Recommended replacement interval for the part category Brake disc : 50000 km

Important!

This replacement procedure can be used for:
NISSAN MICRA II (K11) 1.0 i 16V, NISSAN MICRA II (K11) 1.5 D, NISSAN MICRA II (K11) 1.0 i 16V, NISSAN MICRA II (K11) 1.4 i 16V … View more

The steps may slightly vary depending on the car design.

How to change front brake discs and front brake pads set on NISSAN MICRA 2 [TUTORIAL AUTODOC]

All the parts you need to replace – Brake Discs for MICRA II (K11) and other NISSAN models

Brake disc

        Brake disc for NISSAN MICRA II (K11) 1.0 i 16V Petrol (54 hp)
      
        Brake disc for NISSAN MICRA II (K11) 1.5 D Diesel (57 hp)
      
        Brake disc for NISSAN MICRA II (K11) 1.0 i 16V Petrol (60 hp)
      
        Brake disc for NISSAN MICRA II (K11) 1.4 i 16V Petrol (82 hp)

Replacement: brake discs – Nissan Micra K11. Tools you might need:

                        Wire brush
                      
                        WD-40 spray
                      
                        Brake cleaner 
                      
                        Copper grease 
                      
                        Brake caliper guide pins grease
                      
                        Drive socket # 12
                      
                        Drive socket # 17
                      
                        Wheel impact socket #19
                      
                        Brake caliper wind back tool
                      
                        Ratchet wrench
                      
                        Torque wrench
                      
                        Crow bar
                      
                        Wheel chock

Buy tools

AUTODOC recommends:

Replace the brake disks on the car Nissan Micra K11 in complete set for each axis. Regardless of the state of components. This will ensure even braking.
The replacement procedure is identical for both brake disks on the same axle.
When changing the brake discs, always replace the brake pads.
Please note: all work on the car – Nissan Micra K11 – should be done with the engine switched off.

Carry out replacement in the following order:

Step 1

Open the bonnet. Unscrew the brake fluid reservoir cap.
Step 2

Secure the wheels with chocks.
Step 3

Loosen the wheel mounting bolts. Use wheel impact socket #19.
Step 4

Raise the front of the car and secure on supports.
Step 5

Unscrew the wheel bolts.

AUTODOC recommends:
Warning! To avoid injury, hold the wheel while unscrewing the fastening bolts. Nissan Micra K11
Step 6

Remove the wheel.
Step 7

Clean the brake caliper fasteners. Use a wire brush. Use WD-40 spray.

Step 8

Unscrew the brake caliper fastening. Use a drive socket #12. Use a ratchet wrench.
Step 9

Spread the brake pads. Use a crowbar.

Step 10

Remove the brake caliper.

Replacement: brake discs – Nissan Micra K11. Tip:
Tie the caliper to the suspension or to the body with a wire without disconnecting from the brake hose to prevent depressurization of the brake system.Make sure that the brake caliper is not hanging on the brake hose.Don't press the brake pedal after the brake caliper has been removed. As a result, the piston can fall out from the brake cylinder, and brake fluid leakage and depressurization of the system may occur. Check the brake caliper bracket, brake caliper guide pins and boots. Clean them. Replace, if necessary.
Step 11

Remove the brake pads.
Step 12

Remove the retaining springs of the brake pads.

Step 13

Clean the brake caliper bracket fasteners. Use a wire brush. Use WD-40 spray.
Step 14

Unscrew the caliper bracket fastening. Use a drive socket #17. Use a ratchet wrench.
Step 15

Remove the caliper bracket.
Step 16

Remove the brake disc.
Step 17

Clean the hub. Use a wire brush. Treat the contacting surface. Use copper grease.
Step 18

Install the brake disc.
Step 19

Clean the brake caliper bracket from dirt and dust. Use a wire brush. Use a brake cleaner.

AUTODOC recommends:
Replacement: brake discs – Nissan Micra K11. After applying the spray, wait a few minutes.
Step 20

Remove the guide pins from the brake caliper.

