How to carry out replacement: Brake Discs 1.2 16V (F08, F68) Opel Corsa B
Disclaimer
Change Opel Corsa B 1.7 DTI 16V (F08, F68) Brake Discs yourself – manuals and video tutorials

How to change front brake discs on VAUXHALL Corsa Mk II (C) Hatchback (X01) – replacement guide

downloads: 3
Views: 26
Download your free tutorial and fix VAUXHALL Corsa Mk II (C) Hatchback (X01) 1.7 DI 16V (F08, F68) problems yourself Download for free 1.95 MB Brake Discs for Opel Corsa B Shop now
Leave a comment Open in a new tab
When to replace the Brake Discs on your VAUXHALL CORSA
Recommended replacement interval for the part category Brake disc : 50000 km
Important!
This replacement procedure can be used for:
VAUXHALL Corsa Mk II (C) Hatchback (X01) 1.7 CDTI 16V (F08, F68) … View more

The steps may slightly vary depending on the car design.

This video shows the replacement procedure of a similar car part on another vehicle

All the parts you need to replace – Brake Discs for Corsa Mk II (C) Hatchback (X01) and other VAUXHALL models
Alternative products
How to change Brake disc on Opel Corsa B 1.2 16V (F08, F68) – step-by-step instructions for straightforward car repair Brake disc
Tools
Replacement: brake discs – VAUXHALL CORSA Mk II (C) (W5L, F08). List of the tools you'll need:
Wire brush
Nylon cleaning brush
WD-40 spray
Brake cleaner
Copper grease
Drive socket # 18
HEX bit No.H5.
HEX bit No.H7.
Wheel impact socket #17
Ratchet wrench
Torque wrench
Brake caliper wind back tool
Flat Screwdriver
Crow bar
Pliers
Wheel chock
Buy tools
Replacement: brake discs – VAUXHALL CORSA Mk II (C) (W5L, F08). AUTODOC recommends:
  • Replace the brake disks on the car VAUXHALL CORSA Mk II (C) (W5L, F08) in complete set for each axis. Regardless of the state of components. This will ensure even braking.
  • The replacement procedure is identical for both brake disks on the same axle.
  • When changing the brake discs, always replace the brake pads.
  • All work should be done with the engine stopped.
Replacement: brake discs – VAUXHALL CORSA Mk II (C) (W5L, F08). Use the following procedure:
  1. Step 1
    Open the bonnet. Unscrew the brake fluid reservoir cap.
    Step 2
    How to change Brake Discs on Opel Corsa B 2000 - free PDF and video manuals
    Secure the wheels with chocks.
  2. Step 3
    How to replace VAUXHALL Corsa Mk II (C) Hatchback (X01) 1.2 16V (F08, F68) 2001 Brake Discs - step-by-step manuals and video guides
    Loosen the wheel mounting bolts. Use wheel impact socket #17.
  3. Step 4
    Raise the front of the car and secure on supports.
    Step 5
    Opel Corsa B 1.2 Twinport (F08, F68) 2002 Brake Discs replacement: free workshop manuals
    Unscrew the wheel bolts.
    AUTODOC recommends:
    Important! Hold the wheel while unscrewing the fastening bolts. VAUXHALL CORSA Mk II (C) (W5L, F08)
  4. Step 6
    Changing Brake Discs on VAUXHALL Corsa Mk II (C) Hatchback (X01) 1.4 Twinport (F08, F68) 2003 by yourself
    Remove the wheel.
  5. Step 7
    How to remove VAUXHALL CORSA 1.8 16V (F08, F68) 2004 Brake Discs - online easy-to-follow instructions
    Detach the brake caliper retaining spring. Use a flat screwdriver.
  6. Step 8
    How to replace Brake Discs on VAUXHALL Corsa Mk II (C) Hatchback (X01) 2005: download PDF manuals and video instructions
    Remove the dust boot caps of the brake caliper guide pins. Use a flat screwdriver.
  7. Step 9
    Clean the brake caliper fasteners. Use a wire brush. Use WD-40 spray.
    Step 10
    How hard is it to do yourself: Brake Discs replacement on Opel Corsa B 1.3 CDTI 16V (F08, F68) 2006 - download illustrated guide
    Unscrew the brake caliper fastening. Use HEX No.H7. Use a ratchet wrench.
  8. Step 11
    Need to know how to renew Brake Discs on VAUXHALL CORSA 2000? This free workshop manual will help you to do it yourself
    Spread the brake pads. Use a crowbar.
  9. Step 12
    Changing of Brake Discs on Opel Corsa B 2001 won't be an issue if you follow this illustrated step-by-step guide
    Remove the brake caliper.
    Replacement: brake discs – VAUXHALL CORSA Mk II (C) (W5L, F08). Professionals recommend:
    Tie the caliper to the suspension or to the body with a wire without disconnecting from the brake hose to prevent depressurization of the brake system.Make sure that the brake caliper is not hanging on the brake hose.Don't press the brake pedal after the brake caliper has been removed. As a result, the piston can fall out from the brake cylinder, and brake fluid leakage and depressurization of the system may occur. Check the brake caliper bracket, brake caliper guide pins and boots. Clean them. Replace, if necessary.
  10. Step 13
    VAUXHALL CORSA 1.7 DTI 16V (F08, F68) Brake Discs replacement: online guides and video tutorials
    Remove the brake pads.
  11. Step 14
    Replacing Brake Discs on Opel Corsa B 2003 1.2 16V (F08, F68) by yourself
    Clean the brake caliper bracket fasteners. Use a wire brush. Use WD-40 spray.
  12. Step 15
    Corsa Mk II (C) Hatchback (X01) 1.8 16V (F08, F68) 2004 Brake Discs DIY replacement workshop manual
    Unscrew the caliper bracket fastening. Use a drive socket #18. Use a ratchet wrench.
  13. Step 16
    Remove the fastening bolts (2 pieces).
    Step 17
    How to change Brake Discs on VAUXHALL Corsa Mk II (C) Hatchback (X01) 2005 - tips and tricks
    Remove the caliper bracket.
  14. Step 18
    Step-by-step recommendations for DIY replacement Opel Corsa B 2006 1.8 16V (F08, F68) Brake Discs
    Clean the brake disc fastener. Use a wire brush. Use WD-40 spray.
  15. Step 19
    DIY replacement of Brake Discs on VAUXHALL Corsa Mk II (C) Hatchback (X01) 1.0 12V (F08, F68) 2000 is not an issue anymore with our step-by-step tutorial
    Unscrew the brake disc fastening. Use HEX No.H5. Use a ratchet wrench.
  16. Step 20
    How to change Brake Discs on Opel Corsa B 2000 - free PDF and video manuals
    Remove the brake disc.
  17. Step 21
    How to replace VAUXHALL Corsa Mk II (C) Hatchback (X01) 1.2 16V (F08, F68) 2001 Brake Discs - step-by-step manuals and video guides
    Clean the hub. Use a wire brush. Treat the contacting surface. Use copper grease.
  18. Step 22
    Opel Corsa B 1.2 Twinport (F08, F68) 2002 Brake Discs replacement: free workshop manuals
    Install the brake disc.
  19. Step 23
    Changing Brake Discs on VAUXHALL Corsa Mk II (C) Hatchback (X01) 1.4 Twinport (F08, F68) 2003 by yourself
    Tighten the brake disc fastening. Use HEX No.H5. Use a torque wrench. Tighten it to 7 Nm torque.
  20. Step 24
    How to remove VAUXHALL CORSA 1.8 16V (F08, F68) 2004 Brake Discs - online easy-to-follow instructions
    Clean the brake caliper bracket from dirt and dust. Use a wire brush. Use a brake cleaner.
    AUTODOC recommends:
    Replacement: brake discs – VAUXHALL CORSA Mk II (C) (W5L, F08). After applying the spray, wait a few minutes.
Was this manual helpful?
Please rate this manual on a scale from 1 to 5. If you have any questions, feel free to ask us.
Users voted – 0
Need New Tyres?

