
Disclaimer
How to change front brake discs on SKODA Fabia IV Hatchback (PJ3) – replacement guide
downloads:
2
Views:
13

Recommended replacement interval for the part category Brake disc : 50000 km
Important!
This replacement procedure can be used for:
SKODA Fabia IV Hatchback (PJ3) 1.0 MPI … View more
The steps may slightly vary depending on the car design.
SKODA Fabia IV Hatchback (PJ3) 1.0 MPI … View more
The steps may slightly vary depending on the car design.
This video shows the replacement procedure of a similar car part on another vehicle
All the parts you need to replace – Brake Discs for Fabia IV Hatchback (PJ3) and other SKODA models
Brake disc
Alternative products

Wire brush
WD-40 spray
Brake cleaner
Copper grease
HEX bit no.H7.
Wheel impact socket #17
Brake caliper wind back tool
Ratchet wrench
Torque wrench
Phillips screwdriver
Crow bar
Wheel chock
Replacement: brake discs – SKODA Fabia IV Schrägheck (PJ3). Professionals recommend:
- Replace the brake disks on the car SKODA Fabia IV Schrägheck (PJ3) in complete set for each axis. Regardless of the state of components. This will ensure even braking.
- The replacement procedure is identical for both brake disks on the same axle.
- When changing the brake discs, always replace the brake pads.
- All work should be done with the engine stopped.
Replacement: brake discs – SKODA Fabia IV Schrägheck (PJ3). Use the following procedure:
- Step 1Open the bonnet. Unscrew the brake fluid reservoir cap.Step 2Secure the wheels with chocks.
- Step 3Loosen the wheel mounting bolts. Use wheel impact socket #17.
- Step 4Raise the front of the car and secure on supports.Step 5Unscrew the wheel bolts.Replacement: brake discs – SKODA Fabia IV Schrägheck (PJ3). Tip:To avoid injury, hold up the wheel when unscrewing the bolts.
- Step 6Remove the wheel.
- Step 7Remove the dust boot caps of the brake caliper guide pins. Use a crowbar.
- Step 8Unscrew the brake caliper fastening. Use HEX No.H7. Use a ratchet wrench.
- Step 9Spread the brake pads. Use a crowbar.
- Step 10Remove the brake caliper.Replacement: brake discs – SKODA Fabia IV Schrägheck (PJ3). AUTODOC experts recommend:Tie the caliper to the suspension or to the body with a wire without disconnecting from the brake hose to prevent depressurization of the brake system.Make sure that the brake caliper is not hanging on the brake hose.Don't press the brake pedal after the brake caliper has been removed. As a result, the piston can fall out from the brake cylinder, and brake fluid leakage and depressurization of the system may occur. Check the brake caliper bracket, brake caliper guide pins and boots. Clean them. Replace, if necessary.
- Step 11Remove the brake pads. Use a crowbar.
- Step 12Clean the brake disc fasteners. Use a wire brush. Use WD-40 spray.
- Step 13Unscrew the brake disc fastening. Use a Phillips screwdriver.
- Step 14Remove the brake disc.
- Step 15Clean the hub. Use a wire brush. Treat the contacting surface. Use copper grease.
- Step 16Install the brake disc.Step 17Tighten the brake disc fastening. Use a Phillips screwdriver. Use a torque wrench. Tighten it to 4 Nm torque.
- Step 18Treat the brake caliper piston. Use a brake cleaner.AUTODOC recommends:Replacement: brake discs – SKODA Fabia IV Schrägheck (PJ3). After applying the spray, wait a few minutes.
Was this manual helpful?
Please rate this manual on a scale from 1 to 5. If you have any questions, feel free to ask us.
Users voted – 0
Need New Tyres?
Find out which tyre and wheel sizes are compatible with the SKODA Fabia IV Hatchback (PJ3) model
Popular maintenance tutorials for SKODA Fabia IV Schrägheck (PJ3)
Complete guides for changing the Brake rotors on different SKODA FABIA models
Unlock your car maintenance assistant!
Track expenses, manage logs, schedule replacements, and more.
Tips & tricks for your SKODA Fabia IV Hatchback (PJ3)
View more
- DIY starter repair | AUTODOC tips
- How to Use Sandblasting Equipment: Step-by-Step Guide | AUTODOC Tips
- Top 5 possible reasons your car is shaking or vibrating
- How to tighten cylinder head bolts
Most commonly replaced car parts on SKODA FABIA
Time to replace parts? Get even better deals in our Shop app.

SCAN ME