Recommended replacement interval for the part category Brake pad set : 30000 km

Important!

This replacement procedure can be used for:
NISSAN MICRA II (K11) 1.0 i 16V, NISSAN MICRA II (K11) 1.5 D, NISSAN MICRA II (K11) 1.0 i 16V, NISSAN MICRA II (K11) 1.4 i 16V … View more

The steps may slightly vary depending on the car design.

How to change front brake discs and front brake pads set on NISSAN MICRA 2 [TUTORIAL AUTODOC]

All the parts you need to replace – Brake Pads for MICRA II (K11) and other NISSAN models

Brake pad set

        Brake pad set for NISSAN MICRA II (K11) 1.0 i 16V Petrol (54 hp)
      
        Brake pad set for NISSAN MICRA II (K11) 1.5 D Diesel (57 hp)
      
        Brake pad set for NISSAN MICRA II (K11) 1.0 i 16V Petrol (60 hp)
      
        Brake pad set for NISSAN MICRA II (K11) 1.4 i 16V Petrol (82 hp)

Replacement: brake pads – Nissan Micra K11. List of the tools you'll need:

                        Wire brush
                      
                        WD-40 spray
                      
                        Brake cleaner 
                      
                        Copper grease 
                      
                        Anti-squeal paste
                      
                        Drive socket # 12
                      
                        Wheel impact socket #19
                      
                        Brake caliper wind back tool
                      
                        Ratchet wrench
                      
                        Torque wrench
                      
                        Crow bar
                      
                        Wheel chock

Buy tools

Replacement: brake pads – Nissan Micra K11. AUTODOC experts recommend:

Perform the replacement of brake pads in complete set for each axis. This provides effective braking.
The replacement procedure is identical for all brake pads on the same axle.
Please note: all work on the car – Nissan Micra K11 – should be done with the engine switched off.

Carry out replacement in the following order:

Step 1

Open the bonnet. Unscrew the brake fluid reservoir cap.
Step 2

Secure the wheels with chocks.
Step 3

Loosen the wheel mounting bolts. Use wheel impact socket #19.
Step 4

Raise the front of the car and secure on supports.
Step 5

Unscrew the wheel bolts.

AUTODOC recommends:
Warning! To avoid injury, hold the wheel while unscrewing the fastening bolts. Nissan Micra K11
Step 6

Remove the wheel.
Step 7

Clean the brake caliper fasteners. Use a wire brush. Use WD-40 spray.

Step 8

Unscrew the brake caliper fastening. Use a drive socket #12. Use a ratchet wrench.
Step 9

Spread the brake pads. Use a crowbar.

Step 10

Remove the brake caliper.

Replacement: brake pads – Nissan Micra K11. Professionals recommend:
Tie the caliper to the suspension or to the body with a wire without disconnecting from the brake hose to prevent depressurization of the brake system.Make sure that the brake caliper is not hanging on the brake hose.Don't press the brake pedal after the brake caliper has been removed. As a result, the piston can fall out from the brake cylinder, and brake fluid leakage and depressurization of the system may occur. Check the brake caliper bracket, brake caliper guide pins and boots. Clean them. Replace, if necessary.
Step 11

Remove the brake pads.

Replacement: brake pads – Nissan Micra K11. Tip from AUTODOC:
Measure the brake disc thickness. Upon reaching the wear limit the part must be replaced.
Step 12

Remove the retaining springs of the brake pads.

Step 13

Clean the brake caliper bracket from dirt and dust. Use a wire brush. Use a brake cleaner.

AUTODOC recommends:
Replacement: brake pads – Nissan Micra K11. After applying the spray, wait a few minutes.
Step 14

Treat the brake pads in the area where their surface comes into contact with the brake caliper bracket. Use anti-squeal paste.

Replacement: brake pads – Nissan Micra K11. AUTODOC experts recommend:
Make sure the disc surface is clean before installing the pads.
Step 15

Install the retaining springs of the brake pads.

Step 16

Install new brake pads.