Step 21

Clean the brake caliper guide pins.
Step 22

Treat the brake caliper guide pins. Use the brake caliper guide pin grease.
Step 23

Screw in the guide pins.

Step 24

Install the brake caliper bracket.
Step 25

Tighten the brake caliper bracket. Use a drive socket #17. Use a torque wrench. Tighten it to 115 Nm torque.

Step 26

Install the retaining springs of the brake pads.

Step 27

Install the brake pads.
Step 28

Treat the brake caliper piston. Use a brake cleaner.

Replacement: brake discs – Nissan Micra K11. Tip from AUTODOC experts:
After applying the spray, wait a few minutes.
Step 29

Press in the brake caliper piston. Use brake caliper wind back tool.
Step 30.1

Install the brake caliper and fix it.

Step 30.2

Use a drive socket #12. Use a torque wrench. Tighten it to 30 Nm torque.
Step 31

Treat the surface where the brake disc contacts the wheel rim. Use copper grease.
Step 32

Clean the brake disk surface. Use a brake cleaner.

AUTODOC recommends:
Replacement: brake discs – Nissan Micra K11. After applying the spray, wait a few minutes.
Step 33

Install the wheel.

AUTODOC recommends:
Important! Hold the wheel while screwing in the fastening bolts. Nissan Micra K11
Step 34

Screw in the wheel bolts. Use wheel impact socket #19.
Step 35

Lower the car and working in a cross order, tighten the wheel bolts. Use wheel impact socket #19. Use a torque wrench. Tighten it to 110 Nm torque.
Step 36

Remove the jacks and chocks.

Replacement: brake discs – Nissan Micra K11. AUTODOC recommends:
Check the brake fluid level in the expansion tank and refill if necessary.
Step 37

Tighten the brake fluid reservoir cap.

Replacement: brake discs – Nissan Micra K11. Tip:
Without starting the engine, press the brake pedal several times until you feel significant resistance.
Step 38

Close the hood.

Was this manual helpful?

Please rate this manual on a scale from 1 to 5. If you have any questions, feel free to ask us.

How to change front brake pads on Nissan Micra K11 – replacement guide

Free download PDF
1.56 MB
How to change front wheel bearing on Nissan Micra K11 – replacement guide

Free download PDF
2.46 MB
How to change engine oil and filter on Nissan Micra K11 – replacement guide

Free download PDF
1.46 MB
How to change front suspension strut on Nissan Micra K11 – replacement guide

Free download PDF
2.46 MB
How to change air filter on NISSAN MICRA II (K11) – replacement guide

Free download PDF
849.92 KB
How to change track rod end on Nissan Micra K11 – replacement guide

Free download PDF
1.27 MB

How to change front brake discs on Nissan Micra K12 – replacement guide

Free download PDF
2.13 MB
How to change front brake pads on Nissan Micra K12 – replacement guide

Free download PDF
1.56 MB
How to change front brake discs on NISSAN MICRA V (K14) – replacement guide

Free download PDF
2.03 MB
How to change front brake discs on NISSAN Micra C+C III (K12) – replacement guide

Free download PDF
2.01 MB
How to change brake discs on a car – replacement tutorial

Universal

Free download PDF
2.92 MB
How to change front brake discs on Nissan Qashqai J10 – replacement guide

Free download PDF
1.97 MB

Your profile is your personal assistant.

It can track car expenses, keep a car log and replacement schedule, and save favourite materials, notes and documents

Install the AUTODOC CLUB app!

Your personal car expenses manager, maintenance tips, reminders about upcoming appointments and service intervals, DIY repair instructions – all this on your phone.

Scan

To download the app:

- scan the QR code
- download from App Store
- download from Google Play

How to check your head gasket | AUTODOC

9K views

Published on: 13/10/2020
What to do if the ABS light comes on | AUTODOC tips

6K views

Published on: 11/03/2021
3 things to know before buying summer tyres | AUTODOC tips

3K views

Published on: 18/05/2023
How to repair a bumper yourself | AUTODOC tips

9K views

Published on: 01/06/2023