Find out which tyre and wheel sizes are compatible with the VAUXHALL Corsa Mk2 (C) Hatchback (X01) model

Opel Corsa B tyre size

Popular maintenance tutorials for Opel Corsa B

More manuals for Opel Corsa B

Complete guides for changing the Brake rotors on different VAUXHALL CORSA models

Unlock your car maintenance assistant!

Track expenses, manage logs, schedule replacements, and more.

DIY VAUXHALL Corsa Mk II (C) Hatchback (X01) Brake Discs replacement - online guide
Tips & tricks for your VAUXHALL Corsa Mk II (C) Hatchback (X01)
View more
  • How to change Brake rotors on VAUXHALL Corsa Mk II (C) Hatchback (X01) 1.0 12V (F08, F68) - replacement tricks
    5 mistakes made when washing the engine | AUTODOC tips
    32K views
    Published on: 22/04/2021
  • Changing Brake disc Opel Corsa B 1.2 16V (F08, F68) - Replacement Tips
    Revitalize Your Car Interior: DIY Steering Wheel Cover with AUTODOC Tips
    7K views
    Published on: 14/03/2024
  • Maintenance Hacks - VAUXHALL Corsa Mk II (C) Hatchback (X01) 1.2 Twinport (F08, F68) Rotors replacement guide
    5 Essential Tips for beginner drivers: Avoid Common Mistakes
    4K views
    Published on: 31/01/2023
  • Replace Disc brakes on Opel Corsa B - free video tips
    How to tell if a tie rod is faulty
    7K views
    Published on: 24/07/2025

Most commonly replaced car parts on VAUXHALL CORSA

Professional manuals for the most common VAUXHALL models

ОЕ number
Autodoc CLUB App icon
Time to replace parts? Get even better deals in our Shop app.
VAUXHALL Corsa Mk II (C) Hatchback (X01) Brake Discs replace by yourself - Scan QR-code and download AUTODOC CLUB app
SCAN ME