Replacement: brake pads – Nissan Micra K11. AUTODOC recommends:
Make sure the pads are installed with linings facing the disc.
Step 17

Treat the brake caliper piston. Use a brake cleaner.

AUTODOC recommends:
Replacement: brake pads – Nissan Micra K11. After applying the spray, wait a few minutes.
Step 18

Press in the brake caliper piston. Use brake caliper wind back tool.
Step 19.1

Install the brake caliper and fix it.

Step 19.2

Use a drive socket #12. Use a torque wrench. Tighten it to 30 Nm torque.
Step 20

Treat the surface where the brake disc contacts the wheel rim. Use copper grease.
Step 21

Clean the brake disk surface. Use a brake cleaner.

Replacement: brake pads – Nissan Micra K11. Tip from AUTODOC:
After applying the spray, wait a few minutes.
Step 22

Install the wheel.

AUTODOC recommends:
Warning! To avoid injury, hold the wheel while screwing in the fastening bolts on the car. Nissan Micra K11
Step 23

Screw in the wheel bolts. Use wheel impact socket #19.
Step 24

Lower the car and working in a cross order, tighten the wheel bolts. Use wheel impact socket #19. Use a torque wrench. Tighten it to 110 Nm torque.
Step 25

Remove the jacks and chocks.

Replacement: brake pads – Nissan Micra K11. Tip from AUTODOC:
Check the brake fluid level in the expansion tank and refill if necessary.
Step 26

Tighten the brake fluid reservoir cap.

Replacement: brake pads – Nissan Micra K11. AUTODOC recommends:
Without starting the engine, press the brake pedal several times until you feel significant resistance.
Step 27

Close the hood.

Replacement: brake pads – Nissan Micra K11. Tip from AUTODOC experts:
Slow down smoothly for first 150-200 km after the brake pads replacement. Avoid unneccessary and sharp braking to a stop.

Was this manual helpful?

Please rate this manual on a scale from 1 to 5. If you have any questions, feel free to ask us.

How to change front brake discs on Nissan Micra K11 – replacement guide

Free download PDF
1.89 MB
How to change front wheel bearing on Nissan Micra K11 – replacement guide

Free download PDF
2.46 MB
How to change engine oil and filter on Nissan Micra K11 – replacement guide

Free download PDF
1.46 MB
How to change front suspension strut on Nissan Micra K11 – replacement guide

Free download PDF
2.46 MB
How to change air filter on NISSAN MICRA II (K11) – replacement guide

Free download PDF
849.92 KB
How to change track rod end on Nissan Micra K11 – replacement guide

Free download PDF
1.27 MB

How to change front brake discs on Nissan Micra K12 – replacement guide

Free download PDF
2.13 MB
How to change front brake pads on Nissan Micra K12 – replacement guide

Free download PDF
1.56 MB
How to change rear brake pads on NISSAN MICRA III (K12) – replacement guide

Free download PDF
1.49 MB
How to change front brake pads on NISSAN Micra C+C III (K12) – replacement guide

Free download PDF
1.48 MB
How to change rear brake pads on NISSAN Micra C+C III (K12) – replacement guide

Free download PDF
1.49 MB
How to change brake pads on a car – replacement tutorial

Universal

Free download PDF
2.84 MB

Your profile is your personal assistant.

It can track car expenses, keep a car log and replacement schedule, and save favourite materials, notes and documents

Install the AUTODOC CLUB app!

Your personal car expenses manager, maintenance tips, reminders about upcoming appointments and service intervals, DIY repair instructions – all this on your phone.

Scan

To download the app:

- scan the QR code
- download from App Store
- download from Google Play

TOP 5 mistakes during DIY oil change | AUTODOC tips

33K views

Published on: 17/06/2021
How to replace the suspension on a BMW E30 Turbo | SUPERCAR AUTODOC

1K views

Published on: 04/03/2021
Things you should never do with an automatic transmission | AUTODOC tips

6K views

Published on: 26/01/2021
TOP 5 mistakes when replacing shock absorbers | AUTODOC tips

8K views

Published on: 15/06/2023