When to replace the Brake Pads on your VOLVO V50
Recommended replacement interval for the part category Brake pad set : 30000 km
Important!
This replacement procedure can be used for:
VOLVO V50 (545) 1.6 D, VOLVO V50 (545) D4, VOLVO V50 (545) D3, VOLVO V50 (545) 2.4, VOLVO V50 (545) 2.4, VOLVO V50 (545) T5, VOLVO V50 (545) 2.0 D, VOLVO V50 (545) T5 AWD, VOLVO V50 (545) 1.8, VOLVO V50 (545) 1.6, VOLVO V50 (545) 2.0, VOLVO V50 (545) D5, VOLVO V50 (545) T5, VOLVO V50 (545) T5 AWD, VOLVO V50 (545) 1.8 FlexFuel, VOLVO V50 (545) 2.4 AWD, VOLVO V50 (545) 2.4 Tdi, VOLVO V50 (545) D2, VOLVO V50 (545) 2.0 FlexFuel, VOLVO V50 (545) 2.0 CDI, VOLVO V50 (545) 2.0 D4, VOLVO V50 (545) 1.8 BiFuel View more

The steps may slightly vary depending on the car design.

How to change rear brake pads / rear brake pad set on VOLVO V50 1 (P12) [TUTORIAL AUTODOC]

video
All the parts you need to replace – Brake Pads for V50 (545) and other VOLVO models
Tools
Replacement: brake pads – Volvo V50 MW. List of the tools you'll need:
Brake cleaner
Anti-squeal paste
Copper grease
HEX bit no.H7.
Wheel impact socket #19
Brake caliper wind back tool
Ratchet wrench
Torque wrench
Rubber mallet
Crow bar
Wheel chock
Replacement: brake pads – Volvo V50 MW. AUTODOC experts recommend:
  • Perform the replacement of brake pads in complete set for each axis. This provides effective braking.
  • The replacement procedure is identical for all brake pads on the same axle.
  • All work should be done with the engine stopped.
Replacement: brake pads – Volvo V50 MW. Use the following procedure:
  1. Step 1
    How to change Brake Pads on Volvo V50 545 2003 - free PDF and video manuals
    Open the bonnet. Unscrew the brake fluid reservoir cap.
  2. Step 2
    How to replace VOLVO V50 (545) 2.0 D 2004 Brake Pads - step-by-step manuals and video guides
    Secure the wheels with chocks.
  3. Step 3
    Volvo V50 545 1.6 D 2005 Brake Pads replacement: free workshop manuals
    Loosen the wheel mounting bolts. Use wheel impact socket #19.
  4. Step 4
    Changing Brake Pads on VOLVO V50 (545) 2.4 2006 by yourself
    Raise the rear of the car and secure on supports.
  5. Step 5
    How to remove VOLVO V50 1.8 FlexFuel 2007 Brake Pads - online easy-to-follow instructions
    Unscrew the wheel bolts.
    AUTODOC recommends:
    Warning! To avoid injury, hold the wheel while unscrewing the fastening bolts. Volvo V50 MW
  6. Step 6
    How to replace Brake Pads on VOLVO V50 (545) 2008: download PDF manuals and video instructions
    Remove the wheel.
  7. Step 7
    How hard is it to do yourself: Brake Pads replacement on Volvo V50 545 D5 2009 - download illustrated guide
    Remove the dust boot caps of the brake caliper guide pins. Use a crowbar.
  8. Step 8
    Need to know how to renew Brake Pads on VOLVO V50 2010? This free workshop manual will help you to do it yourself
    Unscrew the brake caliper fastening. Use HEX No.H7. Use a ratchet wrench.
  9. Step 9
    Changing of Brake Pads on Volvo V50 545 2011 won't be an issue if you follow this illustrated step-by-step guide
    Detach the brake caliper retaining spring. Use a crowbar.
  10. Step 10
    VOLVO V50 2.0 D Brake Pads replacement: online guides and video tutorials
    Remove the brake caliper. Use a crowbar.
    Replacement: brake pads – Volvo V50 MW. Professionals recommend:
    Tie the caliper to the suspension or to the body with a wire without disconnecting from the brake hose to prevent depressurization of the brake system.Make sure that the brake caliper is not hanging on the brake hose.Don't press the brake pedal after the brake caliper has been removed. As a result, the piston can fall out from the brake cylinder, and brake fluid leakage and depressurization of the system may occur. Check the brake caliper bracket, brake caliper guide pins and boots. Clean them. Replace, if necessary.
  11. Step 11
    Replacing Brake Pads on Volvo V50 545 2003 2.0 D by yourself
    Remove the brake pads. Use a crowbar.
    Replacement: brake pads – Volvo V50 MW. Tip from AUTODOC:
    Measure the brake disc thickness. Upon reaching the wear limit the part must be replaced.
  12. Step 12
    V50 (545) 1.8 FlexFuel 2004 Brake Pads DIY replacement workshop manual
    Treat the brake caliper piston. Use a brake cleaner.
    AUTODOC recommends:
    Replacement: brake pads – Volvo V50 MW. After applying the spray, wait a few minutes.
  13. Step 13
    How to change Brake Pads on VOLVO V50 (545) 2005 - tips and tricks
    Press in the brake caliper piston. Use brake caliper wind back tool.
  14. Step 14
    Step-by-step recommendations for DIY replacement Volvo V50 545 2006 1.8 FlexFuel Brake Pads
    Treat the brake pads in the area where their surface comes into contact with the brake caliper bracket. Use anti-squeal paste.
    Replacement: brake pads – Volvo V50 MW. Tip:
    Make sure the disc surface is clean before installing the pads.
  15. Step 15
    DIY replacement of Brake Pads on VOLVO V50 (545) D2 2007 is not an issue anymore with our step-by-step tutorial
    Install new brake pads.
    Replacement: brake pads – Volvo V50 MW. AUTODOC recommends:
    Make sure the pads are installed with linings facing the disc.
Was this manual helpful?
Please rate this manual on a scale from 1 to 5. If you have any questions, feel free to ask us.
Users voted – 0
Your profile is your personal assistant.

It can track car expenses, keep a car log and replacement schedule, and save favourite materials, notes and documents

Install the AUTODOC CLUB app!
Your personal car expenses manager, maintenance tips, reminders about upcoming appointments and service intervals, DIY repair instructions – all this on your phone.
VOLVO V50 (545) Brake Pads replace by yourself - Scan QR-code and download AUTODOC CLUB app
Scan

To download the app:

  • - scan the QR code
  • - download from App Store
  • - download from Google Play
DIY VOLVO V50 (545) Brake Pads replacement - online guide
Tips & tricks for your VOLVO V50 (545)
View more
  • How to change Brake pad set on VOLVO V50 (545) D2 - replacement tricks
    How to paint a car with a spray can | AUTODOC tips
  • Changing Disc pads Volvo V50 545 2.0 D - Replacement Tips
    5 most common causes of oil leaks | AUTODOC tips
  • Maintenance Hacks - VOLVO V50 (545) 1.6 D Brake pad kit replacement guide
    5 car tips for a winter's day | AUTODOC tips
  • Replace Disc brake pads on Volvo V50 545 - free video tips
    How to detect vacuum leaks using a smoke machine | AUTODOC

Professional manuals for the most common VOLVO models