Recommended replacement interval for the part category Brake pad set : 30000 km

Important!

This replacement procedure can be used for:
SKODA Fabia II Combi (545) 1.2 12V, SKODA Fabia II Combi (545) 1.2, SKODA Fabia II Combi (545) 1.4, SKODA Fabia II Combi (545) 1.6, SKODA Fabia II Combi (545) 1.4 TDI, SKODA Fabia II Combi (545) 1.4 TDI, SKODA Fabia II Combi (545) 1.9 TDI, SKODA Fabia II Combi (545) 1.2, SKODA Fabia II Combi (545) 1.2 TSI, SKODA Fabia II Combi (545) 1.2 TSI, SKODA Fabia II Combi (545) 1.6 TDI, SKODA Fabia II Combi (545) 1.6 TDI, SKODA Fabia II Combi (545) 1.6 TDI, SKODA Fabia II Combi (545) 1.4 TSI RS, SKODA Fabia II Combi (545) 1.2 TDI, SKODA Fabia II Combi (545) 1.2 LPG … View more

The steps may slightly vary depending on the car design.

This video shows the replacement procedure of a similar car part on another vehicle

All the parts you need to replace – Brake Pads for Fabia II Combi (545) and other SKODA models

Alternative products

Brake pad set

Replacement: brake pads – SKODA FABIA Combi. Tools you'll need:

                      Wire brush
                    
                      WD-40 spray
                    
                      Anti-squeal paste
                    
                      Copper grease 
                    
                      HEX bit No.H7.
                    
                      Wheel impact socket #17
                    
                      Ratchet wrench
                    
                      Torque wrench
                    
                      Brake caliper wind back tool
                    
                      Crow bar
                    
                      Fender cover
                    
                      Wheel chock

Buy tools

Replacement: brake pads – SKODA FABIA Combi. AUTODOC recommends:

Perform the replacement of brake pads in complete set for each axis. This provides effective braking.
The replacement procedure is identical for all brake pads on the same axle.
All work should be done with the engine stopped.

Replacement: brake pads – SKODA FABIA Combi. Use the following procedure:

Step 1

Open the bonnet.

Step 2

Use a fender protection cover to prevent damaging paintwork and plastic parts of the car.

Step 3

Unscrew the brake fluid reservoir cap.
Step 4

Secure the wheels with chocks.
Step 5

Loosen the wheel mounting bolts. Use wheel impact socket #17.
Step 6

Raise the front of the car and secure on supports.

Step 7

Unscrew the wheel bolts.

Replacement: brake pads – SKODA FABIA Combi. Tip:
To avoid injury, hold up the wheel when unscrewing the bolts.
Step 8

Remove the wheel.
Step 9

Remove the dust boot caps of the brake caliper guide pins. Use a crowbar.
Step 10

Unscrew the brake caliper fastening. Use HEX No.H7. Use a ratchet wrench.
Step 11

Spread the brake pads. Use a crowbar.
Step 12

Remove the brake caliper.

Replacement: brake pads – SKODA FABIA Combi. AUTODOC experts recommend:
Tie the caliper to the suspension or to the body with a wire without disconnecting from the brake hose to prevent depressurization of the brake system.Make sure that the brake caliper is not hanging on the brake hose.Don't press the brake pedal after the brake caliper has been removed. As a result, the piston can fall out from the brake cylinder, and brake fluid leakage and depressurization of the system may occur.
Step 13

Remove the brake pads.
Step 14

Treat the brake caliper piston. Use WD-40 spray.
Step 15

Press in the brake caliper piston. Use brake caliper wind back tool.
Step 16

Clean the brake caliper bracket from dirt and dust. Use a wire brush.

Step 17

Treat the brake caliper bracket where it contacts the brake pads. Use anti-squeal paste.

Replacement: brake pads – SKODA FABIA Combi. Tip from AUTODOC:
Make sure the disc surface is clean before installing the pads.
Step 18

Install new brake pads.

Replacement: brake pads – SKODA FABIA Combi. Professionals recommend:
Make sure the pads are installed with linings facing the disc.
Step 19

Install the brake caliper and fix it. Use HEX No.H7. Use a torque wrench. Tighten it to 30 Nm torque.
Step 20

Install the dust boot caps of the brake caliper guide pins.
Step 21

Clean the brake disk surface. Use a wire brush. Treat the surface where the brake disc contacts the wheel rim. Use copper grease.
Step 22

Install the wheel.

AUTODOC recommends:
Important! Hold the wheel while screwing in the fastening bolts. SKODA FABIA Combi
Step 23

Screw in the wheel bolts. Use wheel impact socket #17.
Step 24

Lower the car and working in a cross order, tighten the wheel bolts. Use a torque wrench. Tighten it to 120 Nm torque.

Replacement: brake pads – SKODA FABIA Combi. AUTODOC recommends:
Check the brake fluid level in the expansion tank and refill if necessary.
Step 25

Tighten the brake fluid reservoir cap.

AUTODOC recommends:
SKODA FABIA Combi – Without starting the engine, press the brake pedal several times until it feels firm.
Step 26

Remove the fender protection cover.

Step 27

Close the hood.

Step 28

Remove the jacks and chocks.

Replacement: brake pads – SKODA FABIA Combi. Tip from AUTODOC experts:
Slow down smoothly for first 150-200 km after the brake pads replacement. Avoid unneccessary and sharp braking to a stop.

Was this manual helpful?

Please rate this manual on a scale from 1 to 5. If you have any questions, feel free to ask us.

Need New Tyres?

Find out which tyre and wheel sizes are compatible with the SKODA Fabia II Combi (545) model

SKODA FABIA Combi tyre size

How to change front brake discs on SKODA Fabia II Combi (545) – replacement guide

Free download PDF
1.53 MB
How to change front brake hose on SKODA Fabia II Combi (545) – replacement guide

Free download PDF
2.56 MB
How to change front brake caliper on SKODA Fabia II Combi (545) – replacement guide

Free download PDF
2.02 MB
How to change rear brake caliper on SKODA Fabia II Combi (545) – replacement guide

Free download PDF
2.01 MB
How to change rear brake shoes on SKODA Fabia II Combi (545) – replacement guide

Free download PDF
1.91 MB
How to change rear brake pads on SKODA Fabia II Combi (545) – replacement guide

Free download PDF
1.37 MB

How to change rear brake pads on SKODA Fabia II Hatchback (542) – replacement guide

Free download PDF
1.37 MB
How to change front brake pads on SKODA Fabia II Hatchback (542) – replacement guide

Free download PDF
2.26 MB
How to change front brake pads on SKODA Fabia I Hatchback (6Y2) – replacement guide

Free download PDF
2.26 MB
How to change rear brake pads on SKODA FABIA (6Y2) – replacement guide

Free download PDF
1.37 MB
How to change front brake pads on SKODA FABIA (NJ3) – replacement guide

Free download PDF
1.57 MB
How to change rear brake pads on SKODA FABIA (NJ3) – replacement guide

Free download PDF
1.53 MB

Unlock your car maintenance assistant!

Track expenses, manage logs, schedule replacements, and more.

DIY vehicle AC compressor restoration

581K views

Published on: 28/11/2024
What causes engine misfire? | AUTODOC

6K views

Published on: 10/07/2020
How to Prevent Premature Wear on Your Car Boot Damper | AUTODOC

4K views

Published on: 04/07/2021
Initial Car Inspection: What to Check Before You Buy

5K views

Published on: 24/10/2020