correct position of the spring in the retainer.Make sure that the spring coils tightly entered the lock handles.
Step 24

Compress the spring.
Step 25

Treat the shock strut rod. Use a wire brush. Use WD-40 spray.
Step 26

Remove the strut piston rod nut. Use HEX No.H6. Use a drive socket #21. Use a ratchet wrench.
Step 27

Remove the top strut mount.

Replacement: suspension strut – VAUXHALL ASTRA Mk V (H) Estate. Tip from AUTODOC experts:
Τhoroughly examine the shock absorber mount, dust boot, bump stop. Replace them if necessary.
Step 28

Remove the shock absorber dust cap and the bump stop.
Step 29

Release the coil spring.
Step 30

Remove the spring.
Step 31

Install the spring on the shock absorber.
Step 32

Compress the spring.
Step 33

Install the mount, the boot and the bump stop on the shock absorber.
Step 34

Tighten the shock strut piston rod nut. Use HEX No.H6. Use a drive socket #21. Use a torque wrench. Tighten it to 65 Nm torque.

Replacement: coil springs – VAUXHALL ASTRA Mk V (H) Estate. Tip:
Check to make sure the spring is positioned correctly. Avoid its misalignment.
Step 35

Treat the shock strut rod. Use copper grease.
Step 36

Decompress the spring.
Step 37

Remove the assembled shock strut.
Step 38

Clean the mounting seats of the shock strut. Use a wire brush. Use WD-40 spray.
Step 39

Install the shock strut into the wheel arch.
Step 40

Fix the shock absorber strut on the steering knuckle.

AUTODOC recommends:
VAUXHALL ASTRA Mk V (H) Estate – To avoid injury, hold the suspension strut while screwing in the fastening bolts.
Step 41

Install the fastening bolts.
Step 42

Install the retainer of the shock strut upper mount. Use water pump pliers.
Step 43

Install the shock strut mount cap.
Step 44

Remove the support from under the steering knuckle.

AUTODOC recommends:
Replacement: coil springs – VAUXHALL ASTRA Mk V (H) Estate. Lower the transmission jack smoothly, without jerks, to avoid damaging components and mechanisms.
Step 45

Tighten the lower fasteners connecting the shock strut to the steering knuckle. Use a combination spanner #18. Use a drive socket #18. Use a torque wrench. Tighten it to 120 Nm torque.
Step 46

Connect the ABS sensor wiring.
Step 47

Fasten the brake hose on the strut.
Step 48

Install the brake hose retaining clip. Use a hammer.
Step 49

Ιnstall the transverse stabilizer link.
Step 50

Tighten the fastener connecting the stabilizer link to the shock strut. Use a combination spanner #17. Use a drive socket #18. Use a torque wrench. Tighten it to 55 Nm torque.
Step 51

Treat the fasteners of the shock strut mount. Treat the steering knuckle fasteners. Use copper grease.
Step 52

Clean the wheel rim mounting seat. Use a wire brush.
Step 53

Treat the surface where the brake disc contacts the wheel rim. Use copper grease.
Step 54

Clean the brake disk surface. Use a brake cleaner.

AUTODOC recommends:
Replacement: coil springs – VAUXHALL ASTRA Mk V (H) Estate. After applying the spray, wait a few minutes.
Step 55

Install the wheel.

AUTODOC recommends:
Important! Hold the wheel while screwing in the fastening bolts. VAUXHALL ASTRA Mk V (H) Estate
Step 56

Screw in the wheel bolts. Use wheel impact socket #17.
Step 57

Lower the car and working in a cross order, tighten the wheel bolts. Use wheel impact socket #17. Use a torque wrench. Tighten it to 110 Nm torque.
Step 58

Remove the jacks and chocks.

Step 59

Remove the fender protection cover.

Step 60

Close the hood.

Was this manual helpful?

Please rate this manual on a scale from 1 to 5. If you have any questions, feel free to ask us.

Need New Tyres?

Find out which tyre and wheel sizes are compatible with the VAUXHALL Astra Mk5 (H) Estate (A04) model

Astra H Estate tyre size

How to change rear shock absorbers on VAUXHALL Astra Mk V (H) Estate (A04) – replacement guide

Free download PDF
1.56 MB
How to change front suspension strut on VAUXHALL Astra Mk V (H) Estate (A04) – replacement guide

Free download PDF
2.92 MB
How to change rear brake pads on VAUXHALL Astra Mk V (H) Estate (A04) – replacement guide

Free download PDF
1.98 MB
How to change front brake pads on VAUXHALL Astra Mk V (H) Estate (A04) – replacement guide

Free download PDF
1.5 MB
How to change front brake discs on VAUXHALL Astra Mk V (H) Estate (A04) – replacement guide

Free download PDF
1.95 MB
How to change rear brake discs on VAUXHALL Astra Mk V (H) Estate (A04) – replacement guide

Free download PDF
1.29 MB

How to change rear coil springs on VAUXHALL Astra Mk V (H) (A04) Hatchback – replacement guide

Free download PDF
1.85 MB
How to change front coil springs on VAUXHALL Astra Mk V (H) (A04) Hatchback – replacement guide

Free download PDF
2.85 MB
How to change rear coil springs on VAUXHALL Astra Mk IV (G) CC (T98) – replacement guide

Free download PDF
1.32 MB
How to change front coil springs on VAUXHALL Astra Mk IV (G) CC (T98) – replacement guide

Free download PDF
2.41 MB
How to change front coil springs on VAUXHALL Astravan Mk V (H) (A04) – replacement guide

Free download PDF
2.85 MB
How to change rear coil springs on VAUXHALL Astra Mk V (H) TwinTop (A04) – replacement guide

Free download PDF
1.85 MB

Unlock your car maintenance assistant!

Track expenses, manage logs, schedule replacements, and more.

Prevent Engine Damage: How to Identify Rocker Cover Gasket Issues and Proper Replacement | AUTODOC

5K views

Published on: 03/12/2020
Top 5 Car Interior Cleaning Mistakes You Should Avoid | AUTODOC Tips

7K views

Published on: 26/05/2022
Petrol or diesel: The engine showdown! | AUTODOC

4K views

Published on: 04/05/2021
Coolant comparison test | AUTODOC

14K views

Published on: 18/02/2021